DRIVING IN FREEWAY RUSH HOUR TRAFFIC (40-45MPH), FAN CAME LOOSE FROM ITS MOUNT, STRUCK AND DAMAGED RADIATOR. SURFACE WHERE BELT CONTACTS FAN IS GOUGED AND WILL HAVE TO BE REPLACED/MACHINED TO AVOID DAMAGE TO BELT. SERPENTINE BELT AND PART OF FAN MOUNT LOST. REPLACING RADIATOR AND CURRENTLY TRYING TO TRACK DOWN PARTS TO REPLAC…
Read full complaint
DRIVING IN FREEWAY RUSH HOUR TRAFFIC (40-45MPH), FAN CAME LOOSE FROM ITS MOUNT, STRUCK AND DAMAGED RADIATOR. SURFACE WHERE BELT CONTACTS FAN IS GOUGED AND WILL HAVE TO BE REPLACED/MACHINED TO AVOID DAMAGE TO BELT. SERPENTINE BELT AND PART OF FAN MOUNT LOST. REPLACING RADIATOR AND CURRENTLY TRYING TO TRACK DOWN PARTS TO REPLACE FAN. *LA
NHTSA ODI #10080837
Mileage unknown · Aug 23, 2002
Equipment
SPARE TIRE STORED UNDERNEATH VECHILE FELL TO GROUND AND LOGGED UNDER VEHICLE. ONLY A BAD BOUNCE AT 10 MPH BUT A MAJOR PROBLEM AT 70 MPH. REPAIR SERVICE STATES THEY HAVE SEEM THIS BEFORE--WILL REPLACEMENT FAIL WHEN TRAVELING AT A HIGHER SPEED? IS IT SAFE TO DRIVE THIS VEHICLE?*AK
NHTSA ODI #766107
Mileage unknown · Oct 14, 2000
Electrical SystemEquipmentPower Train
WITH THE AIR CONDITONER THE RELAYS AND FUSES KEEP BLOWING. I HAVE TAKEN THE VEHICLE TO A AIR CONDITONING PLACE AND THEY ARE NOT SURE. WITH THE ABS I WAS DRIVING DOWN THE ROAD IN SNOW. I USED THE BRAKES THE ANTI LOCKS CAME ON AND ALL LIGHTS INTERIOR AND EXTERIOR CUT OFF COMPLETELY. HAD TO STOP AND RESTART VEHICLE. WITH THE ELCTRI…
Read full complaint
WITH THE AIR CONDITONER THE RELAYS AND FUSES KEEP BLOWING. I HAVE TAKEN THE VEHICLE TO A AIR CONDITONING PLACE AND THEY ARE NOT SURE. WITH THE ABS I WAS DRIVING DOWN THE ROAD IN SNOW. I USED THE BRAKES THE ANTI LOCKS CAME ON AND ALL LIGHTS INTERIOR AND EXTERIOR CUT OFF COMPLETELY. HAD TO STOP AND RESTART VEHICLE. WITH THE ELCTRICAL PROBLEM I WAS DRIVING DOWN THE ROAD WHEN ALL MY GAUGES JUMPED THEN WENT TO NORMAL. WITH THE TRANNSMISSION IT HAS CONSTATLY SLAMMED INTO SECOND AND THIRD GEAR. I HAVE BROUGHT TO THTE DEALER NUMEROUS TIMES. IT WAS WORKED ON ONCE. THEY SAID THEY REPLACED NUMEROUS PARTS ON THE TRANSMISSION. UPON DRIVING IT DOWN THE ROAD THE SAME THING HAPPENED AGAIN.
NHTSA ODI #734327
Mileage unknown · Jul 13, 2000
Equipment
CABLE HOLDING SPARE TIRE UNDER FRAME HAS FAILED TWICE. ONCE ON 1-19-2000 AND AGAIN ON 07092000. CABLE BREAKS AND TIRE FALLS TO GROUND INTO TRAFFIC. BOTH FAILURES AT LOW SPEED WITH OUT DAMAGE. DEALER REPAIRED BOTH TIMES AT THEIR COST. CONCERN SHOULD IT FAIL AT HIGHWAY SPEED IN HEAVY TRAFFIC. *AK
NHTSA ODI #725383
Mileage unknown · Jan 4, 2000
Equipment
WHILE TRAVELING ON THE HIGHWAY AT APPROXIMATELY 60-65 MPH SPARE TIRE FROM UNDERNEATH THE VEHICLE CARRIER BROKE AND FELL ONTO THE HIGHWAY, ALMOST CAUSING A VEHICLE COLLISION. DEALER WAS NOTIFIED. *AK
NHTSA ODI #854712
Mileage unknown · Sep 15, 1999
Electrical SystemEngine And Engine CoolingEquipment
THE ENGINE SOMETIMES STALLS WHILE CONSUMER RELEASES THE CLUTCH, THE ENGINE HESITATES AND SOMETIMES HAS LITTLE POWER. THE CONSUMER SMELLS FUEL AND SULFER, THE DEALER CAN NOT LOCATE ANY PROBLEMS. THE STARTER DOES NOT WORK PROPERLY. THE AIR CONDITIONER BLOWS HOT. THE TRANSMISSION IS SLIPPING, THE CLUTCH LOCKS UP IN REVERSE AND …
Read full complaint
THE ENGINE SOMETIMES STALLS WHILE CONSUMER RELEASES THE CLUTCH, THE ENGINE HESITATES AND SOMETIMES HAS LITTLE POWER. THE CONSUMER SMELLS FUEL AND SULFER, THE DEALER CAN NOT LOCATE ANY PROBLEMS. THE STARTER DOES NOT WORK PROPERLY. THE AIR CONDITIONER BLOWS HOT. THE TRANSMISSION IS SLIPPING, THE CLUTCH LOCKS UP IN REVERSE AND IS NOISY. THE CONSUMER COMPLAINS THAT THE VEHICLE DOES NOT STOP FAST ENOUGH. THE FAN CLUTCH WAS NOISY. *SLC
NHTSA ODI #842847
Mileage unknown · May 25, 1999
Engine And Engine CoolingEquipmentService Brakes, Hydraulic
TRUCK DOES'T WANT TO START, IT BACKFIRES,ENGINE PULLS DOWN BEFORE STARTING , POWER TO RADIO IS DISRUPTED, CAUSING RADIO TO RESET. PAINT STARTING TO CRACK ON HOOD AND ROOF. BRAKING SYSTEM FOR ABS MAKES A LOUD NOISE WHEN PUSHED HAD TO FLOOR. RADIO ONLY PLAYS TAPES THOUGH ONE SIDE OF SPEAKERS. *AK
NHTSA ODI #706856
Mileage unknown · Feb 1, 1999
Equipment
CD PLAYER IS NOT WORKING. YH
NHTSA ODI #607404
Mileage unknown · Oct 20, 1998
Engine And Engine CoolingEquipmentStructure
RADIO FAILED.
NHTSA ODI #542193
Mileage unknown · Jul 7, 1998
Equipment
WHILE DRIVING THE SPARE TIRE ROD BROKE, CAUSING SPARE TIRE TO FALL OUT. PLEASE PROVIDE DETAILS. *AK
VEHICLE DESCRIPTION: ELECTRIC PASSENGER VEHICLES AND PICKUP TRUCKS CONTAINING A NICKEL METAL HYDRIDE (NIMH) BATTERY PACK. THESE VEHICLES CONTAIN SOFTWARE WITHIN THE BATTERY PACK MODULE INTENDED TO DISABLE THE VEHICLE FROM BEING DRIVEN IF THE ELECTRICAL RESISTANCE WITH THE BATTERY PACK EXCEEDS A PRESCRIBED VALUE. AFFECTED VEHICLES WILL ILLUMINATE THE "SERVICE NOW" AND "REDUCED PERFORMANCE" TELLTALES AND CONTINUE TO FUNCTION IN A REDUCED PERFORMANCE MODEL INSTEAD OF BEING DISABLED.
Consequence & remedy
Consequence: IF THE TELLTALES ARE IGNORED AND THE AFFECTED VEHICLE CONTINUES TO BE DRIVEN, HEAT COULD BUILD UP AND A FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL REVISED SOFTWARE IN THE BATTERY PACK MODULE.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE DAYTIME RUNNING LIGHTS BUILT WITH A CANDELA VALUE GREATER THAN 3,000 CANNOT BE MOUNTED HIGHER THAN 864MM ABOVE THE ROAD SURFACE.
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy: DEALERS WILL INSTALL A REVISED WIRING HARNESS THAT CHANGES THE DRL'S FROM HIGH BEAM TO LOW BEAM DRL'S, AND INSTALL NEW LONG-LIFE LOW BEAM BULBS.
VEHICLE DESCRIPTION: ELECTRIC PICKUP TRUCKS. A CONDITION IN WHICH THE FUEL-FIRED HEATER FILL PIPE GROUND STRAP CONTACTS THE REAR PASSENGER SIDE BRAKE PIPE.
Consequence & remedy
Consequence: THIS COULD WEAR OFF THE CORROSION PROTECTION ON THE BRAKE PIPE, LEADING TO PREMATURE CORROSION AND EVENTUAL LOSS OF BRAKE PIPE INTEGRITY. WHEN BRAKE PIPE INTEGRITY IS LOST, BRAKE FLUID LEAKAGE CAN OCCUR.
Remedy: DEALERS WILL RELOCATE THE GROUND STRAP ATTACHMENT, INSPECT THE BRAKE PIPE FOR WEAR, AND REPLACE THE BRAKE PIPE IF NECESSARY.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH ELECTRIC DRIVE. RAPID FOGGING OF THE INTERIOR GLASS CAN OCCUR WITHIN TWO MINUTES AFTER THE HEAT IS TURNED ON IF (1) THE OUTSIDE TEMPERATURE IS BETWEEN 35 AND 76 DEGREES FAHRENHEIT AND (2) WATER HAS COLLECTED ON THE HEAT EXCHANGER DURING PREVIOUS OPERATION OF THE AIR CONDITIONING.
Consequence & remedy
Consequence: IF RAPID FOGGING WERE TO OCCUR DURING DRIVING, IT COULD OBSTRUCT THE DRIVER'S VISION INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: OWNERS ARE BEING PROVIDED WITH A CAUTION LABEL AND SUPPLEMENTAL INSERT FOR THEIR OWNER'S MANUAL ADVISING THEM TO FOLLOW A "STOP AND WAIT" PROCEDURE TO HELP AVOID WINDOW FOGGING WHILE DRIVING.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE VEHICLES. AN ENGINE ELECTRICAL WIRING-HARNESS CLIP CAN MELT AND DRIP ONTO THE EXHAUST MANIFOLD.
Consequence & remedy
Consequence: THE CLIP MATERIAL ON THE EXHAUST MANIFOLD CAN IGNITE AND SUBSEQUENTLY IGNITE OTHER COMBUSTIBLE COMPONENTS RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS ARE CONTACTING OWNERS BY TELEPHONE TO HAVE THEIR VEHICLES TOWED TO THE DEALER AND ALTERNATE TRANSPORTATION PROVIDED TO THEM UNTIL THE DEALER CAN REROUTE THE ELECTRICAL WIRING-HARNESS.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. A FATIGUE FRACTURE OF THE REAR AXLE RIGHT-HAND BRAKE PIPE CAN OCCUR CAUSING A SLOW BRAKE FLUID LEAK RESULTING IN A SOFT BRAKE PEDAL. IF THE BRAKE PIPE BREAKS, THE DRIVER WOULD EXPERIENCE A SUDDEN DROP IN THE BRAKE PEDAL, THE INSTRUMENT PANEL BRAKE LIGHT WOULD ILLUMINATE, AND THERE WOULD BE A LOSS OF REAR BRAKE PERFORMANCE.
Consequence & remedy
Consequence: PARTIAL LOSS OF BRAKING AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE BRAKE PIPE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA05008 · Tailgate Support Cables
Opened Apr 14, 2005 · Closed May 19, 2006
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch
GENERAL MOTORS IS CONDUCTING A SPECIAL POLICY PROGRAM FOR 903,464 OWNERS OF 2000 - 2003 MODEL S/T VEHICLES THROUGH WHICH OWNERS MAY, AT THEIR OPTION, EITHER (1) PERIODICALLY INSPECT THE TAILGATE SUPPORT CABLES INSTALLED IN THEIR VEHICLE AND HAVE THE CABLES REPLACED IF THE CABLE COATING EXHIBITS ANY INDICATIONS OF DAMAGE OR DETERIORATION OR (2) REQUEST THAT THE TAILGATE SUPPORT CABLES BE REPLACED FREE OF CHARGE. GM WILL HONOR ALL REQUESTS BY OWNERS WHO OPT FOR REPLACEMENT WITHOUT QUESTION REGARDLESS OF THE CONDITION OR APPEARANCE OF THE CABLES. GM HAS AGREED TO MAIL REMINDER NOTIFICATIONS TO OWNERS EVERY TWO YEARS UNTIL THE TAILGATE SUPPORT CABLES HAVE BEEN REPLACED OR UNTIL THE VEHICLE IS 12 YEARS OLD.ODI'S INVESTIGATION INDICATES THAT A SIGNIFICANT MAJORITY OF THE REPORTED COMPLAINTS (87%) AND INJURIES (94%) HAVE OCCURRED IN MY 2000 - 2003 S/T VEHICLES.
RQ04012 · Tailgate Support Cable(s) Break
Opened Nov 22, 2004 · Closed Apr 14, 2005
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI IS UPGRADING RQ04-012 AND OPENING AN EA TO INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998 - 2004 MODEL YEAR SONOMA AND S10 MODEL VEHICLES.GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000-2004 SIERRAS AND SILVERADOS AND CERTAIN MODEL YEAR 2002-2004 AVALANCHES AND ESCALADE EXTS (C/K MODELS).GENERAL MOTORS HAS ADVISED ODITHAT THE TAILGATE SUPPORT CABLES INSTALLED IN THE SUBJECT VEHICLES WERE FABRICATED USING IDENTICAL OR SIMILAR SHEATHING MATERIAL AS THE RECALLED VEHICLES.HOWEVER,GENERAL MOTORS HAS ADVISED ODI THAT SONOMA AND S-10 VEHICLES DIFFER FROM C/K MODELS IN SEVERAL WAYS: THE VEHICLE HEIGHT IS LOWER; THE TAILGATE DISPLACEMENT (DROP) WHEN NOT SUPPORTED BY THE CABLES IS SMALLER AND THE TAILGATE COMES TO REST AT A LESS SEVERE TIP ANGLE WHEN NOT SUPPORTED BY THE CABLES; THE TAILGATE MASS IS SMALLER; AND THE SIZE, PAYLOAD, AND USAGE CHARACTERISTCIS ARE LESS DEMANDING THAN C/K MODEL VEHICLES.GM ALSO STATED THAT SONOMA AND S-10 WARRANTY CLAIM INFORMATION INDICATES A LOWER CLAIM COUNT AND A LOWER CLAIM RATE THAN RECALLED C/K MODELS.NOTWITHSTANDING THE ABOVE INFORMATION, ODI HAS RECEIVED AN ADDITIONAL 73 NON-INJURY COMPLAINTS AND 10 INJURY COMPLAINTS ON THE SUBJECT VEHICLES DURING RQ04-012 (SINCE NOVEMBER 2004 TO DATE), WHICH JUSTIFIES OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS ISSUE.
EA99012 · Post Collision Fuel System Integrity
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ALLEGE THAT IN CERTAIN SIDE IMPACT CRASHES, THE SUBJECT FUEL TANKS MAY CONTACT THE PROP SHAFT REAR UNIVERSAL JOINT COMPONENTS WITH SUFFICIENT FORCE TO PUNCTURE THE TANK.
1998 Chevrolet S10 Problems, Complaints & Recalls | Skip That Year
Illustration