NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
52 reports180,000 miles · Sep 16, 2020
EngineFuel System, Gasoline
TL* THE CONTACT OWNS A 2015 CHEVROLET SILVERADO 3500. THE CONTACT STATED WHILE PARKED, THE HIGH-PRESSURE FUEL PUMP FAILED WITHOUT WARNING. THE CONTACT STATED HE HEARD AN ABNORMAL NOISE AND TURNED OFF AND RESTARTED THE VEHICLE HOWEVER, THE VEHICLE SHUTOFF WITHOUT WARNING. THE CONTACT HAD THE VEHICLE TOWED TO WOODLAND CHEVROLET (5…
Read full complaint
TL* THE CONTACT OWNS A 2015 CHEVROLET SILVERADO 3500. THE CONTACT STATED WHILE PARKED, THE HIGH-PRESSURE FUEL PUMP FAILED WITHOUT WARNING. THE CONTACT STATED HE HEARD AN ABNORMAL NOISE AND TURNED OFF AND RESTARTED THE VEHICLE HOWEVER, THE VEHICLE SHUTOFF WITHOUT WARNING. THE CONTACT HAD THE VEHICLE TOWED TO WOODLAND CHEVROLET (530 QUALITY CIR, WOODLAND, CA 95776) WHERE THE VEHICLE WAS DIAGNOSED WITH A HIGH-PRESSURE FUEL PUMP FAILURE. THE VEHICLE REMAINED AT THE DEALER UNREPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND A CASE WAS FILED. THE FAILURE MILEAGE WAS 180,000.
NHTSA ODI #11355336
43,000 miles · Sep 14, 2020
Electrical System
ENGINE LOSS POWER WHILE PULLING A LOADED HORSE TRAILER AROUND 10,000 POUNDS. ERROR MESSAGE SAYING POWER HAS BEEN REDUCED. THE TOP SPEED WHILE ON A HILL WAS ABIUT 15 MILES AN HOUR.TRACTOR TRAILLERS HAD TO MANUVER AROUND ME DUE TO THE LOW SPEED ON AN EXPRESSWAY WITH 70 MILE AN HOUR SPEED LIMIT. THE DEALER SAID CAUSE WAS FRAYING…
Read full complaint
ENGINE LOSS POWER WHILE PULLING A LOADED HORSE TRAILER AROUND 10,000 POUNDS. ERROR MESSAGE SAYING POWER HAS BEEN REDUCED. THE TOP SPEED WHILE ON A HILL WAS ABIUT 15 MILES AN HOUR.TRACTOR TRAILLERS HAD TO MANUVER AROUND ME DUE TO THE LOW SPEED ON AN EXPRESSWAY WITH 70 MILE AN HOUR SPEED LIMIT. THE DEALER SAID CAUSE WAS FRAYING OF THE WIRING HARNESS PROBABLY AROUND THE TURBO. AFTER RESEARCH ON THE INTERNET, I FOUND THIS WAS A FREQUENT PROBLEM. TRUCK ONLY HAS 43,000 MILES ON IT. I HAVE REQUESTED THE OLD WIRING HARNESS FOR INSPECTION.
NHTSA ODI #11354990
7 miles · Sep 12, 2020
Power Train
AT HIGH WAY SPEEDS APPROX. 67 MPH TO 80 TRUCK STARTS TO VIBRATE VERY BADLY. TAKEN TO TIRE SHOP AND BALANCE CHECKS FINE. FOUND THAT THIS YR AND MAKE GM HAS HAD VIBRATION ISSUES. AROUND 2017 TRUCK WAS TAKEN TO GM DEALER AND THEY HAD TO REPLACE TRANSMISSION TORQ CONVERTER WAS BAD ALSO.
NHTSA ODI #11354602
96,000 miles · Sep 9, 2020
EngineFuel/propulsion SystemPower Train
CP4 FUEL PUMP FAILURE AND ENGINE FAILURE- STARTED TRUCK THAT MORNING, 5 MIN LATER IT SHUT OFF AND HASN'T STARTED AGAIN. HUB EXPLODED MAKING 4WHEEL DRIVE IMPOSSIBLE WHEN DRIVING DOWN HEY. AC BLENDER STOPPED WORKING AC VENTS BLOW HOT AIR ON RIGHT SIDE OF DASH WHILE IN MOTION.
NHTSA ODI #11353898
114,000 miles · Apr 27, 2020
Fuel/propulsion System
TL* THE CONTACT OWNS A 2015 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT COASTED TO THE SIDE OF THE ROADWAY. THE VEHICLE WAS TOWED TO PINEGAR CHEVROLET BUICK GMC OF BRANSON (163 ADAIR RD, BRANSON, MO 65616, (866) 311-4731) TO BE DIAGNOSED. …
Read full complaint
TL* THE CONTACT OWNS A 2015 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT COASTED TO THE SIDE OF THE ROADWAY. THE VEHICLE WAS TOWED TO PINEGAR CHEVROLET BUICK GMC OF BRANSON (163 ADAIR RD, BRANSON, MO 65616, (866) 311-4731) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FUEL SYSTEM WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND NOTIFIED OF THE FAILURE. THE MANUFACTURER INFORMED THE CONTACT OF AN ONGOING CLASS ACTION LAWSUIT HOWEVER, THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 114,000.
NHTSA ODI #11322410
69,000 miles · Jan 16, 2020
Structure
WATER LEAKING INTO THE VEHICLE FROM THE ONSTAR/XM ANTENNA. GM ISSUES A TSB FOR THE ISSUE IN 2017. WILL NOT WARRANTY THE NECESSARY REPAIRS AFTER THE INITIAL BUMPER TO BUMPER COVERAGE. TURNED A CORNER GOT A LAP FULL OF WATER, LUCKILY I WASN'T IN HEAVY TRAFFIC. HEADLINER AND CARPET ARE WET, PROBABLY THE ELECTRONICS AS WELL. NOT SUR…
Read full complaint
WATER LEAKING INTO THE VEHICLE FROM THE ONSTAR/XM ANTENNA. GM ISSUES A TSB FOR THE ISSUE IN 2017. WILL NOT WARRANTY THE NECESSARY REPAIRS AFTER THE INITIAL BUMPER TO BUMPER COVERAGE. TURNED A CORNER GOT A LAP FULL OF WATER, LUCKILY I WASN'T IN HEAVY TRAFFIC. HEADLINER AND CARPET ARE WET, PROBABLY THE ELECTRONICS AS WELL. NOT SURE HOW LONG IT HAS BEEN LEAKING JUST NOTICED IT.
NHTSA ODI #11299933
Mileage unknown · Jan 11, 2020
Electrical SystemFuel/propulsion SystemUnknown Or Other
I NEVER RECEIVED A RECALL ON MY CHEVROLET TRUCK WHICH IS THE SAME YEAR MAKE AND MODEL AS THIS ONE. TOOK IT TO A DEALERSHIP AND HAD IT FIXED. THEY SAID IT WASN'T RECALLED SO WE HAD TO PAY THE BILL. ISN'T THEIR A WAY TO FIND THE RECALL AND GET REIMBURSED FOR THE REPAIR BILL AND ALL THE ASSOCIATED COSTS? WE HAVE CALLED AND MADE…
Read full complaint
I NEVER RECEIVED A RECALL ON MY CHEVROLET TRUCK WHICH IS THE SAME YEAR MAKE AND MODEL AS THIS ONE. TOOK IT TO A DEALERSHIP AND HAD IT FIXED. THEY SAID IT WASN'T RECALLED SO WE HAD TO PAY THE BILL. ISN'T THEIR A WAY TO FIND THE RECALL AND GET REIMBURSED FOR THE REPAIR BILL AND ALL THE ASSOCIATED COSTS? WE HAVE CALLED AND MADE A COMPLAINT TO NHTSA. NOTHING CAME OF IT. IT STILL IS A SAFETY DEFECT THAT SHOULD BE REPAIRED WITH NO COST TO THE CUSTOMERS.
NHTSA ODI #11298635
90,000 miles · Dec 23, 2019
Electrical SystemFire
I WOULD NOTICE WHITE SMOKE COMING OUT UNDER THE HOOD OF MY VEHICLE. I WOULD MAINLY NOTICE IT WHEN I WOULD TURN ON THE AC . THIS WOULD HAPPEN EITHER PARKED OR IN MOTION. I WOULD OPEN THE HOOD AND THE SMOKE WOULD ONLY LAST A FEW MINUTES, WHICH CAUSED THE ALTERNATOR TO CATCH ON FIRE.
NHTSA ODI #11290791
125,200 miles · Apr 10, 2019
Electrical SystemVisibility/wiper
I REMOTE STARTED MY 2015 SILVERADO 3500HD DURAMAX. AFTER ABOUT 5 MINUTES OF IDLE TIME I BEGAN DRIVING THE TRUCK. ABOUT 3/4 MILES DOWN THE ROAD I DETECTED THE SMELL OF SOMETHING BURNING OR VERY HOT. MY FIRST THOUGH WAS IT WAS COMING FROM THE OUTSIDE. BEFORE I COULD FIGURE OUT WHAT WAS BURNING HEAVY WHITE/GRAY SMOKE STARTING EXITI…
Read full complaint
I REMOTE STARTED MY 2015 SILVERADO 3500HD DURAMAX. AFTER ABOUT 5 MINUTES OF IDLE TIME I BEGAN DRIVING THE TRUCK. ABOUT 3/4 MILES DOWN THE ROAD I DETECTED THE SMELL OF SOMETHING BURNING OR VERY HOT. MY FIRST THOUGH WAS IT WAS COMING FROM THE OUTSIDE. BEFORE I COULD FIGURE OUT WHAT WAS BURNING HEAVY WHITE/GRAY SMOKE STARTING EXITING FROM LOWER WEATHER STRIPPING ON THE REAR CENTER SLIDING WINDOW. BEFORE I COULD TAKE ACTION I HEARD A LOUD POPPING SOUND. I LOOKED BACK AGAIN AND THE REAR PASSENGER SIDE WINDOW WAS ENTIRELY SHATTERED. AT THIS TIME I KILLED THE REAR WINDOW DEFROST AND THE SMOKE QUITE. I WAS TRAVELING AT ROUGHLY 20-30MPH ON A PAVED CITY STREET. IT WAS 35 DEGREES WITH A LIGHT MIST AND FOG.
NHTSA ODI #11195372
30,000 miles · Aug 6, 2018
EquipmentUnknown Or Other
WE WERE TRAVELING ON I-465 OR I-90 OUTSIDE OF INDIANAPOLIS WITH OUR 2016 LANCE CAMPER MODEL 995 ON OUR 2015 SILVERADO 3500HD. WE STOPPED AT A REST AREA ON I-90 AND FOUND THE AWNING AND AWNING ROLLER FOR THE SLIDEOUT ON THE CAMPER HAD DISAPPEARED. I HAD BEEN DRIVING AT OR UNDER THE POSTED SPEED LIMITS WHEN THIS OCCURRED. THE MOUN…
Read full complaint
WE WERE TRAVELING ON I-465 OR I-90 OUTSIDE OF INDIANAPOLIS WITH OUR 2016 LANCE CAMPER MODEL 995 ON OUR 2015 SILVERADO 3500HD. WE STOPPED AT A REST AREA ON I-90 AND FOUND THE AWNING AND AWNING ROLLER FOR THE SLIDEOUT ON THE CAMPER HAD DISAPPEARED. I HAD BEEN DRIVING AT OR UNDER THE POSTED SPEED LIMITS WHEN THIS OCCURRED. THE MOUNTS, BOTH DAMAGED, WERE ALL THAT WERE LEFT. THE CAMPER SIDE WAS ALSO SLIGHTLY CRACKED ON ONE CORNER AND BULGED ON THE OTHER. IT COULD HAVE BEEN MUCH WORSE. LANCE HAS REPLIED TO MY COMPLAINT STATING IT WAS NOT A WARRANTY ITEM ANY MORE SO CLAIMED THEY HAD NO LIABILITY. MY CONCERN IS THAT THIS SHOULD NEVER HAVE HAPPENED AND I COULD HAVE HURT SOMEONE. THE AWNING IS MADE BY CAREFREE OF COLORADO FOR LANCE. I WANTED TO HAVE THIS RECORDED BECAUSE I HAVE HEARD OF ANECDOTAL INFORMATION OF OTHER SLIDE AWNINGS UNFURLING AND/OR COMING OFF SOME CAMPERS.
NHTSA ODI #11118200
Official recalls
7Jul 1, 2021
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Interim owner notification letters informing owners of the safety risk were mailed on August 18, 2021. Owners will receive a second notice when the remedy is available. Phase I owner notification letters were mailed on May 5, 2022. Phase II owner notification letters are expected to be mailed on May 31, 2022. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. This recall supersedes NHTSA recall number 20V-736. GM's number for this recall is N202324251.
Nov 25, 2020
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500 and Chevrolet Silverado 1500 and 2015 GMC Sierra 2500 and 3500, and Chevrolet Silverado 2500 and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator.
Consequence & remedy
Consequence: If the end cap separates from the inflator, the compressed gas will escape and the end cap can be propelled into the vehicle, increasing the risk of injury or a crash.
Remedy: GM will notify owners, and dealers will replace the RRAB modules on the left and/or right side, free of charge. Interim owner notification letters were mailed on December 22, 2020. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. Note: GM filed a new recall, number 21V-504 that supersedes this recall. All vehicles previously recalled under 20V-736 will now be repaired under the new recall number 21V-504. GM's numbers for this recall are N202309680, N202309681, and N202309682.
Aug 30, 2018
General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 2500, 3500, 1500 Crew Cab Special Service, Tahoe Police Pursuit/Special Service, GMC Sierra 2500, and 3500 vehicles. The brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Consequence & remedy
Consequence: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Remedy: GM will notify owners, and dealers will add adhesive to the nut and reinstall the nut with increased tightness, free of charge. The recall began October 3, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18278. Note: The vehicles in this recall need this additional remedy despite being covered by recall 16V069 for brake pedal loosening.
Oct 19, 2017
General Motors LLC (GM) is recalling certain 2011-2015 Chevrolet Silverado 3500 and GMC Sierra 3500 trucks equipped with dual fuel tanks. The low fuel level sensor for the front tank may stick causing the rear tank to overfill the front tank.
Consequence & remedy
Consequence: If the front tank overfills, the excess pressure may cause the front tank to expand and contact the driveshaft, possibly resulting in a hole in the tank. The hole will leak fuel, which in the presence of an ignition source, can increase the risk of a fire.
Remedy: GM has notified owners, and dealers will replace the rear tank fuel pump or update the fuel-level sensor software, as well as inspect the front tank, replacing it as necessary, free of charge. The recall began December 11, 2017. Owners may contact GM customer service for Chevrolet 1-800-222-1020 or for GMC customer service at 1-800-462-8782. GM's number for this recall is 17399.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Feb 5, 2016
General Motors LLC (GM) is recalling certain model year 2015-2016 Chevrolet Silverado 1500, 2500, and 3500 heavy duty trucks manufactured October 1, 2013, to February 1, 2016, 2015-2016 Chevrolet Tahoe Police Pursuit Vehicles (PPV) manufactured March 1, 2014, to February 1, 2016, and 2015-2016 GMC Sierra 2500 and 3500 heavy duty trucks manufactured October 29, 2013, to February 1, 2016. On the affected vehicles, the brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Consequence & remedy
Consequence: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Remedy: GM will notify owners, and dealers will add adhesive to the brake pedal pivot nut and reinstall with an increased torque, free of charge. The recall began on March 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 20760.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration