Structure. Review the 73 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Latches/locks/linkages. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

17 crash reports2 fire reports16 injury reports

Service Brakes, Air complaints

3 reports

Clear category filter

7,580 miles · May 22, 2004

Service Brakes, Air

Read full complaint

-BRAKES FAILED TO STOP VEHICLE (2002 CHEROLET S10 PICKUP) WHILE TRAVELING AT LOW SPEED (20-35 MPH). BRAKE PEDAL WENT TO THE FLOOR AT LEAST ONCE, POSSIBLY MORE, AS I TRIED TO GET THE BRAKES TO ENGAGE. BRAKES FINALLY CAUGHT BUT ON THE RIGHT SIDE ONLY FOR THE VEHICLE JERKED TO THE RIGHT BEFORE IT CAME TO A STOP. VEHICLE, WHICH IS STILL UNDER WARRENTY, WAS TOWED TO DEALER AND NO DEFECTS OR PROBLEMS WERE FOUND. DEALER STATED THAT THERE IS NOTHING THEY CAN DO TO SINCE THEY CANNOT REPLICATE PROBLEM.*AK

NHTSA ODI #10072991

Mileage unknown · Dec 5, 2002

Service Brakes, Air

RIGHT REAR BRAKE WOULD NOT RELEASE COMPLETELY, CAUSE BRAKEING AND WARNING LIGHT TO ILLUMINATE, DEALER NOTIFIED AND UNABLE TO DETERMINED THE PROBLEM. TS

NHTSA ODI #8023836

Mileage unknown · Oct 4, 2002

Service Brakes, Air

CONSUMER STATES THAT THE ABS SYSTEM IS NOT WORKING PROPERLY. CONTACTED DEALER. *MR

NHTSA ODI #8020205

Official recalls

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA05008 · Tailgate Support Cables

Opened Apr 14, 2005 · Closed May 19, 2006

Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch

GENERAL MOTORS IS CONDUCTING A SPECIAL POLICY PROGRAM FOR 903,464 OWNERS OF 2000 - 2003 MODEL S/T VEHICLES THROUGH WHICH OWNERS MAY, AT THEIR OPTION, EITHER (1) PERIODICALLY INSPECT THE TAILGATE SUPPORT CABLES INSTALLED IN THEIR VEHICLE AND HAVE THE CABLES REPLACED IF THE CABLE COATING EXHIBITS ANY INDICATIONS OF DAMAGE OR DETERIORATION OR (2) REQUEST THAT THE TAILGATE SUPPORT CABLES BE REPLACED FREE OF CHARGE. GM WILL HONOR ALL REQUESTS BY OWNERS WHO OPT FOR REPLACEMENT WITHOUT QUESTION REGARDLESS OF THE CONDITION OR APPEARANCE OF THE CABLES. GM HAS AGREED TO MAIL REMINDER NOTIFICATIONS TO OWNERS EVERY TWO YEARS UNTIL THE TAILGATE SUPPORT CABLES HAVE BEEN REPLACED OR UNTIL THE VEHICLE IS 12 YEARS OLD.ODI'S INVESTIGATION INDICATES THAT A SIGNIFICANT MAJORITY OF THE REPORTED COMPLAINTS (87%) AND INJURIES (94%) HAVE OCCURRED IN MY 2000 - 2003 S/T VEHICLES.

RQ04012 · Tailgate Support Cable(s) Break

Opened Nov 22, 2004 · Closed Apr 14, 2005

Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut

ODI IS UPGRADING RQ04-012 AND OPENING AN EA TO INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998 - 2004 MODEL YEAR SONOMA AND S10 MODEL VEHICLES.GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000-2004 SIERRAS AND SILVERADOS AND CERTAIN MODEL YEAR 2002-2004 AVALANCHES AND ESCALADE EXTS (C/K MODELS).GENERAL MOTORS HAS ADVISED ODITHAT THE TAILGATE SUPPORT CABLES INSTALLED IN THE SUBJECT VEHICLES WERE FABRICATED USING IDENTICAL OR SIMILAR SHEATHING MATERIAL AS THE RECALLED VEHICLES.HOWEVER,GENERAL MOTORS HAS ADVISED ODI THAT SONOMA AND S-10 VEHICLES DIFFER FROM C/K MODELS IN SEVERAL WAYS: THE VEHICLE HEIGHT IS LOWER; THE TAILGATE DISPLACEMENT (DROP) WHEN NOT SUPPORTED BY THE CABLES IS SMALLER AND THE TAILGATE COMES TO REST AT A LESS SEVERE TIP ANGLE WHEN NOT SUPPORTED BY THE CABLES; THE TAILGATE MASS IS SMALLER; AND THE SIZE, PAYLOAD, AND USAGE CHARACTERISTCIS ARE LESS DEMANDING THAN C/K MODEL VEHICLES.GM ALSO STATED THAT SONOMA AND S-10 WARRANTY CLAIM INFORMATION INDICATES A LOWER CLAIM COUNT AND A LOWER CLAIM RATE THAN RECALLED C/K MODELS.NOTWITHSTANDING THE ABOVE INFORMATION, ODI HAS RECEIVED AN ADDITIONAL 73 NON-INJURY COMPLAINTS AND 10 INJURY COMPLAINTS ON THE SUBJECT VEHICLES DURING RQ04-012 (SINCE NOVEMBER 2004 TO DATE), WHICH JUSTIFIES OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS ISSUE.