IllustrationNO SUMMARY. *AK
1996 Chevrolet S10
Owner reports · Recalls · Investigations
More warning signs than most S10 years
Owner complaints for the 1996 Chevrolet S10 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all S10 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 34 of 665 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 209 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
110 crash reports11 fire reports50 injury reports
Service Brakes, Hydraulic complaints
209 reportsABS BRAKES FAIL TO WORK PROPERLY, ALMOST CAUSING CRASH
ABS/BRAKES HAVE FAILED MANY TIMES. REAR BRAKES LOCK UP SEVERELY CAUSING LOSS OF CONTROL. THIS HAS OCCURRED NUMEROUS TIMES AND IS EXTREMELY DANGEROUS. HAVE SEEN MANY SIMILAR FAILURES AT YOUR WEB SITE. PLEASE DO SOMETHING.
ANTI LOCK BRAKES FAILED RESULTING IN VEHICLE COLLISION.
FOUND OUTER BRAKE PADS WORN DOWN TO METAL DURING ROUTINE TIRE ROTATION, AT 21500 HIGHWAY MILES, WITH NO PRIOR WARNING. DEALER SAYS I WAS LUCKY AS HE HAS RECEIVED MANY SIMILAR COMPLAINTS AT MUCH LOWER MILEAGE. DEALER SAYS THIS IS DUE TO REMOVAL OF ASBESTOS FROM PAD MATERIAL AND GM UNDERSIZING THE ROTORS. IN ADDITION, THE WEAR …
Read full complaint
FOUND OUTER BRAKE PADS WORN DOWN TO METAL DURING ROUTINE TIRE ROTATION, AT 21500 HIGHWAY MILES, WITH NO PRIOR WARNING. DEALER SAYS I WAS LUCKY AS HE HAS RECEIVED MANY SIMILAR COMPLAINTS AT MUCH LOWER MILEAGE. DEALER SAYS THIS IS DUE TO REMOVAL OF ASBESTOS FROM PAD MATERIAL AND GM UNDERSIZING THE ROTORS. IN ADDITION, THE WEAR INDICATORS ARE LOCATED ON THE INNER PADS WHICH WEAR AT A MUCH SLOWER RATE, AS IN MY CASE. THE UNDERDESIGN OF THIS BRAKE SYSTEM IS A SAFETY HAZARD AND GM'S RESPONSIBILITY. GM NEEDS TO BE MADE TO CONDUCT A RECALL TO REPLACE CALIPERS, ROTORS AND PADS WITH A SAFE DESIGN BEFORE SOMEONE GETS KILLED!
WHILE DRIVING SLOWLY, STOPPING AND PICKING UP SPEED, APPLIED BRAKES, AND THE BRAKE'S WENT STRAIGHT TO THE FLOORBOARD AND LOCKED UP. THE VEHICLE HAS BEEN IN THE SHOP FOUR TO FIVE TIMES FOR REPAIRS. DEALER REPLACED THE BRAKES AND THE PROBLEM HAS RETURNED. *AK
BRAKES HAVE BEEN REPLACED THREE TIMES, AND THE PROBLEM STILL EXISTS, REPAIR WORK, I.E. PADS, ROTORS, HAVE BEEN DONE. DEALER CANNOT DUPLICATE THE PROBLEM. *AK CONSUMER STATES VEHICLE PULLS TO THE SIDE WHEN BRAKES ARE APPLIED, THE PEDAL DID NOT FEEL RIGHT FROM DAY ONE, ON THE FIRST DEALER VISIT THE RIGHT FRONT ASSEMBLY, CALIPER,…
Read full complaint
BRAKES HAVE BEEN REPLACED THREE TIMES, AND THE PROBLEM STILL EXISTS, REPAIR WORK, I.E. PADS, ROTORS, HAVE BEEN DONE. DEALER CANNOT DUPLICATE THE PROBLEM. *AK CONSUMER STATES VEHICLE PULLS TO THE SIDE WHEN BRAKES ARE APPLIED, THE PEDAL DID NOT FEEL RIGHT FROM DAY ONE, ON THE FIRST DEALER VISIT THE RIGHT FRONT ASSEMBLY, CALIPER, PADS, ROTORS, WERE REPLACED DUE TO BEING LOOSE AND PADS HAD COMPLETELY WORE DOWN AND WERE SQUEAKING, AT 16000 MILES THIS PROBLEM REPEATED ITSELF, ON 28-SEP-98 VEHICLE WAS INVOLVED IN AN ACCIDENT, ONE PERSON WAS INJURED AND THE DRIVER AIR BAG DID NOT DEPLOY WHEN IT SHOULD HAVE. *SLC
VEHICLE WAS EXPERIENCING INTERMITTENT BRAKE TROUBLES. BRAKES WOULD GRAB ON ONE SIDE, CAUSING BRAKES TO LOCK-UP . VEHICLE BEEN DEALER SHOP AND REPAIRS WERE MADE, BUT LATER ON VEHICLE HAD ONCE AGAIN EXPERIENCED ANOTHER BRAKE LOCK-UP. TAKEN BACK TO DEALER SHOP AND INFORMED OF NOTHING COULD BE FOUND. *AK
REAR DRIVER'S SIDE TIRE FELL OFF, WHICH ALMOST CAUSED AN ACCIDENT. ALSO BRAKES MALFUNCTIONED.*AK
ANTI LOCK BRAKES FAILED RESULTING IN COLLISION, NO DEPLOYMENT OF AIR BAG DURING COLLISION.
Official recalls
703V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
99V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
97V146001 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Sep 11, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER PICKUP TRUCKS EQUIPPED WITH 4.3L ENGINES. THE FRONT BRAKE LINE CAN CONTACT THE LEFT-HAND SIDE OF THE ENGINE OIL PAN CAUSING THE BRAKE LINE TO WEAR TO THE POINT OF BRAKE FLUID LOSS DURING BRAKE APPLICATION.
Consequence & remedy
Consequence: BRAKE FLUID LOSS CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE STOPPING DISTANCES RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE OIL PAN AND THE BRAKE LINE. IF THE CLEARANCE IS 6MM OR LESS, DEALERS WILL INSTALL AN ADDITIONAL BRAKE LINE CLIP AND IF THERE WAS CONTACT BETWEEN THE OIL PAN AND BRAKE LINE, THE FRONT BRAKE LINE WILL BE REPLACED.
97V096001 · Seat Belts
Jun 12, 1997
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
97V008001 · Visibility:windshield
Jan 27, 1997
THE TOP COAT PAINT SEVERELY PEELS DUE TO OVERBAKING OF THE POWDER PRIMER PRIOR TO THE TOP COAT APPLICATION. SINCE THE WINDSHIELD PRIMER AND ADHESIVE ADHERE TO THE TOP COAT PAINT ONTHE WINDSHIELD OPENING FLANGE, THE WINDSHIELD DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WINDSHIELD MAY NOT STAY IN PLACE AS REQUIRED BY FMVSS NO. 212.
Remedy: ALL VEHICLES HAVE BEEN REPURCHASED. THIS CAMPAIGN IS 100%.
96V035000 · Power Train:manual Transmission
Feb 22, 1996
SOME OF THESE TRUCKS WERE BUILT WITH TRANSMISSIONS CONTAINING PARTS WHICH WERE NOT MACHINED TO GM'S SPECIFICATIONS.
Consequence & remedy
Consequence: THESE TRANSMISSIONS COULD SEIZE AND LOCK THE REAR DRIVE WHEELS WHILE THE TRUCK IS BEING DRIVEN CAUSING A LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION MAIN SHAFT OUTPUT TORQUE USING A SPECIAL TOOL. IF THE OUTPUT TORQUE DOES NOT MEET SPECIFICATIONS, THE TRANSMISSION WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA99018 · Spare Tire Separation From Vehicle
Opened Jun 30, 1999 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Equipment
No summary supplied.
PE99004 · Separation Of Spare Tire From Vehicle
Opened Jan 15, 1999 · Closed Jun 30, 1999
Status: closed (inferred from source dates) · Equipment
ALLEGED THAT WIRE CABLE/WINCH ASSEMBLY WHICH HOLDS THE SPARE TIRE/WHEEL ASSEMBLY UDER THE REAR OF THE VEHICLE MAY FAIL, ALLOWING THE TIRE TO FALL FROM THE VEHICLE WHILE IN MOTION
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.