WHILE DRIVING THE SPARE TIRE CABLE SHEARED OFF, RESULTING IN THE LOSS OF THE SPARE TIRE. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND DROVE IT TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT THE CABLE AND RACKET WAS A SET AND NEEDED REPLACEMENT. CONSUMER INFORMED THE MECHANIC THAT A RECALL WAS NOT FOR THIS …
Read full complaint
WHILE DRIVING THE SPARE TIRE CABLE SHEARED OFF, RESULTING IN THE LOSS OF THE SPARE TIRE. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND DROVE IT TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT THE CABLE AND RACKET WAS A SET AND NEEDED REPLACEMENT. CONSUMER INFORMED THE MECHANIC THAT A RECALL WAS NOT FOR THIS VEHICLE. AND AS A CONSUMER THE PAYMENT SHOULD RENDERED ON THE DEALER, NOT ON THE CONSUMER. *AK
NHTSA ODI #10084048
Mileage unknown · Dec 29, 2003
Tires
TIRE DEVELOPED A BULGE THE TREAD BEGAN TO MELT, AND THE RADIAL CORDS BECAME VISIBLE.*AK
NHTSA ODI #10052075
Mileage unknown · Sep 28, 2000
Tires
FIRESTONE TIRE EXPERIENCED BLOW OUT CAUSING VEHICLE TO SKID AND ROLLOVER,CONSUMER WAS KILLED DURING ACCIDENT. *SLC
NHTSA ODI #555427
Mileage unknown · Oct 23, 1999
Engine And Engine CoolingEquipmentService Brakes, Air
HAVE HAD PROBLEMS WITH THE WINDSHIELD WIPERS FROM THE BEGINNING. I WOULD BE DRIVING IN POURING-DOWN RAIN AND THE WIPERS WOULD GO OUT CAUSING ME TO HAVE TO PULL OVER. RIGHT NOW THEY DO NOT WORK AT ALL. I HAD TO WORK ON MY BRAKES THE FIRST YEAR AND A COUPLE OF TIMES THEREAFTER. I RECENTLY HAD TO HAVE MY AIR-CONDITIONER DONE. T…
Read full complaint
HAVE HAD PROBLEMS WITH THE WINDSHIELD WIPERS FROM THE BEGINNING. I WOULD BE DRIVING IN POURING-DOWN RAIN AND THE WIPERS WOULD GO OUT CAUSING ME TO HAVE TO PULL OVER. RIGHT NOW THEY DO NOT WORK AT ALL. I HAD TO WORK ON MY BRAKES THE FIRST YEAR AND A COUPLE OF TIMES THEREAFTER. I RECENTLY HAD TO HAVE MY AIR-CONDITIONER DONE. THE LATEST WAS MY WATER PUMP THAT I FIXED MYSELF. THE WORSE WAS MY MOTOR. I HAD BEEN STALLED A NUMBER OF TIMES TILL FINALLY IT WOULDN'T GO AT ALL. I HAD IT TOWED TO MICHAEL HOLLEY CHEVROLET IN LAKELAND (THE TOWN I WORKED IN). THEY REFUSED TO HONOR MY SMARTCARE SAYING I HAD NOT CHANGED THE OIL. THAT WAS NOT TRUE SINCE I HAD CHANGED IT MYSELF AND HAD IT CHANGED ALSO. THEY WANTED OVER 3000 FOR A NEW MOTOR. I AM AND WAS STILL PAYING ON MY TRUCK AND DID NOT HAVE THAT MUCH CASH. I HAD TO TOW IT AT MY MOTHERS AND PARK IT. I WAS ABLE TO CHANGE THE OIL AND NOTICED THAT THE CHEVROLET DEALERS HAD REMOVED THE ALTERNATOR BELT AND HAD LEFT IT LOOSE. THAT DID NOT GIVE ME ANY CONFIDENCE IN THEM. 4 MONTHS LATER MY MOTHER'S CAR WAS TOTALLED AND SHE PAID FOR ME TO GET A MOTOR FROM AN AMOCO DEALER. IN SEPTEMBER OF 1999 MY MOTHER WAS SURFING THE NET AND FOUND OUT THAT THERE HAD BEEN RECALLS ON THIS VEHICLE ALMOST FROM THE FIRST AND I HAVE NEVER BEEN NOTIFIED AT ALL. I WROTE TO THE HOME OFFICE IN EARLY SEPTEMBER BUT RECEIVED NO ANSWER. I STILL OWE 2 YEARS PAYMENTS. IF I HAD BEEN TRAVELING ON THE HIGHWAY WHEN MY MOTOR WENT OUT ON ME SOMETHING BAD COULD HAVE VERY WELL HAPPENED. I FEEL SURE THAT I WILL NEVER TRUST IN CHEVY'S PRODUCTS AGAIN.
NHTSA ODI #713753
Mileage unknown · Jun 22, 1999
Engine And Engine CoolingTires
VEHICLE RIDES GREAT. JUST STAYS IN THE SHOP MORE THAN ON THE ROAD! NO SAFETY DEFECT INDICATED IN THE SUMMARY. *AK
NHTSA ODI #707760
Mileage unknown · Dec 1, 1998
TiresCrash
CABLE HOLDING SPARE TIRE TO UNDERSIDE OF BODY BROKE WHILE VEHICLE WAS MOVING. WHEEL HIT ANOTHER VEHICLE ON THE ROADWAY CAUSING $1140.00 DAMAGE, PLUS REPLACEMENT COSTS OF SPARE TIRE HOIST TO MY VEHICLE.
NHTSA ODI #701040
Mileage unknown · Sep 18, 1998
Service Brakes, HydraulicTires
REAR DRIVER'S SIDE TIRE FELL OFF, WHICH ALMOST CAUSED AN ACCIDENT. ALSO BRAKES MALFUNCTIONED.*AK
NHTSA ODI #828002
Mileage unknown · Aug 29, 1998
Power TrainService Brakes, HydraulicTires
BRAKE POWER BOOSTER FAILED.
NHTSA ODI #539453
Mileage unknown · Jun 29, 1998
Tires
WHILE DRIVING VEHICLE THE SPARE TIRE WHICH IS LOCATED UNDER VEHICLE FELL OFF. VEHICLE SPEED WAS 45-50 MPH PRIOR TO DEFECT. CAUSE UNKNOWN.
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER PICKUP TRUCKS EQUIPPED WITH 4.3L ENGINES. THE FRONT BRAKE LINE CAN CONTACT THE LEFT-HAND SIDE OF THE ENGINE OIL PAN CAUSING THE BRAKE LINE TO WEAR TO THE POINT OF BRAKE FLUID LOSS DURING BRAKE APPLICATION.
Consequence & remedy
Consequence: BRAKE FLUID LOSS CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE STOPPING DISTANCES RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE OIL PAN AND THE BRAKE LINE. IF THE CLEARANCE IS 6MM OR LESS, DEALERS WILL INSTALL AN ADDITIONAL BRAKE LINE CLIP AND IF THERE WAS CONTACT BETWEEN THE OIL PAN AND BRAKE LINE, THE FRONT BRAKE LINE WILL BE REPLACED.
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
THE TOP COAT PAINT SEVERELY PEELS DUE TO OVERBAKING OF THE POWDER PRIMER PRIOR TO THE TOP COAT APPLICATION. SINCE THE WINDSHIELD PRIMER AND ADHESIVE ADHERE TO THE TOP COAT PAINT ONTHE WINDSHIELD OPENING FLANGE, THE WINDSHIELD DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WINDSHIELD MAY NOT STAY IN PLACE AS REQUIRED BY FMVSS NO. 212.
Remedy: ALL VEHICLES HAVE BEEN REPURCHASED. THIS CAMPAIGN IS 100%.
SOME OF THESE TRUCKS WERE BUILT WITH TRANSMISSIONS CONTAINING PARTS WHICH WERE NOT MACHINED TO GM'S SPECIFICATIONS.
Consequence & remedy
Consequence: THESE TRANSMISSIONS COULD SEIZE AND LOCK THE REAR DRIVE WHEELS WHILE THE TRUCK IS BEING DRIVEN CAUSING A LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION MAIN SHAFT OUTPUT TORQUE USING A SPECIAL TOOL. IF THE OUTPUT TORQUE DOES NOT MEET SPECIFICATIONS, THE TRANSMISSION WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA99018 · Spare Tire Separation From Vehicle
Opened Jun 30, 1999 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Equipment
No summary supplied.
PE99004 · Separation Of Spare Tire From Vehicle
Opened Jan 15, 1999 · Closed Jun 30, 1999
Status: closed (inferred from source dates) · Equipment
ALLEGED THAT WIRE CABLE/WINCH ASSEMBLY WHICH HOLDS THE SPARE TIRE/WHEEL ASSEMBLY UDER THE REAR OF THE VEHICLE MAY FAIL, ALLOWING THE TIRE TO FALL FROM THE VEHICLE WHILE IN MOTION
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
1996 Chevrolet S10 Problems, Complaints & Recalls | Skip That Year
Illustration