IllustrationNO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
1996 Chevrolet S10
Owner reports · Recalls · Investigations
More warning signs than most S10 years
Owner complaints for the 1996 Chevrolet S10 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all S10 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 34 of 665 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 209 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
110 crash reports11 fire reports50 injury reports
What owners actually said
665 reportsIN THE PAST YEAR, WINDSHIELD WIPERS HAVE TO BE MANUALLY STARTED, THEN THEY DON'T ALWAYS WORK. THE TRUCK ENGINE WILL JUST STOP WHILE YOUR DRIVING LEAVING YOU FIGHTING TO BRAKE & STEER.*AK
ACCORDING TO OWNERS MANUAL AIRBAGS ARE SUPPOSED TO BE DEPLOYED AT A THRESHOLD OF 9-18 MPH. THY DID NOT. CONTACTED GM DEALERSHIP AND THEY DO NOT WANT TO DO ANYTHING WITH THIS PROBLEM. I NEED YOUR HELP. MY HAND IS IN A CAST AND ACCORDING TO MY DOCTOR MAY NEED AN OPERATION TO MEND THE TORN LIGAMENTS IN MY HAND. I HIT THE STEER…
Read full complaint
ACCORDING TO OWNERS MANUAL AIRBAGS ARE SUPPOSED TO BE DEPLOYED AT A THRESHOLD OF 9-18 MPH. THY DID NOT. CONTACTED GM DEALERSHIP AND THEY DO NOT WANT TO DO ANYTHING WITH THIS PROBLEM. I NEED YOUR HELP. MY HAND IS IN A CAST AND ACCORDING TO MY DOCTOR MAY NEED AN OPERATION TO MEND THE TORN LIGAMENTS IN MY HAND. I HIT THE STEERING WHEEL WITH MY CHEST. YET THE GM MANUFACTURER WILL NOT DO ANYTHING OTHER THAN EXPLAIN TO ME HOW THE AIR BAGS WORK. A VEHICLE CROSS MY PATH NOT YIELDING TO TRAFFIC AND CROSSED MY FRONT ABOUT 15 FEET AWAY. I HIT THE THE OTHER VEHICLE IN T-BONE TYPE ACCIDENT GOING AT 40 MPH, SPUNNED THE OTHER VEHICLE ABOUT THREE TIMES AND MY AIR BAG IN MY CHEVY S-10 TRUCK DID NOT DEPLOY. GM HAS PLACED THIS FILE ON THE BACKBURNER AND WITHOUT ACTION. THEY DO NOT WANT TO TAKE RESPONSIBILITY FOR MY SAFETY.*AK
98 V 150 001/WINDSHIELD WIPER WIRING: REPORTING WIPERS WORK INTERMITTENTLY. DEALER AND MANUFACTURER WERE NOTIFIED, AND INFORMED CONSUMER THAT VEHICLE WAS NOT COVERED UNDER RECALL DUE TO VIN. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION CONCERNING THIS MATTER.*AK
SPARE TIRE HOIST CABLE FATIGUED NEAR WHEEL RETAINER AND TIRE FELL FROM VEHICLE; THEFT DETERRENT CABLE KEPT TIRE FROM FALLING COMPLETELY AWAY AND CAUSED TIRE TO LIFT THE REAR END OF MY TRUCK. THERE IS NO APPARENT DAMAGE OTHER THAN A BENT REAR LICENSE PLATE. I FEAR THAT THIS MAY HAPPEN TO SOMEONE AT HIGHWAY SPEEDS CAUSING LOSS O…
Read full complaint
SPARE TIRE HOIST CABLE FATIGUED NEAR WHEEL RETAINER AND TIRE FELL FROM VEHICLE; THEFT DETERRENT CABLE KEPT TIRE FROM FALLING COMPLETELY AWAY AND CAUSED TIRE TO LIFT THE REAR END OF MY TRUCK. THERE IS NO APPARENT DAMAGE OTHER THAN A BENT REAR LICENSE PLATE. I FEAR THAT THIS MAY HAPPEN TO SOMEONE AT HIGHWAY SPEEDS CAUSING LOSS OF CONTROL OR IF THEFT DETERRENT CABLE IS NOT IN PLACE THE TIRE MAY FALL FROM UNDERNEATH THE VEHICLE AND STRIKE ANOTHER VEHICLE OR CAUSE A ROAD HAZARD. I WAS FORTUNATE TO BE A FEW HUNDRED FEET FROM MY HOME WHEN THIS HAPPENED. THE CABLE APPEARED TO BE FATIGUED AT THE POINT WHERE THE BREAK OCCURED. PLEASE CONTACT ME TO ASSURE THAT THIS INFORMATION IS PROCESSED. THANK YOU.*AK
ABS WARNING LIGHT WAS ON. CONSUMER TOOK VEHICLE TO A MECHANIC, AND MECHANIC STATED THAT BRAKING SYSTEM IS WIRED WRONGLY, AND AND THAT IS WHY THE LIGHT IS COMING ON. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
3 LUGS: STUDS ON RIGHT REAR WHEEL SHEARED OFF UNDER NORMAL DRIVING CONDITIONS. *AK
WINDSHIELD WIPERS WORK INTERMITTENTLY. AFTER A FEW MONTHS, WINDSHIELD WIPERS BASICALLY STOPPED WORKING. CONTACTED DEALER, AND DEALER WAS NOT WILLING TO DO ANYTHING.*AK *SLC
CONSUMER STATES WHILE DRIVING THE CHECK ENGINE LIGHT CAME ON, THE TRANSMISSION FLUID WAS CHANGED AND OIL WAS CHANGED, AND FOR AWHILE THE LIGHT WENT OFF, UNTIL OCTOBER 1, 2001 THE ENGINE LIGHT HAS COME ON AGAIN THE VEHICLE WAS PUT ON A MACHINE AN A CODE OF 1103 APPEARED THE DEALER WAS CALLED AND STATED THERE IS NO SUCH CODE, PPOS…
Read full complaint
CONSUMER STATES WHILE DRIVING THE CHECK ENGINE LIGHT CAME ON, THE TRANSMISSION FLUID WAS CHANGED AND OIL WAS CHANGED, AND FOR AWHILE THE LIGHT WENT OFF, UNTIL OCTOBER 1, 2001 THE ENGINE LIGHT HAS COME ON AGAIN THE VEHICLE WAS PUT ON A MACHINE AN A CODE OF 1103 APPEARED THE DEALER WAS CALLED AND STATED THERE IS NO SUCH CODE, PPOSSIBLE ENGINE PROBLEMS, BUT AS OF NOW NO ONE KNOWS WHAT THE PROBLEM IS.*JB
WHILE DRIVING IN RAIN WINDSHIELD WIPERS STOP WORKING WITH NO PRIOR WARNING. THEY WORK INTERMITTENTLY. ALSO, HAD TO REPLACE WINDSHIELD WIPER CONTROL MODULE. PLEASE ADD VIN. *AK
Official recalls
703V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
99V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
97V146001 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Sep 11, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER PICKUP TRUCKS EQUIPPED WITH 4.3L ENGINES. THE FRONT BRAKE LINE CAN CONTACT THE LEFT-HAND SIDE OF THE ENGINE OIL PAN CAUSING THE BRAKE LINE TO WEAR TO THE POINT OF BRAKE FLUID LOSS DURING BRAKE APPLICATION.
Consequence & remedy
Consequence: BRAKE FLUID LOSS CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE STOPPING DISTANCES RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE OIL PAN AND THE BRAKE LINE. IF THE CLEARANCE IS 6MM OR LESS, DEALERS WILL INSTALL AN ADDITIONAL BRAKE LINE CLIP AND IF THERE WAS CONTACT BETWEEN THE OIL PAN AND BRAKE LINE, THE FRONT BRAKE LINE WILL BE REPLACED.
97V096001 · Seat Belts
Jun 12, 1997
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
97V008001 · Visibility:windshield
Jan 27, 1997
THE TOP COAT PAINT SEVERELY PEELS DUE TO OVERBAKING OF THE POWDER PRIMER PRIOR TO THE TOP COAT APPLICATION. SINCE THE WINDSHIELD PRIMER AND ADHESIVE ADHERE TO THE TOP COAT PAINT ONTHE WINDSHIELD OPENING FLANGE, THE WINDSHIELD DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WINDSHIELD MAY NOT STAY IN PLACE AS REQUIRED BY FMVSS NO. 212.
Remedy: ALL VEHICLES HAVE BEEN REPURCHASED. THIS CAMPAIGN IS 100%.
96V035000 · Power Train:manual Transmission
Feb 22, 1996
SOME OF THESE TRUCKS WERE BUILT WITH TRANSMISSIONS CONTAINING PARTS WHICH WERE NOT MACHINED TO GM'S SPECIFICATIONS.
Consequence & remedy
Consequence: THESE TRANSMISSIONS COULD SEIZE AND LOCK THE REAR DRIVE WHEELS WHILE THE TRUCK IS BEING DRIVEN CAUSING A LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION MAIN SHAFT OUTPUT TORQUE USING A SPECIAL TOOL. IF THE OUTPUT TORQUE DOES NOT MEET SPECIFICATIONS, THE TRANSMISSION WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA99018 · Spare Tire Separation From Vehicle
Opened Jun 30, 1999 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Equipment
No summary supplied.
PE99004 · Separation Of Spare Tire From Vehicle
Opened Jan 15, 1999 · Closed Jun 30, 1999
Status: closed (inferred from source dates) · Equipment
ALLEGED THAT WIRE CABLE/WINCH ASSEMBLY WHICH HOLDS THE SPARE TIRE/WHEEL ASSEMBLY UDER THE REAR OF THE VEHICLE MAY FAIL, ALLOWING THE TIRE TO FALL FROM THE VEHICLE WHILE IN MOTION
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.