IllustrationWINDOW POP AFTER ROLLED UP SCARING THE !@#$% OUT OF YOU COULD BE 1/2 HOUR LATER OR RIGHT AWAY OR DRIVING OVER A BUMP. NOISE SO BAD MY WIFE DROPPED HER CIGARETTE IT MADE HER SCREAM TOO. READ ARTICLE THAT THESE GM WINDOW CAN SHATTER. I'M AFRAID MINE WILL TOO. NEEDS RECALL TO FIX. *TR
2002 Chevrolet S10
Owner reports · Recalls · Investigations
More warning signs than most S10 years
Owner complaints for the 2002 Chevrolet S10 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all S10 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
350–25K
3925–50K
3250–75K
1675–100K
10100–150K
7150K+
139 reports with mileage · 75 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 73 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Latches/locks/linkages. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports2 fire reports16 injury reports
Visibility complaints
3 reports2002 S10 SEAT RECLINING ADJUSTMENT CONTROL HANDLE BREAKS OFF WITH NO CONTROL OF POSITION OF SAFE POSITION OF SEATING FOR DRIVER. I HAD SAME PROBLEM WITH A 1999. *JB
THIS VEHICLE HAS HAD A PROBLEM WITH THE DEFROSTER THAT BEGAN AT UNDER 20,000 MILES. THE DEALER HAS ATTEMPTED REPAIRS TWICE UNDER WARRANTY. AS I AM ONCE AGAIN HAVING THE PROBLEM, AND OFF OF THE WARRANTY, I BEGAN LOOKING ON THE INTERNET FOR INFORMATION. IT TURNS OUT THAT THE TRANSFER CASE VACUUM SWITCH GOES BAD AND ALLOWS THE FLUI…
Read full complaint
THIS VEHICLE HAS HAD A PROBLEM WITH THE DEFROSTER THAT BEGAN AT UNDER 20,000 MILES. THE DEALER HAS ATTEMPTED REPAIRS TWICE UNDER WARRANTY. AS I AM ONCE AGAIN HAVING THE PROBLEM, AND OFF OF THE WARRANTY, I BEGAN LOOKING ON THE INTERNET FOR INFORMATION. IT TURNS OUT THAT THE TRANSFER CASE VACUUM SWITCH GOES BAD AND ALLOWS THE FLUID IN THE TRANSFER CASE TO BE DRAWN UP INTO THE HVAC SYSTEM. THIS CAUSES, AMONG OTHER PROBLEMS, THE DEFROSTER TO NOT OPERATE. THIS IS A VERY DIFFICULT AND EXPENSIVE PROBLEM TO CORRECT AS THE ENTIRE HVAC SYSTEM MUST BE FLUSHED OUT AND ANY BAD PARTS REPLACED. THIS SEEMS TO BE FAIRLY COMMON AND YET GM WILL DO NOTHING OFF WARRANTY, AND IN MY CASE DID NOT CORRECT THE PROBLEM UNDER WARRANTY. I BELIEVE A RECALL IS IN ORDER. *JB
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA05008 · Tailgate Support Cables
Opened Apr 14, 2005 · Closed May 19, 2006
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch
GENERAL MOTORS IS CONDUCTING A SPECIAL POLICY PROGRAM FOR 903,464 OWNERS OF 2000 - 2003 MODEL S/T VEHICLES THROUGH WHICH OWNERS MAY, AT THEIR OPTION, EITHER (1) PERIODICALLY INSPECT THE TAILGATE SUPPORT CABLES INSTALLED IN THEIR VEHICLE AND HAVE THE CABLES REPLACED IF THE CABLE COATING EXHIBITS ANY INDICATIONS OF DAMAGE OR DETERIORATION OR (2) REQUEST THAT THE TAILGATE SUPPORT CABLES BE REPLACED FREE OF CHARGE. GM WILL HONOR ALL REQUESTS BY OWNERS WHO OPT FOR REPLACEMENT WITHOUT QUESTION REGARDLESS OF THE CONDITION OR APPEARANCE OF THE CABLES. GM HAS AGREED TO MAIL REMINDER NOTIFICATIONS TO OWNERS EVERY TWO YEARS UNTIL THE TAILGATE SUPPORT CABLES HAVE BEEN REPLACED OR UNTIL THE VEHICLE IS 12 YEARS OLD.ODI'S INVESTIGATION INDICATES THAT A SIGNIFICANT MAJORITY OF THE REPORTED COMPLAINTS (87%) AND INJURIES (94%) HAVE OCCURRED IN MY 2000 - 2003 S/T VEHICLES.
RQ04012 · Tailgate Support Cable(s) Break
Opened Nov 22, 2004 · Closed Apr 14, 2005
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI IS UPGRADING RQ04-012 AND OPENING AN EA TO INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998 - 2004 MODEL YEAR SONOMA AND S10 MODEL VEHICLES.GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000-2004 SIERRAS AND SILVERADOS AND CERTAIN MODEL YEAR 2002-2004 AVALANCHES AND ESCALADE EXTS (C/K MODELS).GENERAL MOTORS HAS ADVISED ODITHAT THE TAILGATE SUPPORT CABLES INSTALLED IN THE SUBJECT VEHICLES WERE FABRICATED USING IDENTICAL OR SIMILAR SHEATHING MATERIAL AS THE RECALLED VEHICLES.HOWEVER,GENERAL MOTORS HAS ADVISED ODI THAT SONOMA AND S-10 VEHICLES DIFFER FROM C/K MODELS IN SEVERAL WAYS: THE VEHICLE HEIGHT IS LOWER; THE TAILGATE DISPLACEMENT (DROP) WHEN NOT SUPPORTED BY THE CABLES IS SMALLER AND THE TAILGATE COMES TO REST AT A LESS SEVERE TIP ANGLE WHEN NOT SUPPORTED BY THE CABLES; THE TAILGATE MASS IS SMALLER; AND THE SIZE, PAYLOAD, AND USAGE CHARACTERISTCIS ARE LESS DEMANDING THAN C/K MODEL VEHICLES.GM ALSO STATED THAT SONOMA AND S-10 WARRANTY CLAIM INFORMATION INDICATES A LOWER CLAIM COUNT AND A LOWER CLAIM RATE THAN RECALLED C/K MODELS.NOTWITHSTANDING THE ABOVE INFORMATION, ODI HAS RECEIVED AN ADDITIONAL 73 NON-INJURY COMPLAINTS AND 10 INJURY COMPLAINTS ON THE SUBJECT VEHICLES DURING RQ04-012 (SINCE NOVEMBER 2004 TO DATE), WHICH JUSTIFIES OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS ISSUE.