NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
51 reportsClear category filter91,000 miles · Jul 12, 2004
Engine And Engine CoolingEquipment
DRIVING IN FREEWAY RUSH HOUR TRAFFIC (40-45MPH), FAN CAME LOOSE FROM ITS MOUNT, STRUCK AND DAMAGED RADIATOR. SURFACE WHERE BELT CONTACTS FAN IS GOUGED AND WILL HAVE TO BE REPLACED/MACHINED TO AVOID DAMAGE TO BELT. SERPENTINE BELT AND PART OF FAN MOUNT LOST. REPLACING RADIATOR AND CURRENTLY TRYING TO TRACK DOWN PARTS TO REPLAC…
Read full complaint
DRIVING IN FREEWAY RUSH HOUR TRAFFIC (40-45MPH), FAN CAME LOOSE FROM ITS MOUNT, STRUCK AND DAMAGED RADIATOR. SURFACE WHERE BELT CONTACTS FAN IS GOUGED AND WILL HAVE TO BE REPLACED/MACHINED TO AVOID DAMAGE TO BELT. SERPENTINE BELT AND PART OF FAN MOUNT LOST. REPLACING RADIATOR AND CURRENTLY TRYING TO TRACK DOWN PARTS TO REPLACE FAN. *LA
NHTSA ODI #10080837
52,000 miles · Jan 8, 2004
Engine And Engine CoolingPower Train
THE CONSUMER HAD MULTIPLE PROBLEMS WITH THIS VEHICLE. THE SPARK WIRES CORRODED, THE HEAD GASKET LEAKED AND THE TRANSMISSION DID NOT WORK PROPERLY WHEN SHIFTED. DEALER NOTIFIED. *PH ALSO THE RADIATOR ERUPTED BETWEEN THE TRANSMISSION COOLER AND THE COOLER OF THE RADIATOR. *SC *JB
NHTSA ODI #10050046
59,000 miles · Nov 20, 2003
Engine And Engine Cooling
VEHICLE LOST POWER WHILE DRIVING AND SMOKE WAS EMITTED FROM UNDER THE HOOD. VEHICLE WAS TOWED TO THE SHOP WHERE THE MECHANIC INDICATED THAT THE VEHICLE HAD A BLOWN HEAD GASKET. *PH *MR
NHTSA ODI #10048435
52,000 miles · Nov 12, 2003
Electrical SystemEngine And Engine CoolingPower Train
AUTOMATIC TRANSMISSION COOLER BROKE WHILE DRIVING AND CONTAMINATED OTHER COMPONENTS WITHIN THE ENGINE COMPARTMENT. THIS MADE DRIVING AND GEAR CHANGING DIFFICULT. DEALERSHIP WILL REPLACE ALL CONTAMINATED COMPONENTS. *AK THE "SERVICE ENGINE SOON" LIGHT ILLUMINATED SO THE CONSUMER TOOK THE VEHICLE TO THE DEALER. THE CON…
Read full complaint
AUTOMATIC TRANSMISSION COOLER BROKE WHILE DRIVING AND CONTAMINATED OTHER COMPONENTS WITHIN THE ENGINE COMPARTMENT. THIS MADE DRIVING AND GEAR CHANGING DIFFICULT. DEALERSHIP WILL REPLACE ALL CONTAMINATED COMPONENTS. *AK THE "SERVICE ENGINE SOON" LIGHT ILLUMINATED SO THE CONSUMER TOOK THE VEHICLE TO THE DEALER. THE CONSUMER HAD THE RADIATOR FLUSHED AT 550 MILES AND THE ENGINE CONTINUED TO RUN ROUGH. ON ONE OCCASION, THE CONSUMER STARTED THE ENGINE AND IT LUNGED FORWARD ALMOST KNOCKING HIM TO THE DRIVEWAY. THE SERVICE MANAGER AGREED THAT THE RADIATOR MAY BE DEFECTIVE. *PH THE BATTERY WAS REPLACED, THE INSTRUMENT PANEL CLUSTER WAS REPLACED BECAUSE IT HAD SHORTED OUT. *JB
NHTSA ODI #10042113
80,586 miles · Sep 4, 2003
Engine And Engine Cooling
THE VEHICLE HAD AN OIL LEAK WHICH CAUSED THE VEHICLE TO CUT OFF WHILE DRIVING. IT WAS LATER DISCOVERED THAT THE OIL COOLER LINES RUBBED TOGETHER AND MADE A HOLE WHICH CAUSED THE LEAK. *NLM *JB
NHTSA ODI #10019339
45,000 miles · Jun 30, 2003
Engine And Engine Cooling
CONSUMER STATES HEARD A RATTLING NOISE COMING FROM UNDER THE FRONT END WHILE DRIVING. ONE DAY THE TIMING CHAIN BROKE, CAUSING VEHICLE TO STALL. CONSUMER HAD REPAIRED, BUT NOISE RETURNED, AND CHAIN BROKE AGAIN IN 60 DAYS. HAS REPLACED TIMING CHAIN AND GEAR COMPONENTS 4 TIMES SINCE VEHICLE PURCHASE.*AK
NHTSA ODI #10026267
78,000 miles · Feb 26, 2003
Engine And Engine Cooling
THE FAN FLEW OFF THE SHAFT INTO THE MOTOR, WHICH CAUSED THE CONSUMER TO ABRUPTLY PULL OVER. *JB *TT
NHTSA ODI #10009412
72,000 miles · Jan 28, 2003
Engine And Engine Cooling
1. CONSTANTLY HAD TO CHECK AND FILL OIL AND ANTIFREEZE. 2. USED ALL THE OIL AND MOTOR BLEW UP WITH NO ADVANCE WARNING. 3. LEFT ME STRANDED IN SUB-ZERO WEATHER. 4. CONTACTED LOCAL CHEVY DEALER (STOCKER, STATE COLLEGE, PA) VIA EMAIL AND RECEIVED NO RESPONSE WHATSOEVER.
NHTSA ODI #10003547
Mileage unknown · Aug 15, 2002
Engine And Engine Cooling
MY SON WAS DRIVING DOWN THE ROAD WHEN THE FAN FLEW OFF THE TRUCK , WENT THROUGH THE RADIATOR AND BLEW THE ENGINE. WHAT I WANT TO KNOW IS , THIS NORMAL FOR A VEHICLE THAT ONLY HAS 51000 MILES ON IT???*AK
NHTSA ODI #765669
Mileage unknown · Jul 30, 2002
Electrical SystemEngine And Engine Cooling
WHEN DRIVING THE TRUCK, IT SHUTS DOWN DURING ODD TIMES. IT DOESNT SHUT DOWN WHEN THE TRUCK HAS BEEN DRIVEN ALONG TIME. IT HAPPENS WHEN THE ENGINE IS COLD AND HOT. WHEN I MEAN SHUT DOWN IM REFERRING TO THE WHOLE TRUCK TURNING OFF. THE BATTERY LIGHT COMES ON WHEN SHUT DOWN OCCURS. I HAD THIS VEHICLE TO A CHEV DEALER, THE SAID IT …
Read full complaint
WHEN DRIVING THE TRUCK, IT SHUTS DOWN DURING ODD TIMES. IT DOESNT SHUT DOWN WHEN THE TRUCK HAS BEEN DRIVEN ALONG TIME. IT HAPPENS WHEN THE ENGINE IS COLD AND HOT. WHEN I MEAN SHUT DOWN IM REFERRING TO THE WHOLE TRUCK TURNING OFF. THE BATTERY LIGHT COMES ON WHEN SHUT DOWN OCCURS. I HAD THIS VEHICLE TO A CHEV DEALER, THE SAID IT WAS A IGNITION MODULE, I HAD IT REPLACED. THE SAME PROBLEM HAPPENED. I HAD IT TO ANOTHER GARAGE, THEY SAID IT WAS A CRACK SENSOR, I HAD IT REPLACED, ITS STILL HAPPENING. I HAD IT TO ANOTHER GARAGE, THEY SAID IT WAS A IGNITION COIL, I HAD IT REPLACED, YOU GUESSED IT, STILL SHUTTING DOWN. I SANKED 300 HUNDRED DOLLARS ON THE SO CALLED PROFESSIONALS FROM CHEVROLET. IM STILL HAVING THE PROBLEM. THEY ARE DUMPING PARTS IN MY TRUCK AND HAVE NO IDEA WHAT IT IS. I BOUGHT THIS VEHICLE USED AND IT STILL HAS LOW MILES ON IT. THERE HAS TO BE A SOLUTION TO MY PROBLEM.*AK
NHTSA ODI #764954
Official recalls
6Nov 13, 2000
VEHICLE DESCRIPTION: ELECTRIC PASSENGER VEHICLES AND PICKUP TRUCKS CONTAINING A NICKEL METAL HYDRIDE (NIMH) BATTERY PACK. THESE VEHICLES CONTAIN SOFTWARE WITHIN THE BATTERY PACK MODULE INTENDED TO DISABLE THE VEHICLE FROM BEING DRIVEN IF THE ELECTRICAL RESISTANCE WITH THE BATTERY PACK EXCEEDS A PRESCRIBED VALUE. AFFECTED VEHICLES WILL ILLUMINATE THE "SERVICE NOW" AND "REDUCED PERFORMANCE" TELLTALES AND CONTINUE TO FUNCTION IN A REDUCED PERFORMANCE MODEL INSTEAD OF BEING DISABLED.
Consequence & remedy
Consequence: IF THE TELLTALES ARE IGNORED AND THE AFFECTED VEHICLE CONTINUES TO BE DRIVEN, HEAT COULD BUILD UP AND A FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL REVISED SOFTWARE IN THE BATTERY PACK MODULE.
Aug 11, 2000
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE DAYTIME RUNNING LIGHTS BUILT WITH A CANDELA VALUE GREATER THAN 3,000 CANNOT BE MOUNTED HIGHER THAN 864MM ABOVE THE ROAD SURFACE.
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy: DEALERS WILL INSTALL A REVISED WIRING HARNESS THAT CHANGES THE DRL'S FROM HIGH BEAM TO LOW BEAM DRL'S, AND INSTALL NEW LONG-LIFE LOW BEAM BULBS.
Jun 16, 2000
VEHICLE DESCRIPTION: ELECTRIC PICKUP TRUCKS. A CONDITION IN WHICH THE FUEL-FIRED HEATER FILL PIPE GROUND STRAP CONTACTS THE REAR PASSENGER SIDE BRAKE PIPE.
Consequence & remedy
Consequence: THIS COULD WEAR OFF THE CORROSION PROTECTION ON THE BRAKE PIPE, LEADING TO PREMATURE CORROSION AND EVENTUAL LOSS OF BRAKE PIPE INTEGRITY. WHEN BRAKE PIPE INTEGRITY IS LOST, BRAKE FLUID LEAKAGE CAN OCCUR.
Remedy: DEALERS WILL RELOCATE THE GROUND STRAP ATTACHMENT, INSPECT THE BRAKE PIPE FOR WEAR, AND REPLACE THE BRAKE PIPE IF NECESSARY.
Aug 4, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH ELECTRIC DRIVE. RAPID FOGGING OF THE INTERIOR GLASS CAN OCCUR WITHIN TWO MINUTES AFTER THE HEAT IS TURNED ON IF (1) THE OUTSIDE TEMPERATURE IS BETWEEN 35 AND 76 DEGREES FAHRENHEIT AND (2) WATER HAS COLLECTED ON THE HEAT EXCHANGER DURING PREVIOUS OPERATION OF THE AIR CONDITIONING.
Consequence & remedy
Consequence: IF RAPID FOGGING WERE TO OCCUR DURING DRIVING, IT COULD OBSTRUCT THE DRIVER'S VISION INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: OWNERS ARE BEING PROVIDED WITH A CAUTION LABEL AND SUPPLEMENTAL INSERT FOR THEIR OWNER'S MANUAL ADVISING THEM TO FOLLOW A "STOP AND WAIT" PROCEDURE TO HELP AVOID WINDOW FOGGING WHILE DRIVING.
Nov 25, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE VEHICLES. AN ENGINE ELECTRICAL WIRING-HARNESS CLIP CAN MELT AND DRIP ONTO THE EXHAUST MANIFOLD.
Consequence & remedy
Consequence: THE CLIP MATERIAL ON THE EXHAUST MANIFOLD CAN IGNITE AND SUBSEQUENTLY IGNITE OTHER COMBUSTIBLE COMPONENTS RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS ARE CONTACTING OWNERS BY TELEPHONE TO HAVE THEIR VEHICLES TOWED TO THE DEALER AND ALTERNATE TRANSPORTATION PROVIDED TO THEM UNTIL THE DEALER CAN REROUTE THE ELECTRICAL WIRING-HARNESS.
Nov 24, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. A FATIGUE FRACTURE OF THE REAR AXLE RIGHT-HAND BRAKE PIPE CAN OCCUR CAUSING A SLOW BRAKE FLUID LEAK RESULTING IN A SOFT BRAKE PEDAL. IF THE BRAKE PIPE BREAKS, THE DRIVER WOULD EXPERIENCE A SUDDEN DROP IN THE BRAKE PEDAL, THE INSTRUMENT PANEL BRAKE LIGHT WOULD ILLUMINATE, AND THERE WOULD BE A LOSS OF REAR BRAKE PERFORMANCE.
Consequence & remedy
Consequence: PARTIAL LOSS OF BRAKING AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE BRAKE PIPE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA05008 · Tailgate Support Cables
Opened Apr 14, 2005 · Closed May 19, 2006
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch
GENERAL MOTORS IS CONDUCTING A SPECIAL POLICY PROGRAM FOR 903,464 OWNERS OF 2000 - 2003 MODEL S/T VEHICLES THROUGH WHICH OWNERS MAY, AT THEIR OPTION, EITHER (1) PERIODICALLY INSPECT THE TAILGATE SUPPORT CABLES INSTALLED IN THEIR VEHICLE AND HAVE THE CABLES REPLACED IF THE CABLE COATING EXHIBITS ANY INDICATIONS OF DAMAGE OR DETERIORATION OR (2) REQUEST THAT THE TAILGATE SUPPORT CABLES BE REPLACED FREE OF CHARGE. GM WILL HONOR ALL REQUESTS BY OWNERS WHO OPT FOR REPLACEMENT WITHOUT QUESTION REGARDLESS OF THE CONDITION OR APPEARANCE OF THE CABLES. GM HAS AGREED TO MAIL REMINDER NOTIFICATIONS TO OWNERS EVERY TWO YEARS UNTIL THE TAILGATE SUPPORT CABLES HAVE BEEN REPLACED OR UNTIL THE VEHICLE IS 12 YEARS OLD.ODI'S INVESTIGATION INDICATES THAT A SIGNIFICANT MAJORITY OF THE REPORTED COMPLAINTS (87%) AND INJURIES (94%) HAVE OCCURRED IN MY 2000 - 2003 S/T VEHICLES.
RQ04012 · Tailgate Support Cable(s) Break
Opened Nov 22, 2004 · Closed Apr 14, 2005
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI IS UPGRADING RQ04-012 AND OPENING AN EA TO INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998 - 2004 MODEL YEAR SONOMA AND S10 MODEL VEHICLES.GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000-2004 SIERRAS AND SILVERADOS AND CERTAIN MODEL YEAR 2002-2004 AVALANCHES AND ESCALADE EXTS (C/K MODELS).GENERAL MOTORS HAS ADVISED ODITHAT THE TAILGATE SUPPORT CABLES INSTALLED IN THE SUBJECT VEHICLES WERE FABRICATED USING IDENTICAL OR SIMILAR SHEATHING MATERIAL AS THE RECALLED VEHICLES.HOWEVER,GENERAL MOTORS HAS ADVISED ODI THAT SONOMA AND S-10 VEHICLES DIFFER FROM C/K MODELS IN SEVERAL WAYS: THE VEHICLE HEIGHT IS LOWER; THE TAILGATE DISPLACEMENT (DROP) WHEN NOT SUPPORTED BY THE CABLES IS SMALLER AND THE TAILGATE COMES TO REST AT A LESS SEVERE TIP ANGLE WHEN NOT SUPPORTED BY THE CABLES; THE TAILGATE MASS IS SMALLER; AND THE SIZE, PAYLOAD, AND USAGE CHARACTERISTCIS ARE LESS DEMANDING THAN C/K MODEL VEHICLES.GM ALSO STATED THAT SONOMA AND S-10 WARRANTY CLAIM INFORMATION INDICATES A LOWER CLAIM COUNT AND A LOWER CLAIM RATE THAN RECALLED C/K MODELS.NOTWITHSTANDING THE ABOVE INFORMATION, ODI HAS RECEIVED AN ADDITIONAL 73 NON-INJURY COMPLAINTS AND 10 INJURY COMPLAINTS ON THE SUBJECT VEHICLES DURING RQ04-012 (SINCE NOVEMBER 2004 TO DATE), WHICH JUSTIFIES OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS ISSUE.
EA99012 · Post Collision Fuel System Integrity
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ALLEGE THAT IN CERTAIN SIDE IMPACT CRASHES, THE SUBJECT FUEL TANKS MAY CONTACT THE PROP SHAFT REAR UNIVERSAL JOINT COMPONENTS WITH SUFFICIENT FORCE TO PUNCTURE THE TANK.
Illustration