IllustrationTHE ACCIDENT WAS ALMOST HEAD ON MAINLY ON THE PASSENGER SIDE. THE IMPACT WAS HARD THE AIR BAGS WENT OFF IN THE OTHER CAR BUT NEITHER ONE OF OURS WENT OFF. FOR ABOUT A YEAR PRIOR TO THE ACCIDENT THE TRUCK WOULD STALL AT RANDOM TIMES. *TR
1996 Chevrolet S10
Owner reports · Recalls · Investigations
More warning signs than most S10 years
Owner complaints for the 1996 Chevrolet S10 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all S10 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 34 of 665 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 209 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
110 crash reports11 fire reports50 injury reports
Air Bags complaints
74 reportsTHE LADY TURNED IN FRONT OF ME AND I TBONED HER. *TR
DT: THE CONSUMER STATED 1996 CHEVROLET S-10 WAS INVOLVED IN A CRASH. UPON IMPACT, AIRBAGS DID NOT DEPLOY. THE TRUCK WAS HIT BY A TRACTOR TRAILER. DRIVER SUSTAINED SEVERE INJURIES, INCLUDING WHIPLASH, A SWOLLEN HEAD, CUT AND SCRAPS, FACIAL ABRASIONS, AND INJURIES TO THE CHEST/LEGS/STOMACH AND A BLACK EYE. THE SEAT BELTS DID …
Read full complaint
DT: THE CONSUMER STATED 1996 CHEVROLET S-10 WAS INVOLVED IN A CRASH. UPON IMPACT, AIRBAGS DID NOT DEPLOY. THE TRUCK WAS HIT BY A TRACTOR TRAILER. DRIVER SUSTAINED SEVERE INJURIES, INCLUDING WHIPLASH, A SWOLLEN HEAD, CUT AND SCRAPS, FACIAL ABRASIONS, AND INJURIES TO THE CHEST/LEGS/STOMACH AND A BLACK EYE. THE SEAT BELTS DID CONTAIN THE DRIVER TO THE SEAT. THE DRIVER HAD MARKS ON THE STOMACH LEFT FROM THE SEAT BELT. BUT, THE SEAT BELTS ON THE DRIVER SAVED HIM FROM FALLING OUT OF THE VEHICLE. THE DRIVER HIT THE STEERING WHEEL WITH HIS FACE ON THE LEFT SIDE. THE BACK WINDOW WAS SHATTERED AND FRONT WINDOW BUSTED, AND THE DOOR CAME OPEN. . THE CONSUMER WAS TAKEN TO AN URGENT CARE FACILITY. THE SECURITY AND SAFETY FOR CONSUMER'S COMPANY TOOK CARE OF THE ACCIDENT, AND DID NOT CALL THE POLICE. THE COMPANY PREPAIRED A REPORT AND HAD PICTURES. *AK
I WAS DRIVING A CHEVY S-10 WHEN A LADY PULLED IN FRONT OF ME. I WAS DOING THE SPEED LIMIT OF ABOUT 55-60 MPH. I ENDED UP HITTING HER CAR AND IN TURN MY TRUCK ROLLED OVER SEVERAL (6-10) TIMES. THE WHOLE TRUCK FROM BUMPER TO BUMPER AND SIDE TO SIDE AND TOP TO BOTTOM WAS DESTROYED. THE TRUCK WAS TOTALED. THE SEATBELT DID ITS …
Read full complaint
I WAS DRIVING A CHEVY S-10 WHEN A LADY PULLED IN FRONT OF ME. I WAS DOING THE SPEED LIMIT OF ABOUT 55-60 MPH. I ENDED UP HITTING HER CAR AND IN TURN MY TRUCK ROLLED OVER SEVERAL (6-10) TIMES. THE WHOLE TRUCK FROM BUMPER TO BUMPER AND SIDE TO SIDE AND TOP TO BOTTOM WAS DESTROYED. THE TRUCK WAS TOTALED. THE SEATBELT DID ITS JOB BUT NO AIRBAG CAME OUT. I BOUGHT THE TRUCK USED FROM A LOCAL CAR DEALER HERE IN CONCORD 2 YEARS AGO. I AM VERY BRUISED AND CUT AND VERY UPSET THAT JUST MAYBE IF THAT AIRBAG HAD WORKED I WOULD NOT HAVE GOTTEN ALL THAT GLASS ALONG WITH EVERYTHING ELSE FLYING MY WAY. I KNOW THAT AN AIRBAG WORKS WHEN IT IS HIT JUST RIGHT, BUT AS I STATED THERE IS NO PART ON THAT TRUCK THAT WAS NOT HIT INCLUDING THE FRONT BUMPER AS IT IS ALMOST OFF THE TRUCK. THE INSURANCE COMPANY IS TAKING CONTROL OF THE TRUCK AS WE SPEAK BUT THERE ARE NUMEROUS PICTURES AND WITNESSES TO THIS. I JUST WANT TO KNOW IF SOMETHING WAS WRONG AND THAT I DID NOT PUT ALL MY SAFETY ASSURANCES INTO THIS AIRBAG. THANK-YOU FOR YOUR TIME. CHRISTINE FLORO
CONCERNS WITH AIR BAGS NOT DEPLOYING DURING AN ACCIDENT.*MR THERE WAS DAMAGE TO THE FRONT OF THE VEHICLE INCLUDING THE HOOD. GM CONDUCTED AN INVESTIGATION INTO THE INCIDENT AND CONCLUDED THAT THE AIRBAG SYSTEM FUNCTIONED AS DESIGNED AND THEREFORE THEY WERE NOT RELIABLE FOR DAMAGES. CONSUMER QUESTIONED THE REASON FOR NONDEPLO…
Read full complaint
CONCERNS WITH AIR BAGS NOT DEPLOYING DURING AN ACCIDENT.*MR THERE WAS DAMAGE TO THE FRONT OF THE VEHICLE INCLUDING THE HOOD. GM CONDUCTED AN INVESTIGATION INTO THE INCIDENT AND CONCLUDED THAT THE AIRBAG SYSTEM FUNCTIONED AS DESIGNED AND THEREFORE THEY WERE NOT RELIABLE FOR DAMAGES. CONSUMER QUESTIONED THE REASON FOR NONDEPLOYMENT WHEN BRAKES WERE APPLIED AFTER READING "WHAT MAKES AN AIR BAG INFLATE" IN THE OWNER'S MANUAL. *PH
WHILE DRIVING 65 MPH VEHICLE SUDDENLY ACCELERATED WITH DRIVER'S BOTH FEET ON THE BRAKE PEDAL. VEHICLE CONTINUED TO ACCELERATE, HIT A GUARD RAIL, AND ROLLED INTO AN EMBANKMENT. UPON IMPACT, BOTH FRONTAL AIRBAGS DID NOT DEPLOY. AN AMBULANCE WAS CALLED BUT DRIVER REFUSED TO GO WITH THE ANBULANCE. VEHICLE WAS TOTALED BY THE…
Read full complaint
WHILE DRIVING 65 MPH VEHICLE SUDDENLY ACCELERATED WITH DRIVER'S BOTH FEET ON THE BRAKE PEDAL. VEHICLE CONTINUED TO ACCELERATE, HIT A GUARD RAIL, AND ROLLED INTO AN EMBANKMENT. UPON IMPACT, BOTH FRONTAL AIRBAGS DID NOT DEPLOY. AN AMBULANCE WAS CALLED BUT DRIVER REFUSED TO GO WITH THE ANBULANCE. VEHICLE WAS TOTALED BY THE INSURANCE COMPANY. *AK
WHILE DRIVING 55 MPH THE CONSUMERS VEHICLE WAS INVOLVED IN A FRONT END COLLISION AND NONE OF THE AIR BAGS DEPLOYED. DEALER NOTIFIED. *NLM *SCC *JB
NO SUMMARY. DT
AIR BAG DID NOT DEPLOY
WHILE DRIVING ENGINE COMPLETELY SHUTDOWN, CAUSE UNKNOWN. AIR BAG LIGHT ILLUMINATES ON DASH, AND BRAKE BOOSTER MALFUNCTIONED. ALSO, WATER PUMP WENT OUT. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
Official recalls
703V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
99V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
97V146001 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Sep 11, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER PICKUP TRUCKS EQUIPPED WITH 4.3L ENGINES. THE FRONT BRAKE LINE CAN CONTACT THE LEFT-HAND SIDE OF THE ENGINE OIL PAN CAUSING THE BRAKE LINE TO WEAR TO THE POINT OF BRAKE FLUID LOSS DURING BRAKE APPLICATION.
Consequence & remedy
Consequence: BRAKE FLUID LOSS CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE STOPPING DISTANCES RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE OIL PAN AND THE BRAKE LINE. IF THE CLEARANCE IS 6MM OR LESS, DEALERS WILL INSTALL AN ADDITIONAL BRAKE LINE CLIP AND IF THERE WAS CONTACT BETWEEN THE OIL PAN AND BRAKE LINE, THE FRONT BRAKE LINE WILL BE REPLACED.
97V096001 · Seat Belts
Jun 12, 1997
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
97V008001 · Visibility:windshield
Jan 27, 1997
THE TOP COAT PAINT SEVERELY PEELS DUE TO OVERBAKING OF THE POWDER PRIMER PRIOR TO THE TOP COAT APPLICATION. SINCE THE WINDSHIELD PRIMER AND ADHESIVE ADHERE TO THE TOP COAT PAINT ONTHE WINDSHIELD OPENING FLANGE, THE WINDSHIELD DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WINDSHIELD MAY NOT STAY IN PLACE AS REQUIRED BY FMVSS NO. 212.
Remedy: ALL VEHICLES HAVE BEEN REPURCHASED. THIS CAMPAIGN IS 100%.
96V035000 · Power Train:manual Transmission
Feb 22, 1996
SOME OF THESE TRUCKS WERE BUILT WITH TRANSMISSIONS CONTAINING PARTS WHICH WERE NOT MACHINED TO GM'S SPECIFICATIONS.
Consequence & remedy
Consequence: THESE TRANSMISSIONS COULD SEIZE AND LOCK THE REAR DRIVE WHEELS WHILE THE TRUCK IS BEING DRIVEN CAUSING A LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION MAIN SHAFT OUTPUT TORQUE USING A SPECIAL TOOL. IF THE OUTPUT TORQUE DOES NOT MEET SPECIFICATIONS, THE TRANSMISSION WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA99018 · Spare Tire Separation From Vehicle
Opened Jun 30, 1999 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Equipment
No summary supplied.
PE99004 · Separation Of Spare Tire From Vehicle
Opened Jan 15, 1999 · Closed Jun 30, 1999
Status: closed (inferred from source dates) · Equipment
ALLEGED THAT WIRE CABLE/WINCH ASSEMBLY WHICH HOLDS THE SPARE TIRE/WHEEL ASSEMBLY UDER THE REAR OF THE VEHICLE MAY FAIL, ALLOWING THE TIRE TO FALL FROM THE VEHICLE WHILE IN MOTION
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.