IllustrationTWO MONITORS HAVE BEEN REPLACED AND AIR LEAKS HAS GOTTEN WORST. *TR
2006 Chevrolet Monte Carlo
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Monte Carlo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
2225–50K
1750–75K
1475–100K
15100–150K
7150K+
94 reports with mileage · 19 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports0 fire reports10 injury reports
Tires complaints
9 reportsI OWN A 2006 CHEVROLET MONTE CARLO, THE TIRE PRESSURE LOW SYSTEM MALFUNCTIONS WITHOUT ANY NOTICE, IF MY CAR WERE A IMPALA GM WOULD FIX IT BUT SINCE IT IS A DISCONTINUED MODEL THEY REFUSE TO DO ANYTHING. THERE IS A GREAT DEAL OF DISCUSSION ON THE NET ABOUT THIS ISSUE ALONG WITH REMOTE START/ LOCK PROBLEM FROM WHAT I UNDERSTAND TH…
Read full complaint
I OWN A 2006 CHEVROLET MONTE CARLO, THE TIRE PRESSURE LOW SYSTEM MALFUNCTIONS WITHOUT ANY NOTICE, IF MY CAR WERE A IMPALA GM WOULD FIX IT BUT SINCE IT IS A DISCONTINUED MODEL THEY REFUSE TO DO ANYTHING. THERE IS A GREAT DEAL OF DISCUSSION ON THE NET ABOUT THIS ISSUE ALONG WITH REMOTE START/ LOCK PROBLEM FROM WHAT I UNDERSTAND THAT IS A PROBLEM THEY DO NOT HONOR. *TR
STARTED GETTING A "SERVICE TIRE MONITERING SYSTEM " MESSAGE WHEN CAR WAS PLACED IN DRIVE. *TR
TIRE PRESSURE MONITORING SYSTEM IS MALFUNCTIONING. IS NOT READING TIRE PRESSURE IN TIRES CORRECTLY. LEFT REAR READS - - *TR
MY VEHICLE'S TPM SYSTEM WAS NOT RESET CORRECTLY AFTER TIRE ROTATION AND GAVE A FALSE READING TO THE TIRE BEING LOW, WHEN IN FACT IT WASN'T READING THE RIGHT TIRES PRESSURE. AFTER USING MANUAL TIRE PRESSURE GAUGE, IT WAS DISCOVERED THAT THE TIRE I WAS INFLATING WAS OVER 65PSI 2006 CHEVROLET MONTE CARLO SS.*TR
WE HAVE A 2006 CHEVY MONTE CARLO WHICH WE BOUGHT IN MARCH OF 2007 WITH 25 MILES ON IT FROM MAROONE CHEVROLET IN FORT LAUDERDALE FLORIDA AFTER ABOUT 6 MONTHS THE " SERVICE TIRE MONITORING SYSTEM " LIGHT WOULD CONTINUOUSLY COME ON. WE TOOK CAR INTO MAROONE IN PEMBROKE PINES AT LEAST 5 TIMES AND EVERY TIME WAS TOLD IT WAS FIXED ..N…
Read full complaint
WE HAVE A 2006 CHEVY MONTE CARLO WHICH WE BOUGHT IN MARCH OF 2007 WITH 25 MILES ON IT FROM MAROONE CHEVROLET IN FORT LAUDERDALE FLORIDA AFTER ABOUT 6 MONTHS THE " SERVICE TIRE MONITORING SYSTEM " LIGHT WOULD CONTINUOUSLY COME ON. WE TOOK CAR INTO MAROONE IN PEMBROKE PINES AT LEAST 5 TIMES AND EVERY TIME WAS TOLD IT WAS FIXED ..NEEDLESS TO SAY TO THIS DAY 1-25-08 IT IS STILL ON WE ARE TAKING IT TO THE DEALER IN THE MORNING AGAIN WHY I HAVE NO IDEA ! AS OF THIS TIME NOTHING IS BEING FIXED AND WE ARE BEING TOLD IT IS ~ IT IS VERY FRUSTRATING AND HURTFUL BEING LIED TO TIME AFTER TIME . *TR
TIRE MONITOR SYSTEM DOES NOT WORK. DEALER AND CHEVROLET BOTH SAY THEY ARE AWARE OF THE PROBLEM AND NO FIX IS AVAILABLE. BOTH MADE IT SOUND LIKE A VERY RECENT PROBLEM BUT AFTER SOME RESEARCH OF MY OWN INCLUDING YOUR SITE, I HAVE FOUND CONSUMERS HAVE BEEN COMPLAINING OF THIS DEFECT FOR ALMOST A YEAR NOW. ARE WE TO JUST TO CONTINUE…
Read full complaint
TIRE MONITOR SYSTEM DOES NOT WORK. DEALER AND CHEVROLET BOTH SAY THEY ARE AWARE OF THE PROBLEM AND NO FIX IS AVAILABLE. BOTH MADE IT SOUND LIKE A VERY RECENT PROBLEM BUT AFTER SOME RESEARCH OF MY OWN INCLUDING YOUR SITE, I HAVE FOUND CONSUMERS HAVE BEEN COMPLAINING OF THIS DEFECT FOR ALMOST A YEAR NOW. ARE WE TO JUST TO CONTINUE TO DRIVE A INFERIOR VEHICLE, LACKING IN MY CASE ANYWAY, A FEATURE THAT WAS A MAJOR PART OF MY DECISION TO PURCHASE THIS VEHICLE? I DON'T KNOW AND APPARENTLY CHEVROLET DOESN'T EITHER. SHAME ON CHEVROLET. HOW CAN THEY CLAIM 100% SATISFACTION WHEN THEY WONT EVEN TELL US WHEN A FIX MAY BE EVOLVING? JUST SMOKE AND MIRRORS. *JB
TIRE MONITOR SYSTEM FAILED FROM DAY ONE. IT HAS NOW BEEN 5 MONTHS WITH NO FIX AVAILABLE. AFFECTS THE REMOTE LOCKS AND STARTER AS WELL. NEED TO BE WITHIN 10 FEET OF CAR FOR IT TO WORK. HAVE HAD IT IN 3 TIMES AND THEY STATE THEY ARE WAITING FOR A FIX AND BULLETIN. HELP CORRECT THIS SOMEONE. THE DEALER IS GETTING NO HELP FROM CHEVR…
Read full complaint
TIRE MONITOR SYSTEM FAILED FROM DAY ONE. IT HAS NOW BEEN 5 MONTHS WITH NO FIX AVAILABLE. AFFECTS THE REMOTE LOCKS AND STARTER AS WELL. NEED TO BE WITHIN 10 FEET OF CAR FOR IT TO WORK. HAVE HAD IT IN 3 TIMES AND THEY STATE THEY ARE WAITING FOR A FIX AND BULLETIN. HELP CORRECT THIS SOMEONE. THE DEALER IS GETTING NO HELP FROM CHEVROLET AT ALL. BAD PRACTICE. I HAVE OWN CHEVROLET FOR 25 YEARS WITH NOT HAVING THIS MUCH TROUBLE FIXING AN ISSUE. MY DEALER IS ALWAYS GREAT IT IS ON THE OTHER END THEY NEED HELP.*JB
CAR SHAKES WHILE DRIVING SINCE NEW. NOW 1000 MILES. BEEN TO A CHEVY DEALER(TEAM CHEV IN SMYRNA, TN) THEY HAVE TRIED 3 SETS OF TIRES, ALL DEFECTIVE. THEY BELIEVE THE RIMS ALSO TO BE DEFECTIVE. CAR STILL SHAKES, AND FEELS LOOSE OVER BUMPS. DEALER SAYS HANDS ARE TIED DUE TO VERY POOR CHAIN OF COMMAND TO PROPERLY RESOLVE THIS MATT…
Read full complaint
CAR SHAKES WHILE DRIVING SINCE NEW. NOW 1000 MILES. BEEN TO A CHEVY DEALER(TEAM CHEV IN SMYRNA, TN) THEY HAVE TRIED 3 SETS OF TIRES, ALL DEFECTIVE. THEY BELIEVE THE RIMS ALSO TO BE DEFECTIVE. CAR STILL SHAKES, AND FEELS LOOSE OVER BUMPS. DEALER SAYS HANDS ARE TIED DUE TO VERY POOR CHAIN OF COMMAND TO PROPERLY RESOLVE THIS MATTER QUICKLY, SO MY NEW CAR DRIVES NEW. COMPUTER WILL NOT ALLOW ME TO CHOOSE TIRE SIZE WHICH IS ACTUALLY 225/60-16. *JB
Official recalls
114V355000 · Electrical System:ignition
Jun 23, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) is recalling certain model year 2005-2009 Buick LaCrosse, 2006-2011 Buick Lucerne, 2000-2005 Cadillac DeVille, 2006-2011 Cadillac DTS, 2006-2014 Chevrolet Impala, and 2006-2007 Chevrolet Monte Carlo vehicles. In the affected vehicles, the weight on the key ring and road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury. Additionally, a key knocked out of the run position will cause loss of engine power, power steering, and power braking, increasing the risk of a vehicle crash.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 23, 2014. Owners may contact General Motors customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), and 1-800-222-1020 (Chevrolet). GM's number for this recall is 14299.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE09025 · Power Steering Fluid Leaks - Fires
Opened May 13, 2009 · Closed Oct 2, 2009
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
GENERAL MOTORS (GM) INITIATED A CUSTOMER SATISFACTION CAMPAIGN IN OCTOBER OF 2006 TO ADDRESS A FAILURE OF THE POWER STEERING HOSE AND/OR CLAMPS THAT COULD OCCUR WHEN THE ENGINE IS STARTED IN VEHICLES PRIMARILY OPERATED IN THE FOLLOWING STATES THAT EXPERIENCE EXTREMELY COLD TEMPERATURES:ALASKA, MAINE, MINNESOTA, MONTANA, NEW HAMPSHIRE, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN AND WYOMING.AT THE TIME THIS PRELIMINARY EVALUATION (PE) WAS OPENED, ONLY 1 OF THE 33 COMPLAINTS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) WAS FROM A STATE COVERED BY THE CUSTOMER SATISFACTION CAMPAIGN.IN RESPONSE TO AN INFORMATION REQUEST SENT BY THE ODI, GM PROVIDED INFORMATION THAT INCLUDED 6 ALLEGED FIRES AND 1 ALLEGED MINOR CRASH POTENTIALLY RELATED TO THE ALLEGED DEFECT. ONE OF THE ALLEGED FIRES IS A DUPLICATE OF A REPORT RECEIVED BY ODI.OF THE FIRE INCIDENTS, 2 OF THE 6 ALLEGED FIRE INCIDENTS OCCURRED AFTER THE REMEDY DETAILED IN THE CUSTOMER SATISFACTION PROGRAM WAS PERFORMED.ONE OF THE VEHICLES WAS TOTALED AS A RESULT OF THE INCIDENT.IT IS UNDETERMINED WHETHER THE INCIDENTS WERE RELATED TO THE ALLEGED DEFECT OR WERE A BY PRODUCT OF THE REPAIR.OF THE OTHER FOUR ALLEGED FIRE INCIDENTS, 1 INCIDENT INVOLVED SMOKE ONLY AND NO VISIBLE FLAMES.BASED ON THE INFORMATION PROVIDED, THE REMAINING 3 FIRE INCIDENTS WERE LOCALIZED EVENTS THAT PRIMARILY INVOLVED DAMAGE TO THE POWER STEERING COMPONENTS AND SURROUNDING WIRING.ALL 3 OF THESE VEHICLES WERE SUBSEQUENTLY REPAIRED.NONE OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS UNATTENDED.ODI IS AWARE OF 1 ADDITIONAL ALLEGED FIRE INCIDENT THAT WAS NOT INCLUDED IN GM'S INFORMATION REQUEST RESPONSE.BASED ON THE CONSUMER'S DESCRIPTION OF THE INCIDENT, THE FIRE WAS QUICKLY EXTINGUISHED BY A FRIEND AND THE VEHICLE WAS SUBSEQUENTLY REPAIRED AT A DEALERSHIP.IN TOTAL ODI IS AWARE OF 6 ALLEGED FIRE INCIDENTS WHERE THE CONSUMER ALLEGED FLAMES WERE VISIBLE.ALL OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS STILL ATTENDED. ODI IS AWARE 1 MINOR CRASH ALLEGED TO BE RELATED TO A POWER STEERING FLUID LEAK.THE CONSUMER ALLEGED A MINOR CRASH OCCURRED AS THE CONSUMER WAS ATTEMPTING TO PULL INTO A DRIVEWAY AND HAD DIFFICULTY NEGOTIATING THE TURN DUE TO EXPERIENCING HIGH POWER STEERING EFFORTS AND STRUCK A SNOW BANK.IN A LETTER DATED SEPTEMBER 21, 2009, GM INFORMED ODI THAT A CUSTOMER SATISFACTION PROGRAM WILL COMMENCE IN DECEMBER OF 2009 FOR THE ENTIRE US. AS A REMEDY THE POWER STEERING HOSE ASSEMBLY FOR VEHICLES WITH V8 ENGINES AND THE POWER STEERING RETURN HOSE AND CLAMPS FOR VEHICLES WITH V6 ENGINES WILL BE REPLACED WITH UPGRADED COMPONENTS.BASED ON THE LOW FREQUENCIES AND MINOR SEVERITIES OF THE ALLEGED FIRE INCIDENTS AND CRASH,NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.GM'S EXPANDED CUSTOMER SATISFACTION PROGRAM WILL PROVIDE FREE REPAIRS TO VEHICLES EXCLUDED FROM THE ORIGINAL CAMPAIGN.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (3)
Steering:hydraulic Power Assist:hose, Piping, And Connections
GENERAL MOTORS (GM) INITIATED A CUSTOMER SATISFACTION CAMPAIGN IN OCTOBER OF 2006 TO ADDRESS A FAILURE OF THE POWER STEERING HOSE AND/OR CLAMPS THAT COULD OCCUR WHEN THE ENGINE IS STARTED IN VEHICLES PRIMARILY OPERATED IN THE FOLLOWING STATES THAT EXPERIENCE EXTREMELY COLD TEMPERATURES:ALASKA, MAINE, MINNESOTA, MONTANA, NEW HAMPSHIRE, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN AND WYOMING.AT THE TIME THIS PRELIMINARY EVALUATION (PE) WAS OPENED, ONLY 1 OF THE 33 COMPLAINTS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) WAS FROM A STATE COVERED BY THE CUSTOMER SATISFACTION CAMPAIGN.IN RESPONSE TO AN INFORMATION REQUEST SENT BY THE ODI, GM PROVIDED INFORMATION THAT INCLUDED 6 ALLEGED FIRES AND 1 ALLEGED MINOR CRASH POTENTIALLY RELATED TO THE ALLEGED DEFECT. ONE OF THE ALLEGED FIRES IS A DUPLICATE OF A REPORT RECEIVED BY ODI.OF THE FIRE INCIDENTS, 2 OF THE 6 ALLEGED FIRE INCIDENTS OCCURRED AFTER THE REMEDY DETAILED IN THE CUSTOMER SATISFACTION PROGRAM WAS PERFORMED.ONE OF THE VEHICLES WAS TOTALED AS A RESULT OF THE INCIDENT.IT IS UNDETERMINED WHETHER THE INCIDENTS WERE RELATED TO THE ALLEGED DEFECT OR WERE A BY PRODUCT OF THE REPAIR.OF THE OTHER FOUR ALLEGED FIRE INCIDENTS, 1 INCIDENT INVOLVED SMOKE ONLY AND NO VISIBLE FLAMES.BASED ON THE INFORMATION PROVIDED, THE REMAINING 3 FIRE INCIDENTS WERE LOCALIZED EVENTS THAT PRIMARILY INVOLVED DAMAGE TO THE POWER STEERING COMPONENTS AND SURROUNDING WIRING.ALL 3 OF THESE VEHICLES WERE SUBSEQUENTLY REPAIRED.NONE OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS UNATTENDED.ODI IS AWARE OF 1 ADDITIONAL ALLEGED FIRE INCIDENT THAT WAS NOT INCLUDED IN GM'S INFORMATION REQUEST RESPONSE.BASED ON THE CONSUMER'S DESCRIPTION OF THE INCIDENT, THE FIRE WAS QUICKLY EXTINGUISHED BY A FRIEND AND THE VEHICLE WAS SUBSEQUENTLY REPAIRED AT A DEALERSHIP.IN TOTAL ODI IS AWARE OF 6 ALLEGED FIRE INCIDENTS WHERE THE CONSUMER ALLEGED FLAMES WERE VISIBLE.ALL OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS STILL ATTENDED. ODI IS AWARE 1 MINOR CRASH ALLEGED TO BE RELATED TO A POWER STEERING FLUID LEAK.THE CONSUMER ALLEGED A MINOR CRASH OCCURRED AS THE CONSUMER WAS ATTEMPTING TO PULL INTO A DRIVEWAY AND HAD DIFFICULTY NEGOTIATING THE TURN DUE TO EXPERIENCING HIGH POWER STEERING EFFORTS AND STRUCK A SNOW BANK.IN A LETTER DATED SEPTEMBER 21, 2009, GM INFORMED ODI THAT A CUSTOMER SATISFACTION PROGRAM WILL COMMENCE IN DECEMBER OF 2009 FOR THE ENTIRE US. AS A REMEDY THE POWER STEERING HOSE ASSEMBLY FOR VEHICLES WITH V8 ENGINES AND THE POWER STEERING RETURN HOSE AND CLAMPS FOR VEHICLES WITH V6 ENGINES WILL BE REPLACED WITH UPGRADED COMPONENTS.BASED ON THE LOW FREQUENCIES AND MINOR SEVERITIES OF THE ALLEGED FIRE INCIDENTS AND CRASH,NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.GM'S EXPANDED CUSTOMER SATISFACTION PROGRAM WILL PROVIDE FREE REPAIRS TO VEHICLES EXCLUDED FROM THE ORIGINAL CAMPAIGN.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Steering:hydraulic Power Assist:power Steering Fluid
GENERAL MOTORS (GM) INITIATED A CUSTOMER SATISFACTION CAMPAIGN IN OCTOBER OF 2006 TO ADDRESS A FAILURE OF THE POWER STEERING HOSE AND/OR CLAMPS THAT COULD OCCUR WHEN THE ENGINE IS STARTED IN VEHICLES PRIMARILY OPERATED IN THE FOLLOWING STATES THAT EXPERIENCE EXTREMELY COLD TEMPERATURES:ALASKA, MAINE, MINNESOTA, MONTANA, NEW HAMPSHIRE, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN AND WYOMING.AT THE TIME THIS PRELIMINARY EVALUATION (PE) WAS OPENED, ONLY 1 OF THE 33 COMPLAINTS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) WAS FROM A STATE COVERED BY THE CUSTOMER SATISFACTION CAMPAIGN.IN RESPONSE TO AN INFORMATION REQUEST SENT BY THE ODI, GM PROVIDED INFORMATION THAT INCLUDED 6 ALLEGED FIRES AND 1 ALLEGED MINOR CRASH POTENTIALLY RELATED TO THE ALLEGED DEFECT. ONE OF THE ALLEGED FIRES IS A DUPLICATE OF A REPORT RECEIVED BY ODI.OF THE FIRE INCIDENTS, 2 OF THE 6 ALLEGED FIRE INCIDENTS OCCURRED AFTER THE REMEDY DETAILED IN THE CUSTOMER SATISFACTION PROGRAM WAS PERFORMED.ONE OF THE VEHICLES WAS TOTALED AS A RESULT OF THE INCIDENT.IT IS UNDETERMINED WHETHER THE INCIDENTS WERE RELATED TO THE ALLEGED DEFECT OR WERE A BY PRODUCT OF THE REPAIR.OF THE OTHER FOUR ALLEGED FIRE INCIDENTS, 1 INCIDENT INVOLVED SMOKE ONLY AND NO VISIBLE FLAMES.BASED ON THE INFORMATION PROVIDED, THE REMAINING 3 FIRE INCIDENTS WERE LOCALIZED EVENTS THAT PRIMARILY INVOLVED DAMAGE TO THE POWER STEERING COMPONENTS AND SURROUNDING WIRING.ALL 3 OF THESE VEHICLES WERE SUBSEQUENTLY REPAIRED.NONE OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS UNATTENDED.ODI IS AWARE OF 1 ADDITIONAL ALLEGED FIRE INCIDENT THAT WAS NOT INCLUDED IN GM'S INFORMATION REQUEST RESPONSE.BASED ON THE CONSUMER'S DESCRIPTION OF THE INCIDENT, THE FIRE WAS QUICKLY EXTINGUISHED BY A FRIEND AND THE VEHICLE WAS SUBSEQUENTLY REPAIRED AT A DEALERSHIP.IN TOTAL ODI IS AWARE OF 6 ALLEGED FIRE INCIDENTS WHERE THE CONSUMER ALLEGED FLAMES WERE VISIBLE.ALL OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS STILL ATTENDED. ODI IS AWARE 1 MINOR CRASH ALLEGED TO BE RELATED TO A POWER STEERING FLUID LEAK.THE CONSUMER ALLEGED A MINOR CRASH OCCURRED AS THE CONSUMER WAS ATTEMPTING TO PULL INTO A DRIVEWAY AND HAD DIFFICULTY NEGOTIATING THE TURN DUE TO EXPERIENCING HIGH POWER STEERING EFFORTS AND STRUCK A SNOW BANK.IN A LETTER DATED SEPTEMBER 21, 2009, GM INFORMED ODI THAT A CUSTOMER SATISFACTION PROGRAM WILL COMMENCE IN DECEMBER OF 2009 FOR THE ENTIRE US. AS A REMEDY THE POWER STEERING HOSE ASSEMBLY FOR VEHICLES WITH V8 ENGINES AND THE POWER STEERING RETURN HOSE AND CLAMPS FOR VEHICLES WITH V6 ENGINES WILL BE REPLACED WITH UPGRADED COMPONENTS.BASED ON THE LOW FREQUENCIES AND MINOR SEVERITIES OF THE ALLEGED FIRE INCIDENTS AND CRASH,NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.GM'S EXPANDED CUSTOMER SATISFACTION PROGRAM WILL PROVIDE FREE REPAIRS TO VEHICLES EXCLUDED FROM THE ORIGINAL CAMPAIGN.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Steering:hydraulic Power Assist System
GENERAL MOTORS (GM) INITIATED A CUSTOMER SATISFACTION CAMPAIGN IN OCTOBER OF 2006 TO ADDRESS A FAILURE OF THE POWER STEERING HOSE AND/OR CLAMPS THAT COULD OCCUR WHEN THE ENGINE IS STARTED IN VEHICLES PRIMARILY OPERATED IN THE FOLLOWING STATES THAT EXPERIENCE EXTREMELY COLD TEMPERATURES:ALASKA, MAINE, MINNESOTA, MONTANA, NEW HAMPSHIRE, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN AND WYOMING.AT THE TIME THIS PRELIMINARY EVALUATION (PE) WAS OPENED, ONLY 1 OF THE 33 COMPLAINTS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) WAS FROM A STATE COVERED BY THE CUSTOMER SATISFACTION CAMPAIGN.IN RESPONSE TO AN INFORMATION REQUEST SENT BY THE ODI, GM PROVIDED INFORMATION THAT INCLUDED 6 ALLEGED FIRES AND 1 ALLEGED MINOR CRASH POTENTIALLY RELATED TO THE ALLEGED DEFECT. ONE OF THE ALLEGED FIRES IS A DUPLICATE OF A REPORT RECEIVED BY ODI.OF THE FIRE INCIDENTS, 2 OF THE 6 ALLEGED FIRE INCIDENTS OCCURRED AFTER THE REMEDY DETAILED IN THE CUSTOMER SATISFACTION PROGRAM WAS PERFORMED.ONE OF THE VEHICLES WAS TOTALED AS A RESULT OF THE INCIDENT.IT IS UNDETERMINED WHETHER THE INCIDENTS WERE RELATED TO THE ALLEGED DEFECT OR WERE A BY PRODUCT OF THE REPAIR.OF THE OTHER FOUR ALLEGED FIRE INCIDENTS, 1 INCIDENT INVOLVED SMOKE ONLY AND NO VISIBLE FLAMES.BASED ON THE INFORMATION PROVIDED, THE REMAINING 3 FIRE INCIDENTS WERE LOCALIZED EVENTS THAT PRIMARILY INVOLVED DAMAGE TO THE POWER STEERING COMPONENTS AND SURROUNDING WIRING.ALL 3 OF THESE VEHICLES WERE SUBSEQUENTLY REPAIRED.NONE OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS UNATTENDED.ODI IS AWARE OF 1 ADDITIONAL ALLEGED FIRE INCIDENT THAT WAS NOT INCLUDED IN GM'S INFORMATION REQUEST RESPONSE.BASED ON THE CONSUMER'S DESCRIPTION OF THE INCIDENT, THE FIRE WAS QUICKLY EXTINGUISHED BY A FRIEND AND THE VEHICLE WAS SUBSEQUENTLY REPAIRED AT A DEALERSHIP.IN TOTAL ODI IS AWARE OF 6 ALLEGED FIRE INCIDENTS WHERE THE CONSUMER ALLEGED FLAMES WERE VISIBLE.ALL OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS STILL ATTENDED. ODI IS AWARE 1 MINOR CRASH ALLEGED TO BE RELATED TO A POWER STEERING FLUID LEAK.THE CONSUMER ALLEGED A MINOR CRASH OCCURRED AS THE CONSUMER WAS ATTEMPTING TO PULL INTO A DRIVEWAY AND HAD DIFFICULTY NEGOTIATING THE TURN DUE TO EXPERIENCING HIGH POWER STEERING EFFORTS AND STRUCK A SNOW BANK.IN A LETTER DATED SEPTEMBER 21, 2009, GM INFORMED ODI THAT A CUSTOMER SATISFACTION PROGRAM WILL COMMENCE IN DECEMBER OF 2009 FOR THE ENTIRE US. AS A REMEDY THE POWER STEERING HOSE ASSEMBLY FOR VEHICLES WITH V8 ENGINES AND THE POWER STEERING RETURN HOSE AND CLAMPS FOR VEHICLES WITH V6 ENGINES WILL BE REPLACED WITH UPGRADED COMPONENTS.BASED ON THE LOW FREQUENCIES AND MINOR SEVERITIES OF THE ALLEGED FIRE INCIDENTS AND CRASH,NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.GM'S EXPANDED CUSTOMER SATISFACTION PROGRAM WILL PROVIDE FREE REPAIRS TO VEHICLES EXCLUDED FROM THE ORIGINAL CAMPAIGN.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.