IllustrationThe door latch, that holds your door shut.The wells on them broke and the passenger door came open while going down the road.Big concern had to get it rewelded
2001 Chevrolet S10
Owner reports · Recalls · Investigations
More warning signs than most S10 years
Owner complaints for the 2001 Chevrolet S10 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all S10 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
240–25K
7025–50K
4050–75K
2875–100K
14100–150K
10150K+
186 reports with mileage · 122 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports6 fire reports22 injury reports
What owners actually said
308 reportsI'm having a problem with I believe it's the fuel sensor my truck gets up to a certain temperature and it just dies and it's not just my truck it's in a lot of the newer model Colorado's as well I have a friend who's having the same exact problem as I am when it gets up past 95 degrees, the truck just all of a sudden stops in th…
Read full complaint
I'm having a problem with I believe it's the fuel sensor my truck gets up to a certain temperature and it just dies and it's not just my truck it's in a lot of the newer model Colorado's as well I have a friend who's having the same exact problem as I am when it gets up past 95 degrees, the truck just all of a sudden stops in the engine turns off, and you have to try and steer your truck without any power steering, the reason I am filing this is if this happens in the middle of the road it could possibly cause an accident and that would be no good and it only happens when it is hot outside in the winter time or when it's cold I have no issues whatsoever
I never received Safety Recall# 06020 Galvanized Defective Tailgate Cables that snap/break due to corrosion inside the cable causing the tailgate to fall down while opened. Both my cables have been torn/broken caused by the rust thru for quit some time. My son told me recently, that he had received the Recall Notice a number …
Read full complaint
I never received Safety Recall# 06020 Galvanized Defective Tailgate Cables that snap/break due to corrosion inside the cable causing the tailgate to fall down while opened. Both my cables have been torn/broken caused by the rust thru for quit some time. My son told me recently, that he had received the Recall Notice a number of years ago and the Chevy Dealer replaced his cables; his S-10 cables are good/solid no problems. I am meticulous with records and surely would have told the Dealer and had them replaced during the recall period. What should I do as I never received the Recall Notice at issue?
TRUCK HAS ABS LIGHTS ON WHEN DRIVING AT LOWER SPEEDS AS SOON AS THE FLUIDS ARE NOT COLD THE CHECK GUSHES LIGHT COMES ON AND THE OIL PRESSURE GAUGE NEEDLE DROPS UNTIL THE THROTTLE IS AGAIN DEPRESSED... ALSO ABS IN REAR SHAKES WHOLE TRUCK WHEN GOING BELOW 50MPH AND THEN CONTINUES UP TO 80MPH BEFORE SUBSIDING. THE TRUCK HAS SERIOUS…
Read full complaint
TRUCK HAS ABS LIGHTS ON WHEN DRIVING AT LOWER SPEEDS AS SOON AS THE FLUIDS ARE NOT COLD THE CHECK GUSHES LIGHT COMES ON AND THE OIL PRESSURE GAUGE NEEDLE DROPS UNTIL THE THROTTLE IS AGAIN DEPRESSED... ALSO ABS IN REAR SHAKES WHOLE TRUCK WHEN GOING BELOW 50MPH AND THEN CONTINUES UP TO 80MPH BEFORE SUBSIDING. THE TRUCK HAS SERIOUS STEERING ISSUES CONSTANT LEAKS CAUSED I'M SURE MY RACK AND PINION ARE WORN DOWN AS WELL AS NOW MY TIRES AND SUPENSION I HAVE SO MANY PROBLEMS LIKE THE INTERIOR IS CRUMBLING TO PIECES THE BODY HAS GIANT HOLES FROM IMPROPER PAINTING OPTIONS ON THIS MODEL I HAVE OVER SIZED TIRE WELLS THAT ARE RUSTED COMPLETELY OUT IT MAKE YOUR COMPANY LOOK SILLY FOR NOT MAKING THESE VEHICLES BETTER WHEN THEY LAST PEOPLE KEEP BUYING THEM AGAIN AND AGAIN! SEEMS LIKE YOU PROBABLY USE PARTS FOR MANY YEARS ON MANY MODELS FUNNY HOW EVERY YEAR INCLUDING THE YEAR IT WAS MANUFACTURERED THERE WERE RECALLS EXCEPT FOR MINE IS THAT JUST BECAUSE IT'S OLDER
TL* THE CONTACT OWNS A 2001 CHEVROLET S10. THE CONTACT WAS PULLED OVER BY A POLICE OFFICER AND INFORMED THAT THE BRAKE LIGHTS AND SIGNAL LIGHTS WERE INOPERABLE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. UPON INVESTIGATION THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 01V364000 (EXTERIOR LIGHTING). ED …
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET S10. THE CONTACT WAS PULLED OVER BY A POLICE OFFICER AND INFORMED THAT THE BRAKE LIGHTS AND SIGNAL LIGHTS WERE INOPERABLE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. UPON INVESTIGATION THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 01V364000 (EXTERIOR LIGHTING). ED BOZARTH CHEVROLET LOCATED AT 2001 S HAVANA ST, AURORA, CO 80014, WAS CONTACTED AND MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 330,000.
MY BRAKES DO NOT ALWAYS WORK; I OFTEN HAVE TO PUMP THE BRAKES UP JUST TO BE ABLE TO GET THEM TO APPLY. IT IS VERY SCARY. I CAN PUT MY FOOT ALL THE WAY TO THE FLOOR, AND THE TRUCK WILL BARELY SLOW DOWN. I FEEL I WILL LIKELY REAR-END SOMEBODY OR ROLL INTO A BUSY INTERSECTION BECAUSE THE BRAKES WILL NOT WORK.
TL* THE CONTACT OWNS A 2001 CHEVROLET S10. WHILE DRIVING VARIOUS SPEEDS AND DEPRESSING THE BRAKE PEDAL, THE VEHICLE FAILED TO STOP AND THE BRAKE LINE FRACTURED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. IN ADDITION, …
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET S10. WHILE DRIVING VARIOUS SPEEDS AND DEPRESSING THE BRAKE PEDAL, THE VEHICLE FAILED TO STOP AND THE BRAKE LINE FRACTURED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE BRAKES WERE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 99,000. THE VIN WAS NOT AVAILABLE.
TAKATA RECALL I WAS INVOLVED IN A ACCIDENT 10-10-2016 AT 9:10AM, A VEHICLE PULLED IN FRONT OF ME CAUSING ME TO HIT THEM WITH THE FRONT OF MY TRUCK, THE DRIVER SIDE AIRBAG DID NOT DEPLOY...UPDATED 10/28/16 *BF *TR
I PURCHASE THIS VEHICLE IN APRIL 2015 (USED) I DROVE THE VEHICLE HOME AND IT REGISTERED A HALF A TANK OF GAS, I DROVE IT A FEW DAYS AND THE GAS GAUGE NEEDLE DID NOT MOVE. I NOTIFIED THE AUTO CENTER WHERE I PURCHASE THE VEHICLE AND TOOK IT BACK FOR REPAIRS. FIVE WEEKS AFTER THE REPAIR THE GAS GAUGE IS STILL FAULTY. I WAS DRIVING…
Read full complaint
I PURCHASE THIS VEHICLE IN APRIL 2015 (USED) I DROVE THE VEHICLE HOME AND IT REGISTERED A HALF A TANK OF GAS, I DROVE IT A FEW DAYS AND THE GAS GAUGE NEEDLE DID NOT MOVE. I NOTIFIED THE AUTO CENTER WHERE I PURCHASE THE VEHICLE AND TOOK IT BACK FOR REPAIRS. FIVE WEEKS AFTER THE REPAIR THE GAS GAUGE IS STILL FAULTY. I WAS DRIVING ON THE HIGHWAY AND THE VEHICLE SHUT DOWN (OUT OF GAS) THE GAS GAUGE NEEDLE READ A QUARTER TANK OF GAS. I CONTACTED THE AUTO CENTER WHERE I PURCHASE THE VEHICLE AND I WAS TOLD THE S10 AND THE GMC MODEL OF THIS VEHICLE HAS A HISTORY OF FAULTY GAS GAUGE'S. MY ONLY RECOURSE IS TO HAVE THIS ITEM REPAIRED AGAIN WITHOUT ANY GUARANTEE THE SAME PROBLEM WILL HAPPEN AGAIN.----2001 CHEVROLET S10 FUEL SDYSTEM, OTHER BULLETIN 13599---ACTION NUMBER 10001283 REPORT DATE MAR 01,2003 THANK YOU [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *PM
THE EMERGENCY BRAKE IS MISSING THE TEETH FOR HOLDING THE BRAKE IN PLACE. ALSO THE ABS LIGHT IS ALWAYS ON AND THEY SAY IT IS THE MASTER THAT NEEDS REPLACEMENT AT OVER $1,200. THIS IS ONLY A DANGER IF USING THE CURSOR CONTROL ON WET PAVEMENT WHICH I NEVER USE DUE TO THE ABS NOT WORKING.
Official recalls
100V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA05008 · Tailgate Support Cables
Opened Apr 14, 2005 · Closed May 19, 2006
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch
GENERAL MOTORS IS CONDUCTING A SPECIAL POLICY PROGRAM FOR 903,464 OWNERS OF 2000 - 2003 MODEL S/T VEHICLES THROUGH WHICH OWNERS MAY, AT THEIR OPTION, EITHER (1) PERIODICALLY INSPECT THE TAILGATE SUPPORT CABLES INSTALLED IN THEIR VEHICLE AND HAVE THE CABLES REPLACED IF THE CABLE COATING EXHIBITS ANY INDICATIONS OF DAMAGE OR DETERIORATION OR (2) REQUEST THAT THE TAILGATE SUPPORT CABLES BE REPLACED FREE OF CHARGE. GM WILL HONOR ALL REQUESTS BY OWNERS WHO OPT FOR REPLACEMENT WITHOUT QUESTION REGARDLESS OF THE CONDITION OR APPEARANCE OF THE CABLES. GM HAS AGREED TO MAIL REMINDER NOTIFICATIONS TO OWNERS EVERY TWO YEARS UNTIL THE TAILGATE SUPPORT CABLES HAVE BEEN REPLACED OR UNTIL THE VEHICLE IS 12 YEARS OLD.ODI'S INVESTIGATION INDICATES THAT A SIGNIFICANT MAJORITY OF THE REPORTED COMPLAINTS (87%) AND INJURIES (94%) HAVE OCCURRED IN MY 2000 - 2003 S/T VEHICLES.
RQ04012 · Tailgate Support Cable(s) Break
Opened Nov 22, 2004 · Closed Apr 14, 2005
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI IS UPGRADING RQ04-012 AND OPENING AN EA TO INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998 - 2004 MODEL YEAR SONOMA AND S10 MODEL VEHICLES.GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000-2004 SIERRAS AND SILVERADOS AND CERTAIN MODEL YEAR 2002-2004 AVALANCHES AND ESCALADE EXTS (C/K MODELS).GENERAL MOTORS HAS ADVISED ODITHAT THE TAILGATE SUPPORT CABLES INSTALLED IN THE SUBJECT VEHICLES WERE FABRICATED USING IDENTICAL OR SIMILAR SHEATHING MATERIAL AS THE RECALLED VEHICLES.HOWEVER,GENERAL MOTORS HAS ADVISED ODI THAT SONOMA AND S-10 VEHICLES DIFFER FROM C/K MODELS IN SEVERAL WAYS: THE VEHICLE HEIGHT IS LOWER; THE TAILGATE DISPLACEMENT (DROP) WHEN NOT SUPPORTED BY THE CABLES IS SMALLER AND THE TAILGATE COMES TO REST AT A LESS SEVERE TIP ANGLE WHEN NOT SUPPORTED BY THE CABLES; THE TAILGATE MASS IS SMALLER; AND THE SIZE, PAYLOAD, AND USAGE CHARACTERISTCIS ARE LESS DEMANDING THAN C/K MODEL VEHICLES.GM ALSO STATED THAT SONOMA AND S-10 WARRANTY CLAIM INFORMATION INDICATES A LOWER CLAIM COUNT AND A LOWER CLAIM RATE THAN RECALLED C/K MODELS.NOTWITHSTANDING THE ABOVE INFORMATION, ODI HAS RECEIVED AN ADDITIONAL 73 NON-INJURY COMPLAINTS AND 10 INJURY COMPLAINTS ON THE SUBJECT VEHICLES DURING RQ04-012 (SINCE NOVEMBER 2004 TO DATE), WHICH JUSTIFIES OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS ISSUE.
PE02066 · Engine Stall Due To Fuel Starvation
Opened Sep 6, 2002 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other; Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.