SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

1991 Chevrolet Suburban

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 1991 Chevrolet Suburban do not stand out strongly from the model-year median of 118.

About this comparison →
52Owner complaints

Model-year median: 118

3Recall campaigns

View recall details →

1Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
30
198862
198954
199052
1991189
1992499
1993858
1994
Compare all Suburban years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Seats
12Service Brakes, Hydraulic
11Power Train
9Tires
7Engine And Engine Cooling
4
All reported categories
Seat Belts
4Electrical System
2Steering
2Unknown Or Other
2Wheels
2Fuel System, Gasoline
1Service Brakes, Air
1Structure
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 5 of 52 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Seats. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

4 crash reports6 fire reports3 injury reports

Wheels complaints

2 reports
Clear category filter
Mileage unknown · Jun 24, 2002
Wheels

WHILE DRIVING 60-65 MPH AND TOWING A TRAILER, 2 LUG BOLTS SNAPPED OFF THE HUB AND ONE OTHER BOLT WAS LOOSE CAUSING VEHICLE TO JACKKNIFE AND DROVE OFF THE ROAD. THE TRAILER SEPARATED FROM THE VEHICLE AND TURNED IN A DITCH. THE REMAINING LUG BOTLS WERE MISSING THREADS. THERE WERE NO INJURIES.(OHIO TRAFFIC REPOERT#10-90-210) *T…

Read full complaint

WHILE DRIVING 60-65 MPH AND TOWING A TRAILER, 2 LUG BOLTS SNAPPED OFF THE HUB AND ONE OTHER BOLT WAS LOOSE CAUSING VEHICLE TO JACKKNIFE AND DROVE OFF THE ROAD. THE TRAILER SEPARATED FROM THE VEHICLE AND TURNED IN A DITCH. THE REMAINING LUG BOTLS WERE MISSING THREADS. THERE WERE NO INJURIES.(OHIO TRAFFIC REPOERT#10-90-210) *TT

NHTSA ODI #566202

Mileage unknown · Feb 28, 1995
WheelsCrashInjury

SIX WHEEL STUDS SHEARED OFF AND FOUR WERE RUSTED THROUGH, RESULTING IN WHEEL LOSS AND VEHICLE ROLLOVER ONCE TOTALLED. TT

NHTSA ODI #960760

Official recalls

3

96V226000 · Seats

Nov 4, 1996

THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL VETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.

Consequence & remedy

Consequence: IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULD ALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLE CONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.

93V119000 · Service Brakes, Hydraulic:foundation Components:disc:rotor

Aug 2, 1993

SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.

Consequence & remedy

Consequence: SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.

Remedy: REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.

93V016000 · Power Train:automatic Transmission

Feb 1, 1993

UNANTICIPATED HEAT IN THE TRANSMISSION CAN FORCE THE TRANSMISSION FLUID OUT OF THE VENT TUBE.

Consequence & remedy

Consequence: THE VENTED TRANSMISSION FLUID CAN CATCH FIRE IF EXPOSEDTO A SOURCE OF IGNITION.

Remedy: INSTALL A LONGER TRANSMISSION VENT HOSE ROUTED TO THE LEFT SIDE OF THE ENGINE COMPARTMENT OF THE VEHICLE.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

EA94029 · Engine Compartment Fires

Opened Jul 29, 1994 · Closed Jul 31, 1996

Status: closed (inferred from source dates) · Engine And Engine Cooling

AN ALLEGED MALFUNCTION IN THE ATLERNATOR RESULTING IN ENGINE COMPARTMET FIRES.