NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
47 reportsClear category filter218,000 miles · May 23, 2016
Electrical SystemFire
TL* THE CONTACT OWNS A 1999 CHEVROLET TAHOE. THE CONTACT STATED THAT THE PLASTIC UNDER THE IGNITION SWITCH WAS MELTING WITHOUT WARNING. THE CONTACT ALSO STATED THAT THE WIRES BEGAN TO MELT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT DEALER WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH ASSEMBLY FAILED AND NEEDED TO BE REPLACED. TH…
Read full complaint
TL* THE CONTACT OWNS A 1999 CHEVROLET TAHOE. THE CONTACT STATED THAT THE PLASTIC UNDER THE IGNITION SWITCH WAS MELTING WITHOUT WARNING. THE CONTACT ALSO STATED THAT THE WIRES BEGAN TO MELT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT DEALER WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH ASSEMBLY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 218,000.
NHTSA ODI #10870317
200,000 miles · Aug 12, 2015
Electrical System
TL* THE CONTACT OWNS A 1999 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE SECURITY WARNING INDICATORS ILLUMINATED AND THE VEHICLE STALLED. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT IT MIGHT HAVE BEEN THE PASS KE…
Read full complaint
TL* THE CONTACT OWNS A 1999 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE SECURITY WARNING INDICATORS ILLUMINATED AND THE VEHICLE STALLED. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT IT MIGHT HAVE BEEN THE PASS KEY THAT FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.
NHTSA ODI #10748267
187,000 miles · Mar 11, 2015
Electrical System
TL*THE CONTACT OWNS A 1999 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, THE TECHNICIAN INFORMED THE CONTACT THAT THE VEHICLE WAS OPERATING AS DESIGNED. IN ADDITION…
Read full complaint
TL*THE CONTACT OWNS A 1999 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, THE TECHNICIAN INFORMED THE CONTACT THAT THE VEHICLE WAS OPERATING AS DESIGNED. IN ADDITION, THE TECHNICIAN STATED THAT THE PASS CODE SENSOR NEEDED TO BE REPLACED EVERY TWO YEARS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 187,000.
NHTSA ODI #10693531
116,000 miles · Apr 20, 2014
Electrical SystemEngineService Brakes
SUSPECTED DEFECTIVE IGNITION SWITCH AND/OR IGNITION SWITCH PASSLOCK SECURITY ON OR ABOUT JAN 17 2014 I WAS TRAVELING ABOUT 30 MPH WHEN THE ENGINE STALLED WITH LOSS OF POWER STEERING AND BRAKES. I WAS ABLE TO STOP WITHOUT INCIDENT. AFTER 10-15 MINUTES I WAS ABLE TO RESTART THE VEHICLE AND DRIVE AS NORMAL. FOR SEVERAL YEARS…
Read full complaint
SUSPECTED DEFECTIVE IGNITION SWITCH AND/OR IGNITION SWITCH PASSLOCK SECURITY ON OR ABOUT JAN 17 2014 I WAS TRAVELING ABOUT 30 MPH WHEN THE ENGINE STALLED WITH LOSS OF POWER STEERING AND BRAKES. I WAS ABLE TO STOP WITHOUT INCIDENT. AFTER 10-15 MINUTES I WAS ABLE TO RESTART THE VEHICLE AND DRIVE AS NORMAL. FOR SEVERAL YEARS AFTER DRIVING THE IGNITION KEY WAS WARM OR HOT WHEN REMOVED FROM THE SWITCH. IN EARLY 2013 THE ENGINE WOULD OCCASIONALLY STALL IMMEDIATELY AFTER STARTING BUT WOULD RESTART AFTER WAITING 5 TO 10 MINUTES. ON JAN 14 WHEN AT A GAS STATION THE ENGINE STALLED BUT I WAS ABLE TO MOVE THE CAR TO THE CURB. AFTER 10-15 MINUTES I WAS ABLE TO RESTART AND DRIVE NORMAL. * PASSLOCK IGNITION SECURITY FEATURE IS WIDELY REPORTED TO BE A CAUSE OF THESE SYMPTOMS. *TR
NHTSA ODI #10583740
140,000 miles · Dec 9, 2013
Electrical SystemVehicle Speed Control
I PURCHASED MY 1999 CHEVY TAHOE IN 2004 WITH 87,000 MILES FROM ORIGINAL OWNER. I RECEIVED ALL MAINTENANCE RECORDS FROM ORIGINAL OWNER, AS WELL AS ORIGINAL DEALERSHIP PRICE/OPTION STICKER. I NOTICED ONCE OVER 100,000 MILES THERE WAS AN ELECTRICAL MALFUNCTION OR PROBLEM, LIKE A POWER SURGE ANYTIME THE POWER WINDOW BUTTONS ARE D…
Read full complaint
I PURCHASED MY 1999 CHEVY TAHOE IN 2004 WITH 87,000 MILES FROM ORIGINAL OWNER. I RECEIVED ALL MAINTENANCE RECORDS FROM ORIGINAL OWNER, AS WELL AS ORIGINAL DEALERSHIP PRICE/OPTION STICKER. I NOTICED ONCE OVER 100,000 MILES THERE WAS AN ELECTRICAL MALFUNCTION OR PROBLEM, LIKE A POWER SURGE ANYTIME THE POWER WINDOW BUTTONS ARE DEPRESSED AND WHEN I ACCELERATE, THERE IS A SURGE AND WHEN TRUCK SLOWS DOWN OR IS IN PARK, THERE IS N SURGE. THERE IS SUDDEN ENERGY! THERE IS ALSO A PROBLEM WITH THE DASHBOARD/RADIO AND SWITCH BUTTONS BELOW LIGHTS WORKING. THEY HAVE FAILED! ELECTRICAL PROBLEMS CAN CAUSE FIRES AND I HAVE NOTICED IT IS NOT MY TAHOE ONLY WITH THE SAME EXISTING ELECTRICAL PROBLEMS, AS I HAVE BEEN LOOKING FOR A SECOND VEHICLE, AS I HAVE MY KIDS BOTH OF DRIVING AGE AND MY 1999 TAHOE LS IS MY ONLY VEHICLE. I FEEL SAFE ON THE ROAD IN MY TAHOE. I LOVE THE FOUR WHEEL DRIVE OPTION, AS I LIVE IN MINNESOTA AND I COULD NOT LIVE WITHOUT IT OVER THE WINTER MONTHS! I AM ALSO VERY PROUD TO POINT OUT, MY TAHOE HAS 343,000+ MILES ON IT AND STILL GOING STRONG!!!! I CAN NOT AFFORD A NEW TAHOE, AS I AM ON A FIXED DISABILITY INCOME NOW, SO I AM SHOPPING FOR A 1999 OR NEWER AT A REASONABLE PRICE. I AM SATISFIED WITH ALL THE YEARS I HAVE DRIVEN MINE AND HOPE TO GET MANY MORE YEARS OUT OF IT. PEOPLE ARE AMAZED WHEN I TELL THEM HOW MANY MILES ARE ACTUAL MILES ON MY TAHOE. I AM AMAZED, AS WELL. :) [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10555393
147,000 miles · Dec 7, 2010
Electrical System
TL* THE CONTACT OWNS A 1999 CHEVROLET TAHOE. THE CONTACT STATED THAT WHEN STARTING THE VEHICLE, THE ENGINE WOULD ONLY REMAIN ON FOR A FEW SECONDS BEFORE STALLING. THE SECURITY WARNING LIGHT WAS ILLUMINATED AND THE VEHICLE WOULD RESET INDEPENDENTLY. THE FAILURE WOULD ONLY OCCUR IN COLDER WEATHER AND THE CONTACT STATED HE HAD EXPE…
Read full complaint
TL* THE CONTACT OWNS A 1999 CHEVROLET TAHOE. THE CONTACT STATED THAT WHEN STARTING THE VEHICLE, THE ENGINE WOULD ONLY REMAIN ON FOR A FEW SECONDS BEFORE STALLING. THE SECURITY WARNING LIGHT WAS ILLUMINATED AND THE VEHICLE WOULD RESET INDEPENDENTLY. THE FAILURE WOULD ONLY OCCUR IN COLDER WEATHER AND THE CONTACT STATED HE HAD EXPERIENCED THE FAILURE AT LEAST TEN TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND WAS NOT REPAIRED. THE CONTACT REPLACED THE BATTERY IN THE VEHICLE BUT THE FAILURE PERSISTED. THE APPROXIMATE FAILURE MILEAGE WAS 147,000.
NHTSA ODI #10369533
94,550 miles · Feb 6, 2009
Electrical SystemFuel System, Gasoline
WENT TO VISIT INLAWS IN CANADA FOR CHRISMAS, ARRIVED LATE AT NITE. GOT UP IN THE MORNING TRUCK WILL NOT START, LOCAL MECHANIC DIAGNOSED IT AS THE ANTI-THEFT SYSTEM,{ PASSLOCK } HE GOT IT RUNNING AND SAID I NEED TO GO TO THE NEAREST DEALER TO GET IT REPROGRAMMED BE FORE IT HAPPENS AGAIN. NEXT MORNING WAS GOING TO DEALER IT WOULD…
Read full complaint
WENT TO VISIT INLAWS IN CANADA FOR CHRISMAS, ARRIVED LATE AT NITE. GOT UP IN THE MORNING TRUCK WILL NOT START, LOCAL MECHANIC DIAGNOSED IT AS THE ANTI-THEFT SYSTEM,{ PASSLOCK } HE GOT IT RUNNING AND SAID I NEED TO GO TO THE NEAREST DEALER TO GET IT REPROGRAMMED BE FORE IT HAPPENS AGAIN. NEXT MORNING WAS GOING TO DEALER IT WOULD NOT START AGAIN. THREE DAYS LATTER IT FINALLY STARTED. DEALER CHARGED $330 TO REPROGRAM {PASSLOCK} TWO DAYS LATTER WHEN I WAS GOING HOME IT WOULD NOT START AGAIN. I HAVEN'T GOT IT RUNNING YET. WAS SUPPOSED TO BE BACK TO WORK IN TEXAS THREE DAYS LATTER. I GOT FIRED , AND I'M STILL STUCK IN CANADA AND BROKE NOW. THANK YOU CHEVROLET!! *TR
NHTSA ODI #10257759
125,842 miles · Dec 8, 2008
Electrical System
1999 CHEVY TAHOE A/C BLOWER MOTOR INOPERATIVE. MECHANIC TRACED RELATED ELECTRICAL CIRCUITS. PINPOINT IMMEDIATE PROBLEM TO FAULTY A/C CONTROL HEAD AND BURNT CONNECTOR. THIS PROBLEM WAS A FIRE HAZARD AND HAD TO RESOLVED OR COMPLETELY DISABLED TO ELIMINATE THE POSSIBILITY OF FIRE. LABOR AND PARTS COST $700.00. *TR
NHTSA ODI #10251034
Mileage unknown · Apr 4, 2008
Electrical System
SPEEDOMETER NOT WORKING MOST OF THE TIME, IT STICKS AT 30 MPH WHEN TRAVELING 70 MPH AND FLUCTUATES SOMETIMES IT WORKS AND SOMETIMES IT DOES NOT, I HAVE SPOKE TO SEVERAL MECHANICS ABOUT THE PROBLEM AND NO ONE KNOWS FOR SURE WHAT IT COULD BE WITH OUT A HIGH DOLLAR FEE. I SEARCHED ONLINE AND FOUND THERE ARE NUMEROUS COMPLAINTS ABO…
Read full complaint
SPEEDOMETER NOT WORKING MOST OF THE TIME, IT STICKS AT 30 MPH WHEN TRAVELING 70 MPH AND FLUCTUATES SOMETIMES IT WORKS AND SOMETIMES IT DOES NOT, I HAVE SPOKE TO SEVERAL MECHANICS ABOUT THE PROBLEM AND NO ONE KNOWS FOR SURE WHAT IT COULD BE WITH OUT A HIGH DOLLAR FEE. I SEARCHED ONLINE AND FOUND THERE ARE NUMEROUS COMPLAINTS ABOUT THE SAME PROBLEM. *TR
NHTSA ODI #10223330
114,238 miles · Sep 29, 2006
Electrical System
DT*: THE CONTACT STATED THE AIR CONDITIONING AND HEATER FAN SWITCH, CONNECTOR PLUG AND ATTACHED INSULATION TO THE WIRING OVERHEATED AND MELTED, WHILE TRAVELING 55 MPH. THE SERVICE DEALER AND MANUFACTURER WERE NOTIFIED.
NHTSA ODI #10169588
NHTSA investigations
5PE05020 · Unwanted LOW-SPEED Abs Activation
Opened Apr 28, 2005 · Closed Sep 13, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Additional source detail variants (2)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
PE03026 · Steel Wheel Rim Fracture
Opened Jun 12, 2003 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Wheels; Wheels:multi Piece; Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Wheels
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:multi Piece
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02015 · Throttle Sticking Closed
Opened Aug 1, 2002 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS INVESTIGATION INVOLVES THE GENERAL MOTORS CORPORATION (GM)THROTTLE BODY (TB) UTILIZED IN MODEL YEAR (MY) 1999-2002 SILVERADO, SIERRA, TAHOE, SUBURBAN, AVALANCHE AND YUKON (SUBJECT VEHICLE(S)) WITH 4.8L, 5.3L, AND 6.0L ENGINES. THE TB VALVE MAY INTERMITTENTLY STICK IN A CLOSED POSITION.IN SUCH A SITUATION, AN OPERATOR MAY APPLY ADDITIONAL ACCELERATOR PEDAL FORCE TO INCREASE ENGINE SPEED.THE APPLICATION OF ADDITIONAL ACCELERATOR PEDAL FORCE, TO OPEN A STUCK THROTTLE VALVE, MAY OPEN THE THROTTLE VALVE MORE THAN INTENDED AND, IN TURN, ACCELERATE THE ENGINE AND VEHICLE MORE THAN INTENDED AND REASONABLY EXPECTED BY THE DRIVER.ON AUGUST 1, 2002, THE OFFICE OF DEFECTS INVESTIGATION (ODI), OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), OPENED THIS ENGINEERING ANALYSIS.THE INVESTIGATION REVEALED THAT TWO FACTORS MAY CAUSE THE DEFECT: 1) TB MANUFACTURING PROCESS PROBLEMS; AND 2) ACCUMULATION OF DEPOSITS (A PCV SYSTEM BY-PRODUCT) ON OR AROUND THE TB THROTTLE VALVE AND BORE.ODI CONCLUDES THAT THE TB PERFORMS IN A DEFECTIVE MANNER AFTER ANALYZING GM?S DATA SUBMISSIONS, AND TEST DATA COLLECTED BY THE VEHICLE RESEARCH AND TEST CENTER (VRTC).FIFTY-NINE CRASHES ARE ALLEGED TO HAVE OCCURRED AS A RESULT OF GM?S TB DEFECT.THE MAJORITY OF THE CRASHES INVOLVE A SINGLE VEHICLE, ENGAGING IN A CLOSE QUARTER VEHICLE MANEUVER (OR LOW SPEED), AND CAUSING ONLY MINOR PROPERTY DAMAGE.FOUR OUT OF THE FIFTY-NINE CRASHES INVOLVE INJURY, AND THOSE INJURIES WERE MINOR.ALTHOUGH GM?S TB IS DEFECTIVE, BASED ON THE EVIDENCE GATHERED, ODI HAS FOUND THAT THE ACCELERATOR PEDAL FORCE REQUIRED TO OPEN A STUCK THROTTLE VALVE IS NEGLIGIBLE, AND THE THROTTLE VALVE DOES NOT STICK IN THE OPEN POSITION.THEREFORE THIS ENGINEERING ANALYSIS (EA02-015) WILL BE CLOSED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FOR A DETAILED DISCUSSION OF THE TB COMPONENT AND TESTING, PLEASE SEE THE ATTACHED REPORT.
PE01023 · Seat Belt Anchorage Separation
Opened Jul 17, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ODI HAS RECEIVED ONE (1) COMPLAINT ALLEGING THAT THE 2ND ROW PASSENGER-SIDE SEAT BELT RELEASE BUCKLE ANCHOR DETACHED FROM SEAT FRAME DURING A SIDE IMPACT CRASH.DURING THE CRASH, THE OCCUPANT WAS THROWN FROM HIS SEAT, PARTIALLY EJECTED THROUGH THE REAR QUARTER WINDOW OF THE VEHICLE.OCCUPANT SUSTAINED INJURY.GM HAS SUBSEQUENTLY CHANGED SEAT BELT ANCHORING DESIGN IN MY 2000. ODI HAS COMPLETED A PRELIMINARY INVESTIGATION AND HAS DETERMINED THAT FURTHER INFORMATION IS NEEDED TO DETERMINE WHETHER A SAFETY DEFECT EXISTS.
EA99011 · Erratic Power Steering Assist While Driv
Opened May 12, 1999 · Closed Feb 27, 2001
Status: closed (inferred from source dates) · Steering
THE OFFICE OF DEFECT INVESTIGATION (ODI) HAS INVESTIGATED ALLEGATIONS OF POWER STEERING ASSIST FLUCTUATIONS IN THE SUBJECT VEHICLES.FOR DETAILS AND A BASIS FOR THE INVESTIGATION CONCLUSIONS, PLEASE SEE THE CLOSING REPORT IN THE EA99-011 PUBLIC FILE.ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREND IN THE SUBJECT VEHICLE POPULATION.FUTHER EXPENDITURE OF AGENCY RESOURCES ON THIS SUBJECT DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ENGINEERING IS CLOSED.
Illustration