NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
209 reportsClear category filterMileage unknown · Jun 18, 2008
Service Brakes, HydraulicCrash
1996 CHEVY S10 ATTEMPTED TO SLOW BUT HAD EQUIPMENT FAILURE WITH THE BRAKING SYSTEM. CONSUMER THEN SWERVED TO THE RIGHT TO AVOID HITTING THE CAR AHEAD, DROVE ONTO THE CEMENT CURB, AND STRUCK A POLE. *NJ UPDATED 05/12/10 *BF THE BRAKE LINES ON THE LEFT FRONT SIDE AND REAR WERE LEAKING. THE FLUID RESERVOIR WAS VERY LOW …
Read full complaint
1996 CHEVY S10 ATTEMPTED TO SLOW BUT HAD EQUIPMENT FAILURE WITH THE BRAKING SYSTEM. CONSUMER THEN SWERVED TO THE RIGHT TO AVOID HITTING THE CAR AHEAD, DROVE ONTO THE CEMENT CURB, AND STRUCK A POLE. *NJ UPDATED 05/12/10 *BF THE BRAKE LINES ON THE LEFT FRONT SIDE AND REAR WERE LEAKING. THE FLUID RESERVOIR WAS VERY LOW AND IN FACT WAS EMPTY ON THE HALF DESIGNATED FOR THE REAR BRAKE. THE DRIVER ADMITTED USING THE WRONG TYPE OF BRAKE LINE FITTING WHEN HE DID THE BRAKE SERVICING. OHIO TRAFFIC CRASH REPORT #10-0433-91 THE CONSUMER STATED THE ACCIDENT WAS A RESULT OF EXCESSIVE CORROSION ON AND AROUND THE REAR AXLE. UPDATED 05/14/10.*JB
NHTSA ODI #10231790
52,000 miles · Oct 1, 2004
Service Brakes, HydraulicCrash
AFTER HITTING A BUMP IN THE ROAD BRAKES FAILED WHILE THE CONSUMER WAS PARKING IN THE LOT CAUSING THE VEHICLE TO HIT A LAMP POST AT A SPEED OF 5 MPH. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK *TC
NHTSA ODI #10091583
Mileage unknown · Feb 19, 2004
Service Brakes, Hydraulic
THE CONSUMER STATED THAT THE VEHICLE MADE A SLIPPING NOISE WHILE BRAKING. *NM
NHTSA ODI #10059347
8,493 miles · Feb 7, 2004
Service Brakes, Hydraulic
WHEN TRAVELING ON WET PAVEMENT AND UPON APPLYING FORCE TO THE BRAKE PEDAL, NOTICED A LOUD NOISE, PEDAL TRAVELED TO THE FLOORBOARD, VEHICLE GOT INTO A SKID, RESULTING IN LOSS OF VEHICLE CONTROL FOR A BRIEF PERIOD. NOTE-EVERY TIME IT IS WET.*AK
NHTSA ODI #10056719
5 miles · Jan 18, 2004
Service Brakes, Hydraulic
ANTILOCK BRAKE SYSTEMS FAILURE. *CB
NHTSA ODI #10054379
70,000 miles · Jan 15, 2004
EquipmentService Brakes, Hydraulic
...FOR 3 YEARS CHEVROLET DEALERS TOLD ME THERE WAS NOTHING WRONG WITH ABS. THEN IN 2000, RECEIVED RECALL NOTICE LABELED CAMPAIGN #C99046. ON 03/28/2000 TOOK VEHICLE INTO DEALERSHIP. BILL STATES REPROGRAM PCM FOR NEW ANTILOCK PROGRAM ...CALLED CHEVROLET CUSTOMER ASSISTANCE CENTER TODAY, BECAUSE BRAKES FAILED TODAY THE SAME WAY TH…
Read full complaint
...FOR 3 YEARS CHEVROLET DEALERS TOLD ME THERE WAS NOTHING WRONG WITH ABS. THEN IN 2000, RECEIVED RECALL NOTICE LABELED CAMPAIGN #C99046. ON 03/28/2000 TOOK VEHICLE INTO DEALERSHIP. BILL STATES REPROGRAM PCM FOR NEW ANTILOCK PROGRAM ...CALLED CHEVROLET CUSTOMER ASSISTANCE CENTER TODAY, BECAUSE BRAKES FAILED TODAY THE SAME WAY THEY DID BEFORE REPAIR IN 2000. ...I EXPLAINED THE S10 HAD BEEN BROUGHT INTO DEALERSHIP ON 03/28/2000, AS SOON AS I RECEIVED RECALL NOTICE, AND THAT IT APPEARED REPLACEMENT WAS DEFECTIVE. ...I WAS ADVISED THAT CAMPAIGN ENDED 12/2002. WHEN I REITERATED THAT I HAD WORK DONE WITHIN PARAMETERS OF CAMPAIGN,BUT NOW SAME PROBLEM HAD REOCCURRED, I WAS ADVISED IT DIDN'T MATTER, THE CAMPAIGN ENDED 12/2002. ...WHEN I SARCASTICALLY SAID, SO IF I KILL SOMEONE ON WAY TO DEALERSHIP TOMORROW BECAUSE OF ABS FAILURE, YOU'RE NOT RESPONSIBLE? THE RESPONSE WAS: ONLY IF IT HAPPENED BEFORE 12/2002.
NHTSA ODI #10071117
Mileage unknown · Aug 5, 2003
EquipmentService Brakes, Hydraulic
WHEN I APPLY THE BRAKES, THERE ARE OCCASIONS WHEN IT FEELS LIKE THEY RELEASE! AND I DO NOT HAVE THE ABILITY TO STOP. BECAUSE OF THIS I HAVE NARROWLY MISSED OTHER CARS, AND HAVE HAD TO USE CURBS TO STOP. THIS HAS HAPPENED ON MORE OCCASIONS THAN THE ONE LISTED BELOW.*AK
NHTSA ODI #10030832
79,000 miles · Jun 26, 2003
Engine And Engine CoolingService Brakes, Hydraulic
CONSUMER HAD THE SAME PROBLEM AS THE RECALL ON THE ABS LIGHT ILLUMINATING. DEALER WOULD NOT REPAIR BECAUSE VIN WAS NOT INCLUDED. *AK THE VEHICLE CHECK ENGINE LIGHT ILLUMINATED AND THE DEALER INDICATED THAT THE OXYGEN SENSOR WAS BAD, THE RADIATOR LEAKED, THE HEAD GASKET HAD BLOWN AND THE WATER PUMP LEAKED. *PH *NLM
NHTSA ODI #10024971
Mileage unknown · May 2, 2003
Service Brakes, Hydraulic
WHILE DRIVING THE ABS BRAKE LIGHT APPEARED ON THE DASHBOARD PANEL. *NLM
NHTSA ODI #10018100
Mileage unknown · Sep 16, 2002
Service Brakes, Hydraulic
AFTER DEALER REPLACED SWITCH FOR ABS RECALL 99 V 193 000. ANTI LOCK BRAKES FAILED TO OPERATE WHILE DRIVING.*AK
NHTSA ODI #8018702
Official recalls
7Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
Sep 11, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER PICKUP TRUCKS EQUIPPED WITH 4.3L ENGINES. THE FRONT BRAKE LINE CAN CONTACT THE LEFT-HAND SIDE OF THE ENGINE OIL PAN CAUSING THE BRAKE LINE TO WEAR TO THE POINT OF BRAKE FLUID LOSS DURING BRAKE APPLICATION.
Consequence & remedy
Consequence: BRAKE FLUID LOSS CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE STOPPING DISTANCES RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE OIL PAN AND THE BRAKE LINE. IF THE CLEARANCE IS 6MM OR LESS, DEALERS WILL INSTALL AN ADDITIONAL BRAKE LINE CLIP AND IF THERE WAS CONTACT BETWEEN THE OIL PAN AND BRAKE LINE, THE FRONT BRAKE LINE WILL BE REPLACED.
Jun 12, 1997
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
Jan 27, 1997
THE TOP COAT PAINT SEVERELY PEELS DUE TO OVERBAKING OF THE POWDER PRIMER PRIOR TO THE TOP COAT APPLICATION. SINCE THE WINDSHIELD PRIMER AND ADHESIVE ADHERE TO THE TOP COAT PAINT ONTHE WINDSHIELD OPENING FLANGE, THE WINDSHIELD DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WINDSHIELD MAY NOT STAY IN PLACE AS REQUIRED BY FMVSS NO. 212.
Remedy: ALL VEHICLES HAVE BEEN REPURCHASED. THIS CAMPAIGN IS 100%.
Feb 22, 1996
SOME OF THESE TRUCKS WERE BUILT WITH TRANSMISSIONS CONTAINING PARTS WHICH WERE NOT MACHINED TO GM'S SPECIFICATIONS.
Consequence & remedy
Consequence: THESE TRANSMISSIONS COULD SEIZE AND LOCK THE REAR DRIVE WHEELS WHILE THE TRUCK IS BEING DRIVEN CAUSING A LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION MAIN SHAFT OUTPUT TORQUE USING A SPECIAL TOOL. IF THE OUTPUT TORQUE DOES NOT MEET SPECIFICATIONS, THE TRANSMISSION WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA99018 · Spare Tire Separation From Vehicle
Opened Jun 30, 1999 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Equipment
No summary supplied.
PE99004 · Separation Of Spare Tire From Vehicle
Opened Jan 15, 1999 · Closed Jun 30, 1999
Status: closed (inferred from source dates) · Equipment
ALLEGED THAT WIRE CABLE/WINCH ASSEMBLY WHICH HOLDS THE SPARE TIRE/WHEEL ASSEMBLY UDER THE REAR OF THE VEHICLE MAY FAIL, ALLOWING THE TIRE TO FALL FROM THE VEHICLE WHILE IN MOTION
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Illustration