NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
795 reports75,000 miles · Jun 24, 2005
Air Bags
DT: 2002, CHEVROLET, IMPALA LS, WHILE CONSUMER WAS BACKING THE VEHICLE UP THE AIR BAGS ON BOTH FRONT DRIVERS SIDE AND PASSENGER'S SIDE DEPLOYED, THIS WAS WITHOUT IMPACT , AND NOT WHILE MAKING A SUDDEN STOP. CONSUMER HAD ONLY BACKED UP ABOUT ONE FOOT WHEN THE AIR BAGS DEPLOYED. CONSUMER CONTACTED GM TWICE, UPON CALLING THE S…
Read full complaint
DT: 2002, CHEVROLET, IMPALA LS, WHILE CONSUMER WAS BACKING THE VEHICLE UP THE AIR BAGS ON BOTH FRONT DRIVERS SIDE AND PASSENGER'S SIDE DEPLOYED, THIS WAS WITHOUT IMPACT , AND NOT WHILE MAKING A SUDDEN STOP. CONSUMER HAD ONLY BACKED UP ABOUT ONE FOOT WHEN THE AIR BAGS DEPLOYED. CONSUMER CONTACTED GM TWICE, UPON CALLING THE SECOND TIME, GM INSTRUCTED THE CONSUMER TO TAKE IT TO A LOCAL DEALER, WHO DID A DIAGNOSTIC TEST, AND COULD NOT IDENTIFY THE CAUSE OF THE PROBLEM. GM WILL NOT CORRECT THE PROBLEM. CONSUMER'S INSURANCE AGENCY SAID THAT IT WAS A MANUFACTURER'S DEFECT. CONSUMER REPORTED THE INCIDENT TO THE POLICE , AND THEY SAID THAT THEY WOULD NOT FILE A REPORT BECAUSE THERE WAS NO ACCIDENT. *AK
NHTSA ODI #10126548
36,000 miles · Jun 22, 2005
Service Brakes, Hydraulic
DT: CONSUMER HAS REPLACED THE BRAKE PADS HIMSELF. FIRST, THE BRAKES WERE GRABBING AND THEN THEY STARTED MAKING NOISE. CONSUMER TOOK THE VEHICLE TO THE DEALER, AND AFTER THEY HEARD THE NOISE, THEY TOLD HIM IT WAS THE BRAKES. CONSUMER TOOK THE VEHICLE HIMSELF AND CHANGED THE BRAKE PADS, HE KEPT THE OLD ONES AND THEY WERE UNB…
Read full complaint
DT: CONSUMER HAS REPLACED THE BRAKE PADS HIMSELF. FIRST, THE BRAKES WERE GRABBING AND THEN THEY STARTED MAKING NOISE. CONSUMER TOOK THE VEHICLE TO THE DEALER, AND AFTER THEY HEARD THE NOISE, THEY TOLD HIM IT WAS THE BRAKES. CONSUMER TOOK THE VEHICLE HIMSELF AND CHANGED THE BRAKE PADS, HE KEPT THE OLD ONES AND THEY WERE UNBOUNDED. CONSUMER CALLED THE MANUFACTURER, AND WAS TOLD THAT THEY WOULD COVER THE REPAIR, BUT THE DEALER REFUSED BECAUSE CONSUMER DIDN'T HAVE HIS SERVICE WORK DONE WITH THEM. CONSUMER WAS TOLD THAT BECAUSE OF WHERE HE LIVES THE BRAKE PADS MALFUNCTIONED FASTER. CONSUMER STATED THAT THERE WERE APPROXIMATELY 36,000 MILES ON THE BRAKE PADS.*AK
NHTSA ODI #10126266
53,000 miles · Jun 16, 2005
Electrical System
2002 CHEVY IMPALA THE SECURITY LIGHT GOES ON WHEN DRIVING. AFTER A SHORT PERIOD OF TIME WHEN DRIVING THIS WAY THE CAR WILL NOT START AFTER BEING TURNED OFF. A FRIEND WHO HAS A NEWER IMPALA HAS HAD SECUIRTY LIGHT GO ON WHILE DRIVING AND THE ENGINE TOTALLY SHUT DOWN . VERY SERIOUS IMPLICATIONS COULD ARRIVE IF ON HIGHWAY OR BRIDGE…
Read full complaint
2002 CHEVY IMPALA THE SECURITY LIGHT GOES ON WHEN DRIVING. AFTER A SHORT PERIOD OF TIME WHEN DRIVING THIS WAY THE CAR WILL NOT START AFTER BEING TURNED OFF. A FRIEND WHO HAS A NEWER IMPALA HAS HAD SECUIRTY LIGHT GO ON WHILE DRIVING AND THE ENGINE TOTALLY SHUT DOWN . VERY SERIOUS IMPLICATIONS COULD ARRIVE IF ON HIGHWAY OR BRIDGE AND CAR DIES.
NHTSA ODI #10125557
47,000 miles · Jun 16, 2005
Engine And Engine Cooling
2002 CHEVROLET IMPALA, COOLANT LIGHT HAS BEEN ON FOR 2 YEARS. TOOK IT TO A DEALERSHIP WHEN IT FIRST CAME ON, ONLY TO BE INFORMED THAT IT WAS A "CORROSION PROBLEM" WHICH WAS NOT COVERED BY MY BUMPER TO BUMPER WARANTEE. NOW I DISCOVERED THAT GM'S CHOICE OF DEX-COOL ANTIFREEZE IS VERY WELL KNOWN TO CAUSE CORROSION PROBLEMS, AND THE…
Read full complaint
2002 CHEVROLET IMPALA, COOLANT LIGHT HAS BEEN ON FOR 2 YEARS. TOOK IT TO A DEALERSHIP WHEN IT FIRST CAME ON, ONLY TO BE INFORMED THAT IT WAS A "CORROSION PROBLEM" WHICH WAS NOT COVERED BY MY BUMPER TO BUMPER WARANTEE. NOW I DISCOVERED THAT GM'S CHOICE OF DEX-COOL ANTIFREEZE IS VERY WELL KNOWN TO CAUSE CORROSION PROBLEMS, AND THERE ARE A MYRIAD OF CONSUMER COMPLAINTS ABOUT DEX-COOL DESTROYING HEAD AND INTAKE GASKETS AS WELL! I EXPECT GM TO MAKE GOOD ON A PROBLEM THAT THEY THEMSELVES CAUSED, INSTEAD OF THEIR TO-DATE SNIVELY POLICY OF PASSING THE BUCK BACK TO THE CONSUMER. (IN SHORT, IF THIS ISSUE IS NOT RESOLVED TO MY SATISFACTION IN A TIMELY MANNER, I WILL NEVER BUY A GM PRODUCT EVER AGAIN!)
NHTSA ODI #10125535
19,755 miles · Jun 15, 2005
Service Brakes, Hydraulic
OUR 2002 CHEV IMPALA IS A VACATION AND LONG TRIP VEHICLE, VERY LITTLE CITY DRIVING. AT FIRST WE DROVE IT VERY LITTLE, THEN THE FIRST WINTER WE DROVE IT AND PARKED IT IN THE GARAGE TILL SPRING. THE VEHICLE THEN GAVE US PROBLEMS WITH SHIMMY AND SHAKING ALONG WITH NOISY GRINDING WHEN STOPPING. I TOOK IT TO A DEALER UNDER WARRAN…
Read full complaint
OUR 2002 CHEV IMPALA IS A VACATION AND LONG TRIP VEHICLE, VERY LITTLE CITY DRIVING. AT FIRST WE DROVE IT VERY LITTLE, THEN THE FIRST WINTER WE DROVE IT AND PARKED IT IN THE GARAGE TILL SPRING. THE VEHICLE THEN GAVE US PROBLEMS WITH SHIMMY AND SHAKING ALONG WITH NOISY GRINDING WHEN STOPPING. I TOOK IT TO A DEALER UNDER WARRANTY AND THEY SAID IT HAD WARPED ROTORS AND THEN TURNED ALL 4 ROTORS DOWN AT 19755 MILES. THEN IN JUNE OF 2005 I TOOK IT BACK IN BECAUSE OF A CONSTANT GRINDING SOUND WHEN BACKING UP AND THE SHIMMY WHEN BRAKING WAS RETURNING MORE EVERYDAY. THE DEALER THEN TELLS ME THAT IT IS OUT OF WARRANTY AND THAT IT NEEDS 4 NEW ROTORS BECAUSE THEY ARE WARPED AND PITTED. THIS IS A PEP CAR FROM THE COMPANY AND I MISTAKENLY THOUGHT THAT IT WAS STILL UNDER WARRANTY TILL END OF JULY. I WAS INFORMED THIS IS NOT TRUE AND THAT THE REPAIR WILL BE $732. THIS VEHICLE HAS 30,335 MILES ON IT AND HAS HAD BAD ROTORS AND STOPPING SINCE WE STARTED TO DRIVE IT IN 2002/03 WINTER AND THEN PARKED IT TILL SPRING OF 2004. THIS I BELIEVE IS A DEFINITE SAFTEY HAZARD AND ACCORDING TO THE SERVICE ADVISOR THEY SEE THIS PROBLEM ON THE IMPALAS AND THE MALIBUS ALOT. ACCORDING TO THE ADVISOR GM WILL NOT LET THEM REPLACE THE ROTORS ONLY TURN THEM TO SPECS. THIS I EQUATE TO GETTING OPEN HEART SURGERY AND ONLY USING BANDAIDS AND TAPE TO CLOSE THE ARTERIES AND INCISIONS. I AM TOTALLY DISGUSTED WITH THE QUALITY AND SERVICE WORK DONE BY GENERAL MOTORS. INFERIOR PARTS AND SUBSTANDARD MATERIALS SEEM TO BE THE WAY TO GO AT GM TO GET THEIR REQUIRED PROFITS AT CUSTOMER EXPENSE. THE ADVISOR SAYS THAT THE ROTORS THEY FOUND WERE THE CHEAPEST AND MANUFACTURED IN CHINA. I DON'T THINK THE CHINESE CARE MUCH ABOUT PROVIDING AMERICANS CONSUMERS WITH A QUALITY PRODUCT. GM IS SELLING US OUT FOR THEIR BOTTOM LINE AND WE SUFFER AS THE END USER WHO WILL BE THE INJURED PARTY IF THE PARTS FAIL ON THE ROADS OF AMERICA.
NHTSA ODI #10125443
58,000 miles · Jun 15, 2005
Engine And Engine Cooling
DT: ENGINE STARTED TO SPIT AND SPUTTER. IT GOT WORSE. CALLER CHANGED FUEL FILTER BECAUSE THE DEALER SAID IT MIGHT BE THE PROBLEM. WHILE DRIVING THE VEHICLE THE CAR RAN FAST AND TRIED TO TAKE OFF, AND SHE HAD TO SLAM THE BRAKES HARD, AND HOLD THEM TO T STOP CAR. DEALER SAID A HOLE WAS BURNED INTO THE MANIFOLD, AND WHEN THEY D…
Read full complaint
DT: ENGINE STARTED TO SPIT AND SPUTTER. IT GOT WORSE. CALLER CHANGED FUEL FILTER BECAUSE THE DEALER SAID IT MIGHT BE THE PROBLEM. WHILE DRIVING THE VEHICLE THE CAR RAN FAST AND TRIED TO TAKE OFF, AND SHE HAD TO SLAM THE BRAKES HARD, AND HOLD THEM TO T STOP CAR. DEALER SAID A HOLE WAS BURNED INTO THE MANIFOLD, AND WHEN THEY DID A DIAGNOSTIC TEST, THEY SAID A MISFIRE CODE CAME UP. PROBLEM WAS WITH CATALYTIC CONVERTER BEING PLUGGED. DEALER FIXED THE BURNED INTAKE MANIFOLD BEFORE THEY FOUND THAT THE PROBLEM WAS CATALYTIC CONVERTER. THAT WAS THE ONLY THING WRONG WITH IT. *AK
NHTSA ODI #10125350
Mileage unknown · Jun 14, 2005
Visibility
DT: CONTACT STATES THE REAR DEFROSTER TERMINAL FELL OFF. THIS HAS BEEN THE 5TH TIME THIS OCCURRED. THE REAR WINDOW HAS BEEN REPLACED ONCE, WAITING TO BE REPLACED AGAIN. *AK
NHTSA ODI #10125238
20,000 miles · Jun 7, 2005
Service Brakes, Hydraulic
EXPERIENCED A PULSING IN THE BRAKING OF THE CAR. CONTACTED THE DEALERSHIP, THEY INSPECTED THE BRAKES AND ROTORS, SAID IT WOULD NOT BE COVERED UNDER WARRANTEE. I RETURNED TO MY SHOP (WHERE I WORK) AND THEY TURNED THE ROTORS FOR ME. THIS WAS LAST YEAR. NOW THE PULSING IS BACK. I AM GOING TO CONTACT THE DEALERSHIP AND INFORM THE…
Read full complaint
EXPERIENCED A PULSING IN THE BRAKING OF THE CAR. CONTACTED THE DEALERSHIP, THEY INSPECTED THE BRAKES AND ROTORS, SAID IT WOULD NOT BE COVERED UNDER WARRANTEE. I RETURNED TO MY SHOP (WHERE I WORK) AND THEY TURNED THE ROTORS FOR ME. THIS WAS LAST YEAR. NOW THE PULSING IS BACK. I AM GOING TO CONTACT THE DEALERSHIP AND INFORM THEM OF THE RETURNING PULSATION. SEE WHAT THEY SAY, HAS ANYONE GOTTEN THE DEALERSHIP TO FIX THE PROBLEM???
NHTSA ODI #10124516
52,300 miles · May 27, 2005
Power Train
I HAVE A 2002 CHEVROLET IMPALA. IT HAS AROUND 53,000 MILES ON IT. MY WIFE DRIVES THE CAR AND IT HAS BEEN DRIVEN SLOWLY. ABOUT 3 WEEKS AGO SHE TOLD ME THE CAR SHIFTED HARD AND I DROVE IT AND FOUND THAT PROBLEM ALSO. THAT WENT AWAY FOR 2 WEEKS AND IT HAPPENED AGAIN. WE WERE REFERRED TO A INDEPENDENT TRANSMISSION SHOP AND WE WERE T…
Read full complaint
I HAVE A 2002 CHEVROLET IMPALA. IT HAS AROUND 53,000 MILES ON IT. MY WIFE DRIVES THE CAR AND IT HAS BEEN DRIVEN SLOWLY. ABOUT 3 WEEKS AGO SHE TOLD ME THE CAR SHIFTED HARD AND I DROVE IT AND FOUND THAT PROBLEM ALSO. THAT WENT AWAY FOR 2 WEEKS AND IT HAPPENED AGAIN. WE WERE REFERRED TO A INDEPENDENT TRANSMISSION SHOP AND WE WERE TOLD THAT THE TRANSMISSION IN THE IMPALA HAS BEEN HAVING PROBLEMS AND WE WERE TOLD IT NEEDED TO BE REBUILT. I THEN TOOK THE CAR TO THE CHEVY DEALER AND THEY SAID THEY IS SOME PROBLEMS BUT JUST WOULDNT GET SPECIFIC WITH ME. I THEN WENT TO ANOTHER INDEPENDENT TRANSMISSION SHOP AND WAS TOLD THE SAME THING AS THE FIRST SHOP TOLD ME AND THAT WAS I NEEDED THIS REBUILT. THEY SAID THE TRANSMISSION IS A BAD DESIGN AND WANT $2400. TO $2600. TO FIX IT. THIS IS THE SAME PRICE AS THE FIRST PLACE GAVE ME. I THINK IF THIS IS SO COMMON OF A PROBLEM G.M. SHOULD DO SOMETHING ABOUT IT. I AM GOING BACK TO THE CHEVY DEALER AND AM GOING TO ASK THEM JUST WHAT THEY CAN DO FOR ME. I'M NOT A HAPPY PERSON, THIS CAR HAS NOT BEEN DRIVEN HARD AND INFACT IT'S BEEN TREATED NICELY. I CAN'T FIND A RECALL ON IT BUT IT SEEMS LIKE THERE SHOULD BE ONE IN EFFECT FOR IT. I ALSO THINK THIS PROBLEM COULD BE A SERIOUS ROAD HASSARD IF THE TRANSMISSION GOES OUT WHILE BEING DRIVEN.
NHTSA ODI #10122359
49,000 miles · May 25, 2005
Power Train
DT: ON 4/20/05 WHILE DRIVING,GRINDING NOISE WAS HEARD. VEHICLE BEGAN TO SLOW DOWN UNINTENTIONALLY ,AND UPON PUSHING THE GAS PEDAL, CAR WOULD NOT SPEED UP. THIS OCCURRED ON DRY PAVEMENT ON HIGHWAY. CAR WAS REGULARLY SERVICED WITH RECORDS AVAILABLE. THIS PROBLEM OCCURRED ABOUT EVERY 6 MONTHS. *AK
NHTSA ODI #10122115
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration