DT*: THE CONTACT STATED WHILE KNEELING ON THE TAILGATE BOTH CABLES BROKE. THE CONTACT SUSTAINED MINOR INJURIES. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THE CABLES WERE REPLACED. THERE IS A NHTSA RECALL, # 06V066000, REGARDING THE TAILGATE CABLES. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT I…
Read full complaint
DT*: THE CONTACT STATED WHILE KNEELING ON THE TAILGATE BOTH CABLES BROKE. THE CONTACT SUSTAINED MINOR INJURIES. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THE CABLES WERE REPLACED. THERE IS A NHTSA RECALL, # 06V066000, REGARDING THE TAILGATE CABLES. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. UPDATED 3/28/2006 - *NM
NHTSA ODI #10152684
77,000 miles · Jan 18, 2005
StructureInjury
NORMAL USE PRIOR TO THE FAILURE; WAS LOADING A RIDING LAWNMOWER INTO MY CHEVY S-10 PICKUP WHEN BOTH TAILGATE CABLES FAILED, INJURING MY FRIEND. I HAD TO HAVE THE DEALER REPLACE THE STRAPS, AS THE PART IS NOT AVAILABLE OUTSIDE THE DEALERSHIP. COST WAS OVER $300! *NM
NHTSA ODI #10106539
130,000 miles · Nov 16, 2004
StructureInjury
FAILURE OF TAILGATE CABLE WHICH HOLDS UP THE TAILGATE. THE CABLE JUST SNAPPED INTO TWO PEICES. IT BROKE IN THE MIDDLE. SUDDEN UNEXPECTED FAILURE !!! *AK
NHTSA ODI #10098917
150,045 miles · Aug 2, 2004
Structure
THE CABLES THAT HOLD THE TAILGATE IN THE OPEN POSITION FAIL AND BREAK, ALLOWING THE TAILGATE TO DROP BELOW THE NORMAL POSITION. THIS IS THE THIRD TIME THE CABLES HAVE BROKEN. THEY WERE REPLACED IN THE PAST WITH PARTS FROM THE CHEVY DEALER. A FRIEND WITH THE SAME TRUCK HAS ALSO HAD THE CABLES BREAK. IF SOMEONE WAS STANDING OR S…
Read full complaint
THE CABLES THAT HOLD THE TAILGATE IN THE OPEN POSITION FAIL AND BREAK, ALLOWING THE TAILGATE TO DROP BELOW THE NORMAL POSITION. THIS IS THE THIRD TIME THE CABLES HAVE BROKEN. THEY WERE REPLACED IN THE PAST WITH PARTS FROM THE CHEVY DEALER. A FRIEND WITH THE SAME TRUCK HAS ALSO HAD THE CABLES BREAK. IF SOMEONE WAS STANDING OR SITTING ON THE TAILGATE WHEN IT DROPS UNEXPCTEDLY, SERIOUS INJURY COULD RESULT. *AK
NHTSA ODI #10083139
Mileage unknown · Jul 30, 2004
Structure
CABLE HOLDING SPARE TIRE UNDERNEATH BROKE WHILE DRIVING BETWEEN 15 TO 20 MPH. AS A RESULT, THE SPARE TIRE FELL OFF IN A SMALL TOWN. *AK *SC
NHTSA ODI #10081534
Mileage unknown · Oct 3, 2003
Structure
THE VEHICLE'S FRAME WAS BROKEN IN TWO PLACES WHICH RESULTED IN THE FRAME DETACHING FROM THE VEHICLE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NLM
NHTSA ODI #10042256
Mileage unknown · May 31, 2003
Electrical SystemEquipmentExterior Lighting
TURN SIGNALS MALFUNCTIONED. THE A/C STOPPED WORKING DUE TO A FAULTY EVAPORATOR. THE STABILIZER BAR BROKE ON RIGHT SIDE WHICH CAUSED DRIFT/PULL. ENGINE COOLANT/ANTIFREEZE LEAKED. THE BALL JOINT FOR THE RIGHT-FRONT TIRE GAVE OUT. THE ALTERNATOR HAD TO BE FIXED AND REPLACED THE BATTERY. SPEEDOMETER SEEMED TO BE OFF BY 5 MPH. …
Read full complaint
TURN SIGNALS MALFUNCTIONED. THE A/C STOPPED WORKING DUE TO A FAULTY EVAPORATOR. THE STABILIZER BAR BROKE ON RIGHT SIDE WHICH CAUSED DRIFT/PULL. ENGINE COOLANT/ANTIFREEZE LEAKED. THE BALL JOINT FOR THE RIGHT-FRONT TIRE GAVE OUT. THE ALTERNATOR HAD TO BE FIXED AND REPLACED THE BATTERY. SPEEDOMETER SEEMED TO BE OFF BY 5 MPH. THE WINDSHIELD WIPERS WOULD NOT WORK PROPERLY AND STOPPED IN THE MIDDLE OF A DOWN-POUR. THE DEVICE TO LOWER THE SPARE TIRE HAD TO BE REPLACED. *TT
NHTSA ODI #10020819
Mileage unknown · Dec 27, 2001
StructureInjury
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #756085
Mileage unknown · Dec 26, 2000
Structure
LEFT FRONT DRIVER DOOR HINGE WELDS FAILED. *SLC
NHTSA ODI #785166
Mileage unknown · Sep 5, 2000
Structure
CABLE THAT SUPPORTS TAILGATE SNAPPED & FELL DOWN. CONSUMER & CHILD WERE SIITING IN THE REAR WHEN IT HAPPENED, BUT NO ONE WAS HURT. CONSUMER WILL CONTACT MANUFACTURER. *AK
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER PICKUP TRUCKS EQUIPPED WITH 4.3L ENGINES. THE FRONT BRAKE LINE CAN CONTACT THE LEFT-HAND SIDE OF THE ENGINE OIL PAN CAUSING THE BRAKE LINE TO WEAR TO THE POINT OF BRAKE FLUID LOSS DURING BRAKE APPLICATION.
Consequence & remedy
Consequence: BRAKE FLUID LOSS CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE STOPPING DISTANCES RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE OIL PAN AND THE BRAKE LINE. IF THE CLEARANCE IS 6MM OR LESS, DEALERS WILL INSTALL AN ADDITIONAL BRAKE LINE CLIP AND IF THERE WAS CONTACT BETWEEN THE OIL PAN AND BRAKE LINE, THE FRONT BRAKE LINE WILL BE REPLACED.
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
THE TOP COAT PAINT SEVERELY PEELS DUE TO OVERBAKING OF THE POWDER PRIMER PRIOR TO THE TOP COAT APPLICATION. SINCE THE WINDSHIELD PRIMER AND ADHESIVE ADHERE TO THE TOP COAT PAINT ONTHE WINDSHIELD OPENING FLANGE, THE WINDSHIELD DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WINDSHIELD MAY NOT STAY IN PLACE AS REQUIRED BY FMVSS NO. 212.
Remedy: ALL VEHICLES HAVE BEEN REPURCHASED. THIS CAMPAIGN IS 100%.
SOME OF THESE TRUCKS WERE BUILT WITH TRANSMISSIONS CONTAINING PARTS WHICH WERE NOT MACHINED TO GM'S SPECIFICATIONS.
Consequence & remedy
Consequence: THESE TRANSMISSIONS COULD SEIZE AND LOCK THE REAR DRIVE WHEELS WHILE THE TRUCK IS BEING DRIVEN CAUSING A LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION MAIN SHAFT OUTPUT TORQUE USING A SPECIAL TOOL. IF THE OUTPUT TORQUE DOES NOT MEET SPECIFICATIONS, THE TRANSMISSION WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA99018 · Spare Tire Separation From Vehicle
Opened Jun 30, 1999 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Equipment
No summary supplied.
PE99004 · Separation Of Spare Tire From Vehicle
Opened Jan 15, 1999 · Closed Jun 30, 1999
Status: closed (inferred from source dates) · Equipment
ALLEGED THAT WIRE CABLE/WINCH ASSEMBLY WHICH HOLDS THE SPARE TIRE/WHEEL ASSEMBLY UDER THE REAR OF THE VEHICLE MAY FAIL, ALLOWING THE TIRE TO FALL FROM THE VEHICLE WHILE IN MOTION
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
1996 Chevrolet S10 Problems, Complaints & Recalls | Skip That Year
Illustration