STARTED HAVING PROBLEMS WITH THE HAZARD/BRAKE LIGHT FUSE BLOWING OCCASIONALLY ABOUT 2.5 YR AGO... RECENTLY THE FUSE BLOWS ALMOST AS SOON AS YOU TURN THE VEHICLE ON. BULBS ARE GOOD AND LIGHTS WORK UNTIL THE FUSE BLOWS. I'VE REPLACED THE ELECTRICAL SYSTEM IN THE STEERING COLUMN TWICE IN THAT SAME PERIOD OF TIME. THE MOST RECENT TI…
Read full complaint
STARTED HAVING PROBLEMS WITH THE HAZARD/BRAKE LIGHT FUSE BLOWING OCCASIONALLY ABOUT 2.5 YR AGO... RECENTLY THE FUSE BLOWS ALMOST AS SOON AS YOU TURN THE VEHICLE ON. BULBS ARE GOOD AND LIGHTS WORK UNTIL THE FUSE BLOWS. I'VE REPLACED THE ELECTRICAL SYSTEM IN THE STEERING COLUMN TWICE IN THAT SAME PERIOD OF TIME. THE MOST RECENT TIME HAD NO EFFECT ON THE FUSES BLOWING. *TR
NHTSA ODI #10208722
172,813 miles · Jun 15, 2005
Electrical SystemEngine And Engine Cooling
DT: ONE OF THE CIRCUIT BOARD SHORTED OUT, AND THE VEHICLE WILL NOT START. EVERYTIME STARTING THE VEHICLE SMOKE COMES OUT OF THE VEHICLE, AND ONE CAN SMELL BURNING PLASTIC. SATURDAY GOT THE OIL CHANGED AND DIDN'T NOTICE ANY PROBLEMS.*AK
NHTSA ODI #10125329
67,000 miles · Dec 10, 2004
Electrical System
WIRING HARNESS FAILURE. CAUSES TRUCK TO SHUT DOWN WHEN MOVING. WILL NOT START. HAD REPAIRED ( RIGGED ) BECAUSE THE COST TO REPLACE THIS IS IN EXCESS OF 400 DOLLARS, NOW IS ACTING UP AGAIN. HAD TO REPLACE FAN CLUTCH AS WELL. *AK
NHTSA ODI #10102553
115,000 miles · Feb 12, 2004
Electrical SystemFire
CONSUMER WAS ABLE TO TAKE THE KEY OUT OF THE IGNITION SWITCH WHILE VEHICLE WAS STILL RUNNING. THEN, VEHICLE CAUGHT ON FIRE. *AK
NHTSA ODI #10058029
Mileage unknown · May 31, 2003
Electrical SystemEquipmentExterior Lighting
TURN SIGNALS MALFUNCTIONED. THE A/C STOPPED WORKING DUE TO A FAULTY EVAPORATOR. THE STABILIZER BAR BROKE ON RIGHT SIDE WHICH CAUSED DRIFT/PULL. ENGINE COOLANT/ANTIFREEZE LEAKED. THE BALL JOINT FOR THE RIGHT-FRONT TIRE GAVE OUT. THE ALTERNATOR HAD TO BE FIXED AND REPLACED THE BATTERY. SPEEDOMETER SEEMED TO BE OFF BY 5 MPH. …
Read full complaint
TURN SIGNALS MALFUNCTIONED. THE A/C STOPPED WORKING DUE TO A FAULTY EVAPORATOR. THE STABILIZER BAR BROKE ON RIGHT SIDE WHICH CAUSED DRIFT/PULL. ENGINE COOLANT/ANTIFREEZE LEAKED. THE BALL JOINT FOR THE RIGHT-FRONT TIRE GAVE OUT. THE ALTERNATOR HAD TO BE FIXED AND REPLACED THE BATTERY. SPEEDOMETER SEEMED TO BE OFF BY 5 MPH. THE WINDSHIELD WIPERS WOULD NOT WORK PROPERLY AND STOPPED IN THE MIDDLE OF A DOWN-POUR. THE DEVICE TO LOWER THE SPARE TIRE HAD TO BE REPLACED. *TT
NHTSA ODI #10020819
Mileage unknown · Mar 5, 2002
Electrical System
WHILE DRIVING 65MPH VEHICLE STALLED, LOSING POWER BRAKES AND POWER STEERING. DRIVER TURNED IGNITION OFF AND RESTARTED THE VEHICLE. DEALER SAID IT NEEDED A NEW CONTROL MODULE. *AK DEALER REPLACED VEHICLE COTNROL MODUDLE AT OWNER'S EXPENSE. CONSUMER WAS INFORMED BY DEALER THAT MANUFACTURER IS AWARE OF PROBLEM AND HAD ISSUED A S…
Read full complaint
WHILE DRIVING 65MPH VEHICLE STALLED, LOSING POWER BRAKES AND POWER STEERING. DRIVER TURNED IGNITION OFF AND RESTARTED THE VEHICLE. DEALER SAID IT NEEDED A NEW CONTROL MODULE. *AK DEALER REPLACED VEHICLE COTNROL MODUDLE AT OWNER'S EXPENSE. CONSUMER WAS INFORMED BY DEALER THAT MANUFACTURER IS AWARE OF PROBLEM AND HAD ISSUED A SERVICE BULLETIN (SB66-65-06) TO REPLACE THE VEHICLE CONTROL MODULE. *TT
NHTSA ODI #8004961
Mileage unknown · Sep 10, 2001
Electrical System
WHILE TRAVELING IN AN RAINSTOM HEADLIGHTS SHORT OUT WITHOUT ANY INDICATION. CONSUMER TURNED HEADLIGHTS ON/OFF TO RETURN TO NORMAL TRAVEL . DEALER HAS BEEN CONTACTED. PLEASE PROVIDE FURTHER INFORMATION.*AK
NHTSA ODI #896108
Mileage unknown · Feb 5, 2001
Electrical System
DEALER CANNOT FIND OUT WHAT IS WRONG WITH VEHICLE. WHILE DRIVING JUST SHUT DOWN, THERE WAS A SHORT IN IGNITION .*AK
NHTSA ODI #879851
Mileage unknown · Jan 22, 2001
Electrical System
WHILE TRAVELING AT VARIOUS SPEEDS VEHICLE SHUTS OFF WITHOUT ANY WARNING. *AK
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER PICKUP TRUCKS EQUIPPED WITH 4.3L ENGINES. THE FRONT BRAKE LINE CAN CONTACT THE LEFT-HAND SIDE OF THE ENGINE OIL PAN CAUSING THE BRAKE LINE TO WEAR TO THE POINT OF BRAKE FLUID LOSS DURING BRAKE APPLICATION.
Consequence & remedy
Consequence: BRAKE FLUID LOSS CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE STOPPING DISTANCES RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE OIL PAN AND THE BRAKE LINE. IF THE CLEARANCE IS 6MM OR LESS, DEALERS WILL INSTALL AN ADDITIONAL BRAKE LINE CLIP AND IF THERE WAS CONTACT BETWEEN THE OIL PAN AND BRAKE LINE, THE FRONT BRAKE LINE WILL BE REPLACED.
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
THE TOP COAT PAINT SEVERELY PEELS DUE TO OVERBAKING OF THE POWDER PRIMER PRIOR TO THE TOP COAT APPLICATION. SINCE THE WINDSHIELD PRIMER AND ADHESIVE ADHERE TO THE TOP COAT PAINT ONTHE WINDSHIELD OPENING FLANGE, THE WINDSHIELD DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WINDSHIELD MAY NOT STAY IN PLACE AS REQUIRED BY FMVSS NO. 212.
Remedy: ALL VEHICLES HAVE BEEN REPURCHASED. THIS CAMPAIGN IS 100%.
SOME OF THESE TRUCKS WERE BUILT WITH TRANSMISSIONS CONTAINING PARTS WHICH WERE NOT MACHINED TO GM'S SPECIFICATIONS.
Consequence & remedy
Consequence: THESE TRANSMISSIONS COULD SEIZE AND LOCK THE REAR DRIVE WHEELS WHILE THE TRUCK IS BEING DRIVEN CAUSING A LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION MAIN SHAFT OUTPUT TORQUE USING A SPECIAL TOOL. IF THE OUTPUT TORQUE DOES NOT MEET SPECIFICATIONS, THE TRANSMISSION WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA99018 · Spare Tire Separation From Vehicle
Opened Jun 30, 1999 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Equipment
No summary supplied.
PE99004 · Separation Of Spare Tire From Vehicle
Opened Jan 15, 1999 · Closed Jun 30, 1999
Status: closed (inferred from source dates) · Equipment
ALLEGED THAT WIRE CABLE/WINCH ASSEMBLY WHICH HOLDS THE SPARE TIRE/WHEEL ASSEMBLY UDER THE REAR OF THE VEHICLE MAY FAIL, ALLOWING THE TIRE TO FALL FROM THE VEHICLE WHILE IN MOTION
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
1996 Chevrolet S10 Problems, Complaints & Recalls | Skip That Year
Illustration