NHTSA owner reports · September 18, 2026 snapshot.
Equipment complaints
8 reportsClear category filter135,000 miles · Dec 15, 2010
Equipment
TL*THE CONTACT OWNS A 1999 CHEVROLET TAHOE. THE CONTACT STATED THAT THE SPARE TIRE UNDERNEATH THE VEHICLE WAS NOT CONNECTED AFTER CHECKING THE VEHICLE. THE CONTACT REALIZED THAT THE TIRE MAY HAVE SEPARATED FROM THE VEHICLE DUE TO A DEFECTIVE HOIST THAT HOLDS THE SPARE IN PLACE. HE HAD NO IDEA WHEN THE SPARE SEPARATED FROM THE VE…
Read full complaint
TL*THE CONTACT OWNS A 1999 CHEVROLET TAHOE. THE CONTACT STATED THAT THE SPARE TIRE UNDERNEATH THE VEHICLE WAS NOT CONNECTED AFTER CHECKING THE VEHICLE. THE CONTACT REALIZED THAT THE TIRE MAY HAVE SEPARATED FROM THE VEHICLE DUE TO A DEFECTIVE HOIST THAT HOLDS THE SPARE IN PLACE. HE HAD NO IDEA WHEN THE SPARE SEPARATED FROM THE VEHICLE. THE CONTACT INSPECTED HIS VEHICLE AND REPLACED THE HOIST. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS APPROXIMATELY 135,000. UPDATED 02/03/11*LJ THE CONSUMER STATED THE SPARE TIRE WEIGHT IS 75- 100 POUNDS AT 70 MPH. THE TIRE CAN BOUNCE IRREGULARLY AFTER RELEASED FROM THE VEHICLE. UPDATED 03/18/11
NHTSA ODI #10370748
84,000 miles · Jan 12, 2004
EquipmentSteering
I WAS/AM HAVING SOME STEERING PROBLEMS ON MY 1999 CHEVY TAHOE. ON OCT. 13, 2003 I TOOK MY TAHOE INTO MY DEALERSHIP. DISCOVERED MY SWAY BAR WAS CRACKED IN HALF. THEY SAID THEY HAVE NEVER SEEN SUCH A THING. I DO NOT DRIVE ON ANYTHING BUT ROAD SURFACES, NOR DO I DRIVE ERADICATED. IT COST ABOUT $300 TO HAVE IT REPLACED. THE DE…
Read full complaint
I WAS/AM HAVING SOME STEERING PROBLEMS ON MY 1999 CHEVY TAHOE. ON OCT. 13, 2003 I TOOK MY TAHOE INTO MY DEALERSHIP. DISCOVERED MY SWAY BAR WAS CRACKED IN HALF. THEY SAID THEY HAVE NEVER SEEN SUCH A THING. I DO NOT DRIVE ON ANYTHING BUT ROAD SURFACES, NOR DO I DRIVE ERADICATED. IT COST ABOUT $300 TO HAVE IT REPLACED. THE DEALERSHIP TOLD ME TO FILE A COMPLAINT AND SEE IF GM WOULD COVER COST. I NEVER HEARD BACK FROM GM. ALSO... I AM HAVING SOME STEERING ISSUES FOR ABOUT 5 MONTHS NOW, ABOUT THE SAME TIME MY SWAY BAR WAS CRACKED IN HALF. MY STEERING WHEEL SEEMS TO BE VERY SENSITIVE AND WILL JERK TO THE LEFT OR RIGHT QUITE OFTEN. I'LL BE HOLDING THE STEERING WHEEL AND ALL OF A SUDDEN IT JERK AN INCH OR TWO EITHER WAY FOR NO APPARENT REASON. IT HAPPENS MOST OFTEN WHEN I'M TURNING RIGHT, BUT WILL OCCUR AT LEAST ONCE OR TWICE EVERY MILE. SOME DAYS SEEM BETTER THAN OTHERS. I THOUGHT IT MIGHT BE MY TIRES SO I HAD THEM REPLACED AND HAD THE ALIGNMENT AND BALANCED ADJUSTED DECEMEBER 29TH, 2003. IT IS STILL DOING THE SAME THING. IT FEELS LIKE I'M GOING TO LOSE CONTROL OF MY STEERING. WHAT SHOULD I DO? THIS PROBLEM NEVER WENT AWAY AFTER I HAD MY SWAY BAR REPLACED. PLEASE ADVISE. THANK YOU! *LA
NHTSA ODI #10052995
Mileage unknown · Nov 30, 2003
EquipmentService Brakes, Hydraulic
I HAVE A 1999 CHEVROLET TAHOE 4X4 LT. IN THE LAST FEW MONTHS I HAVE HAD TO REPLACE THE FRONT BRAKE PADS AND ROTORS EVERY 5,000 MILES. I AM NOW LOOKING TO SPEND ANOTHER $600 TO REPLACE THEM AGAIN. I HAVE HAD THEM LOOKED AT EACH TIME, AND I AM TOLD THERE IS NOTHING WRONG WITH THE CALIPERS AND THEY HAVE NO REASON AS TO WHY THE R…
Read full complaint
I HAVE A 1999 CHEVROLET TAHOE 4X4 LT. IN THE LAST FEW MONTHS I HAVE HAD TO REPLACE THE FRONT BRAKE PADS AND ROTORS EVERY 5,000 MILES. I AM NOW LOOKING TO SPEND ANOTHER $600 TO REPLACE THEM AGAIN. I HAVE HAD THEM LOOKED AT EACH TIME, AND I AM TOLD THERE IS NOTHING WRONG WITH THE CALIPERS AND THEY HAVE NO REASON AS TO WHY THE ROTORS ARE BEING WARPED. THE MOST RECENT TIME I TOOK IN THE TAHOE I WAS TOLD THE ROTORS WERE BLUE DUE TO THE HEAT FROM THE PADS, BUT AGAIN THERE IS NOTHING WRONG WITH THE CALIPERS OR ANYTHING ELSE. I HAVE NOT BEEN CARRYING ANY HEAVY LOADS IN THE VEHICLE, OR DRIVING HARD. MOST OF THE MILES ARE FROM DRIVING ON THE HIGHWAY. I HAVE NEVER TAKEN IT OFF ROADING. *AK
NHTSA ODI #10048850
Mileage unknown · Aug 6, 2003
Equipment
THERE IS MILDEW OR MOLD IN THE AIR CONDITIONING VENTS WHICH CAUSES THE PASSENGER CABIN TO SMELL. DEALER ATTEMPTED TO FIX THE PROBLEM BY CLEANING THE AIR CONDITIONING SYSTEM, INSTALLING A DRAIN HOSE, AND PUTTING A DEODORIZER THROUGH THE AIR CONDITIONING SYSTEM. THE PROBLEM STILL EXISTS.*AK
NHTSA ODI #10032222
Mileage unknown · May 26, 2002
Electrical SystemEquipmentExterior Lighting
ADDITIONAL COMPONENTS REPLACED, THESE INCLUDED:ALTERNATOR REPLACED TWICED, BATTERY REPLACED, INJECTORS PLUGGING TREATED THREE TIMES, TAIL SHAFT LEAKING - REPLACED, INTAKE MANIFOLD REPLACED, STEREO REPLACED, TALL LAMP CIRCUIT BOARD REPLACED (BOTH, INTRUMENT CLUSTER REPLACED TWICE - UNSURE IN CURRENT MILEAGE READINGS ARE CORRECT,…
Read full complaint
ADDITIONAL COMPONENTS REPLACED, THESE INCLUDED:ALTERNATOR REPLACED TWICED, BATTERY REPLACED, INJECTORS PLUGGING TREATED THREE TIMES, TAIL SHAFT LEAKING - REPLACED, INTAKE MANIFOLD REPLACED, STEREO REPLACED, TALL LAMP CIRCUIT BOARD REPLACED (BOTH, INTRUMENT CLUSTER REPLACED TWICE - UNSURE IN CURRENT MILEAGE READINGS ARE CORRECT, HEAD LAMPS CONTINUE TO FLICKER WHIL EDRIVING REPLACED THREE TIMES, WATER PUMP REPLACED, BALL JOINTS REPLACED, AND STERRING COMPONENTS REPLACED. CONTINUAL PROBLEMS AND NO ANSWERS.
NHTSA ODI #762295
Mileage unknown · Aug 15, 2001
Electrical SystemEquipmentExterior Lighting
TRUCK WAS TAKEN IN REPEATEDLY FOR BRAKES, TRANSMISSION, AIR CONDITIONER AND HEADLIGHTS PRIOR TO WARRANTY EXPIRATION AND WAS TOLD THEY COULD NOT DUPLICATE THE PROBLEM OR IT WAS UNDER "CHEV SPECS" OR WE WERE EXPERIENCING ANTI-LOCK BRAKES. WATER PUMP BEGAN LEAKING AND HAD TO BE REPLACED 2200 MILES OUTSIDE OF WARRANTY. ENTIRE BRAK…
Read full complaint
TRUCK WAS TAKEN IN REPEATEDLY FOR BRAKES, TRANSMISSION, AIR CONDITIONER AND HEADLIGHTS PRIOR TO WARRANTY EXPIRATION AND WAS TOLD THEY COULD NOT DUPLICATE THE PROBLEM OR IT WAS UNDER "CHEV SPECS" OR WE WERE EXPERIENCING ANTI-LOCK BRAKES. WATER PUMP BEGAN LEAKING AND HAD TO BE REPLACED 2200 MILES OUTSIDE OF WARRANTY. ENTIRE BRAKE SYSTEM, LINES-CALIPERS, EVERYTHING HAD TO BE REPLACED BECAUSE "FOREIGN FLUID CORRODED" THE SYSTEM. NO ONE HAS TOUCHED THE BRAKES BUT THE DEALER. WE REPEATEDLY COMPLAINED ABOUT THE BRAKES TAKING TOO LONG TO STOP THE VEHICLE, HAVING A SPONGY FEEL AND ABSOLUTELY NO CONFIDENCE THAT THEY WOULD STOP IN AN EMERGENCY SITUATION. OVERALL, THE BRAKES JUST DID NOT FEEL SAFE AND WE REPORTED THIS WHEN THE VEHICLE WAS STILL UNDER WARRANTY. INTAKE MANIFOLD IS LEAKING AND NEEDS TO BE REPLACED. BATTERY EXPLODED AND LEAKED BATTERY ACID EVERYWHERE DAMAGING OTHER ENGINE PARTS. TRANSMISSION IS IN NEED OF AN OVERHAUL/REPLACEMENT EITHER AS A DIRECT RESULT OF THE BATTERY EXPLODING OR MERE COINCIDENCE CONSIDERING WE HAVE ALWAYS COMPLAINED THAT SOMETHING WAS WRONG WITH THE TRANSMISSION AND YOU COULD PUSH THE TRUCK WHILE IN PARK A FULL FOOT. THE AIR CONDITIONER HAS ALWAYS LEAKED AFTER DRIVING APPROX. 2 HR AS WELL AS THE DRIVER'S SIDE HIGH BEAM HEADLIGHT ALWAYS HAS WATER IN IT. DETAILED COMPLAINTS HAVE BEEN FILED WITH THE ATTORNEY GENERALS OF AZ AND FL, AS WELL AS COPIES SENT TO THE DEALER, MANUFACTURER AND LEASING COMPANY INVOLVED. CHEVROLET SHOULD BE ASHAMED OF THE SHODDY PRODUCT THAT ROLLED OFF THEIR ASSEMBLY LINE AND THE MANNER IN WHICH THEY CONDUCT BUSINESS SURROUNDING CONSUMER COMPLAINTS GENERATED AS A DIRECT RESULT FROM POOR WORKMANSHIP AT ONE OF THEIR FACTORIES. THERE IS A LONG LIST OF "COSMETIC" DEFECTS AS WELL. FOR INSTANCE, THE CUSTOM LEATHER SEATS THAT WE PAID EXTRA FOR ARE WEARING HOLES IN THEM; THE DRIVER'S SIDE DOOR HANDLE IS CRACKED, DRINK HOLDERS ARE RUSTING, AND THE LIST GOES ON AND ON.
NHTSA ODI #750538
Mileage unknown · Aug 9, 1999
Engine And Engine CoolingEquipmentStructure
TIME OF DELEVERY BUMPER WAS RUSTED. YH
NHTSA ODI #547814
Mileage unknown · Aug 3, 1999
EquipmentSeat Belts
REAR SEAT BELT WON'T LOCK, AND THE RADIO DOESN'T WORK. *AK
NHTSA ODI #844165
NHTSA investigations
5PE05020 · Unwanted LOW-SPEED Abs Activation
Opened Apr 28, 2005 · Closed Sep 13, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Additional source detail variants (2)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
PE03026 · Steel Wheel Rim Fracture
Opened Jun 12, 2003 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Wheels; Wheels:multi Piece; Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Wheels
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:multi Piece
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02015 · Throttle Sticking Closed
Opened Aug 1, 2002 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS INVESTIGATION INVOLVES THE GENERAL MOTORS CORPORATION (GM)THROTTLE BODY (TB) UTILIZED IN MODEL YEAR (MY) 1999-2002 SILVERADO, SIERRA, TAHOE, SUBURBAN, AVALANCHE AND YUKON (SUBJECT VEHICLE(S)) WITH 4.8L, 5.3L, AND 6.0L ENGINES. THE TB VALVE MAY INTERMITTENTLY STICK IN A CLOSED POSITION.IN SUCH A SITUATION, AN OPERATOR MAY APPLY ADDITIONAL ACCELERATOR PEDAL FORCE TO INCREASE ENGINE SPEED.THE APPLICATION OF ADDITIONAL ACCELERATOR PEDAL FORCE, TO OPEN A STUCK THROTTLE VALVE, MAY OPEN THE THROTTLE VALVE MORE THAN INTENDED AND, IN TURN, ACCELERATE THE ENGINE AND VEHICLE MORE THAN INTENDED AND REASONABLY EXPECTED BY THE DRIVER.ON AUGUST 1, 2002, THE OFFICE OF DEFECTS INVESTIGATION (ODI), OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), OPENED THIS ENGINEERING ANALYSIS.THE INVESTIGATION REVEALED THAT TWO FACTORS MAY CAUSE THE DEFECT: 1) TB MANUFACTURING PROCESS PROBLEMS; AND 2) ACCUMULATION OF DEPOSITS (A PCV SYSTEM BY-PRODUCT) ON OR AROUND THE TB THROTTLE VALVE AND BORE.ODI CONCLUDES THAT THE TB PERFORMS IN A DEFECTIVE MANNER AFTER ANALYZING GM?S DATA SUBMISSIONS, AND TEST DATA COLLECTED BY THE VEHICLE RESEARCH AND TEST CENTER (VRTC).FIFTY-NINE CRASHES ARE ALLEGED TO HAVE OCCURRED AS A RESULT OF GM?S TB DEFECT.THE MAJORITY OF THE CRASHES INVOLVE A SINGLE VEHICLE, ENGAGING IN A CLOSE QUARTER VEHICLE MANEUVER (OR LOW SPEED), AND CAUSING ONLY MINOR PROPERTY DAMAGE.FOUR OUT OF THE FIFTY-NINE CRASHES INVOLVE INJURY, AND THOSE INJURIES WERE MINOR.ALTHOUGH GM?S TB IS DEFECTIVE, BASED ON THE EVIDENCE GATHERED, ODI HAS FOUND THAT THE ACCELERATOR PEDAL FORCE REQUIRED TO OPEN A STUCK THROTTLE VALVE IS NEGLIGIBLE, AND THE THROTTLE VALVE DOES NOT STICK IN THE OPEN POSITION.THEREFORE THIS ENGINEERING ANALYSIS (EA02-015) WILL BE CLOSED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FOR A DETAILED DISCUSSION OF THE TB COMPONENT AND TESTING, PLEASE SEE THE ATTACHED REPORT.
PE01023 · Seat Belt Anchorage Separation
Opened Jul 17, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ODI HAS RECEIVED ONE (1) COMPLAINT ALLEGING THAT THE 2ND ROW PASSENGER-SIDE SEAT BELT RELEASE BUCKLE ANCHOR DETACHED FROM SEAT FRAME DURING A SIDE IMPACT CRASH.DURING THE CRASH, THE OCCUPANT WAS THROWN FROM HIS SEAT, PARTIALLY EJECTED THROUGH THE REAR QUARTER WINDOW OF THE VEHICLE.OCCUPANT SUSTAINED INJURY.GM HAS SUBSEQUENTLY CHANGED SEAT BELT ANCHORING DESIGN IN MY 2000. ODI HAS COMPLETED A PRELIMINARY INVESTIGATION AND HAS DETERMINED THAT FURTHER INFORMATION IS NEEDED TO DETERMINE WHETHER A SAFETY DEFECT EXISTS.
EA99011 · Erratic Power Steering Assist While Driv
Opened May 12, 1999 · Closed Feb 27, 2001
Status: closed (inferred from source dates) · Steering
THE OFFICE OF DEFECT INVESTIGATION (ODI) HAS INVESTIGATED ALLEGATIONS OF POWER STEERING ASSIST FLUCTUATIONS IN THE SUBJECT VEHICLES.FOR DETAILS AND A BASIS FOR THE INVESTIGATION CONCLUSIONS, PLEASE SEE THE CLOSING REPORT IN THE EA99-011 PUBLIC FILE.ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREND IN THE SUBJECT VEHICLE POPULATION.FUTHER EXPENDITURE OF AGENCY RESOURCES ON THIS SUBJECT DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ENGINEERING IS CLOSED.
Illustration