NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
10 reportsClear category filter89,000 miles · Sep 12, 2018
SeatsStructure
THE SPRING ON THE DRIVER SEAT BROKE NOT VERY HEAVE PEAPLE DRIVING THE CAR. BODY OF THE CAR I HAVE 2 IMPALAS 2002 AND 2004 BOTH ARE RUSTING UNDER THE DOORS AND AT THE QUARTER PANELS I LOOK AT ALL IMPALAS AROUND THE AGE OF BOTH OF MINE AND 90% OF THE ARE RUSTING IN THE SAME SPOTS. MY CARS WERE RUSTPROOFED AND UNDERNEITH IT IS A …
Read full complaint
THE SPRING ON THE DRIVER SEAT BROKE NOT VERY HEAVE PEAPLE DRIVING THE CAR. BODY OF THE CAR I HAVE 2 IMPALAS 2002 AND 2004 BOTH ARE RUSTING UNDER THE DOORS AND AT THE QUARTER PANELS I LOOK AT ALL IMPALAS AROUND THE AGE OF BOTH OF MINE AND 90% OF THE ARE RUSTING IN THE SAME SPOTS. MY CARS WERE RUSTPROOFED AND UNDERNEITH IT IS A MESS YOU CANT HARDLY GET A JACK UNDER BOTH OF THEM. I KEEP THEM GARAGE KEPT SINCE WE GOT BOTH OF THE I WILL NEVER OWN A IMPALA AGAIN.
NHTSA ODI #11129184
Mileage unknown · Sep 26, 2015
EngineStructureUnknown Or OtherFire
GOT INTO THE CAR FROM WORK DROVE LESS THAN TWO MILES WENT IN THE HOUSE FOR ABOUT 20 MINUTES GOT BACK IN THE CAR DROVE ABOUT A MILE AND A HALF TO GET FOOD GOT BACK IN CAR RETURNED TO PRIOR LOCATION DELIVERY FOOD TO MY MOM WENT INSIDE HOUSE BOUT 5 MINUTES LATER A PASSERBY BANG ON THE DOOR TO NOTIFY US THAT THE CAR WAS ON FIRE USE …
Read full complaint
GOT INTO THE CAR FROM WORK DROVE LESS THAN TWO MILES WENT IN THE HOUSE FOR ABOUT 20 MINUTES GOT BACK IN THE CAR DROVE ABOUT A MILE AND A HALF TO GET FOOD GOT BACK IN CAR RETURNED TO PRIOR LOCATION DELIVERY FOOD TO MY MOM WENT INSIDE HOUSE BOUT 5 MINUTES LATER A PASSERBY BANG ON THE DOOR TO NOTIFY US THAT THE CAR WAS ON FIRE USE A FIRE EXTINGUISHER COULDN'T PUT IT OUT PROCEEDED TO CALL THE FIRE DEPARTMENT
NHTSA ODI #10777801
179,523 miles · Jun 29, 2015
Air BagsStructure
I WAS STANDING OUTSIDE OF THE VEHICLE, WATCHING THE GAUGES ON THE INSTAMENT CLUSTER GOING UP AND DOWN, LIKE THEY WERE LOOSING POWER, THEN BOTH AIR BAGS EXPLODED! ,SHATTERED THE WINDSHIELD AND DASHBOARD! I JUST CANT BELIEVE THAT HAPPENED IF I OR MY LOVED ONES HAD BEEN GOING DOWN THE ROAD!!! WELL I DONT WANT TO THINK ABOUT THAT BU…
Read full complaint
I WAS STANDING OUTSIDE OF THE VEHICLE, WATCHING THE GAUGES ON THE INSTAMENT CLUSTER GOING UP AND DOWN, LIKE THEY WERE LOOSING POWER, THEN BOTH AIR BAGS EXPLODED! ,SHATTERED THE WINDSHIELD AND DASHBOARD! I JUST CANT BELIEVE THAT HAPPENED IF I OR MY LOVED ONES HAD BEEN GOING DOWN THE ROAD!!! WELL I DONT WANT TO THINK ABOUT THAT BUT, THE PIONT IS THE SYSTEM FAILLED. AND IF I HAD HIT A WALL OR SOMETHING AND BEEN KILLED IT WOULD HAVE LOOKED LIKE THE AIR BAGS WORKED PROPERLY. THIS CAR WAS IN MY DRIVE IDELING , IN PARK NO ONE EVEN TOUCHING IT!
NHTSA ODI #10730949
79,000 miles · Mar 31, 2014
Electrical SystemStructureCrash
I HAD JUST DROPPED MY 8 YEAR OLD SON OFF AT SCHOOL, AND I WAS HEADED TO WORK. THE CAR CUT OFF WHILE I WAS SLIDING ON VERY THIN ICE. I COULD NOT STEER AWAY FROM THE BACK OF A PICK UP TRUCK. THE DRIVER DROVE OFF BEFORE I COULD EVEN EXIT THE CAR. THE AIR BAG DID NOT DEPLOY AND I HAD TO HAVE THE CAR TOWED TO MY HOUSE. I HAVE NOT BEE…
Read full complaint
I HAD JUST DROPPED MY 8 YEAR OLD SON OFF AT SCHOOL, AND I WAS HEADED TO WORK. THE CAR CUT OFF WHILE I WAS SLIDING ON VERY THIN ICE. I COULD NOT STEER AWAY FROM THE BACK OF A PICK UP TRUCK. THE DRIVER DROVE OFF BEFORE I COULD EVEN EXIT THE CAR. THE AIR BAG DID NOT DEPLOY AND I HAD TO HAVE THE CAR TOWED TO MY HOUSE. I HAVE NOT BEEN ABLE TO GET IT STARTED SINCE. I HAVE HAD SEVERAL MECHANICS LOOK AT IT BUT NONE COULD FIX THE PROBLEM. I AM A SINGLE PARENT WHO LIVES PAYCHECK TO PAYCHECK. I JUST BOUGHT THE CAR IN OCTOBER. I DO NOT HAVE THE MONEY TO KEEP POURING INTO THIS CAR. I KNOW THERE IS MANUFACTURING PROBLEM BUT I DO NOT HAVE THE MONEY TO HAVE IT TOWED TO A DEALER, MUCH LESS THE MONEY TO HAVE IT FIXED. ALL I WANT TO HAVE MY CAR BACK ON THE ROAD RUNNING. *TR
NHTSA ODI #10575961
87,000 miles · Sep 29, 2008
Structure
I HAVE A 2003 CHEVY IMPALA AND IT IS A MAINTENANCE NIGHTMARE. THE LATEST ISSUE IS I HAVE FOUND A LARGE PUDDLE OF WATER ON THE PASSENGERS SIDE AFTER THE RAIN. A GOOGLE SEARCH SHOWS OTHERS ARE HAVING THE TROUBLE WITH VARIOUS YEARS. I AM TOLD THIS IS A COMMON PROBLEM WITH IMPALA'S AND IS REALLY UNACCEPTABLE. BESIDES HAVING TO R…
Read full complaint
I HAVE A 2003 CHEVY IMPALA AND IT IS A MAINTENANCE NIGHTMARE. THE LATEST ISSUE IS I HAVE FOUND A LARGE PUDDLE OF WATER ON THE PASSENGERS SIDE AFTER THE RAIN. A GOOGLE SEARCH SHOWS OTHERS ARE HAVING THE TROUBLE WITH VARIOUS YEARS. I AM TOLD THIS IS A COMMON PROBLEM WITH IMPALA'S AND IS REALLY UNACCEPTABLE. BESIDES HAVING TO REPLACE ALL THE HUBS, THE CAR LITERALLY ATE TIRES FOR THE FIRST 2 YEARS I OWNED IT BUT HAVE FOUND TIRES THAT LAST MORE THEN 4000 MILES AND LAST THE PAINT IS NOT STAYING ON THE CAR. I CANNOT FIND ANY RECALLS AND I KNOW SEVERAL TRUCKS THAT THE PAINT IS PEALING OFF AND THE OWNERS ARE TOLD TO BAD BY THE DEALER. I HOPE THERE ARE LOTS OF PEOPLE ARE COMPLAINING SO A RECALL CAN BE DONE. I COULD LITERALLY SWIM IN THE WATER FROM THE RAIN THAT CAME IN. OH ALMOST FORGOT THE DRIVERS SIDE POWER WINDOW IS RANDOMLY WORKING AS WELL. *TR
NHTSA ODI #10243935
30,000 miles · Feb 6, 2008
Exterior LightingStructure
THE HEAD LIGHTS ON MY 2002 IMPALA ARE GETTING WATER IN THEM CAUSING ELECTRICAL AND SAFETY PROBLEMS. STEAM - MOISTURE GATHER IN THE LIGHTS AND WE ARE NOT ABLE TO SEE THE ROAD. THIS IA A DEFECT THAT IS ON EVERY 2002-2003 IMPALA I HAVE SEEN, GM REFUSES TO REPLACE OR EVEN RECOGNIZE THE PROBLEM, THEY AND THE DEALER I PURCHASED FROM S…
Read full complaint
THE HEAD LIGHTS ON MY 2002 IMPALA ARE GETTING WATER IN THEM CAUSING ELECTRICAL AND SAFETY PROBLEMS. STEAM - MOISTURE GATHER IN THE LIGHTS AND WE ARE NOT ABLE TO SEE THE ROAD. THIS IA A DEFECT THAT IS ON EVERY 2002-2003 IMPALA I HAVE SEEN, GM REFUSES TO REPLACE OR EVEN RECOGNIZE THE PROBLEM, THEY AND THE DEALER I PURCHASED FROM SAID ITS NOT CONSIDERED A DEFECT UNLESS IT IS A RECALL, I WAS TOLD UNTIL A MAJOR ACCIDENT HAPPENS THAT THEY WILL NOT CONSIDER IT A SAFETY ISSUE. I TOLD THEM WHEN THE LIGHTS GET HOT THE WATER IN THE HEAD LIGHTS TURN TO STEAM FOGGING UP THE LIGHTS PREVENTING ME FROM SEEING THE ROAD WHEN DRIVING AT NIGHT, THEY (THE DEALERSHIP) SAID WELL YOU SHOULD DRIVE ONLY DURING THE DAY. THIS IS ALSO CAUSING OTHER ELECTRICAL PROBLEMS WITH TURN SIGNALS NOT WORKING SOMETIMES AND HAZARDS NOT WORKING NOT TO MENTION HAVING TO REPLACE A BULB EVERYTIME IT GETS WET. THIS HAPPENS ALL THE TIME WHEN WE WASH OUR CAR OR GET INTO BAD WEATHER. I BELIEVE THIS SHOULD BE A RECALL... GM REFUSES TO HANDLE THIS PROBLEM UNTIL WE HAVE MULTIPLE FATAL ACCIDENTS AROUND THE COUNTRY? NOT SMART THERE ARE ALOT OF PEOPLE ON OUR STREETS AND HIGHWAYS THAT ARE BEING PUT AT RISK. *TR
NHTSA ODI #10217095
30,000 miles · Oct 14, 2006
SteeringStructureSuspension
A STATE INSPECTION @30,000 MILES REVEALED A BAD UPPER CONTROL ARM, LEFT AND RIGHT INNER TIE ROD ENDS AND BOTH MOTOR MOUNTS. MY MECHANIC FEELS AS THOUGH THESE PART FAILURES ARE VERY PREMATURE AND WERE CAUSED BY A VERY LOOSE STEERING RACK . HE TOLD ME THAT I SHOULD CONTACT SOMEONE TO SEE IF THERE IS A REPAIR BULLETIN FOR THIS PROB…
Read full complaint
A STATE INSPECTION @30,000 MILES REVEALED A BAD UPPER CONTROL ARM, LEFT AND RIGHT INNER TIE ROD ENDS AND BOTH MOTOR MOUNTS. MY MECHANIC FEELS AS THOUGH THESE PART FAILURES ARE VERY PREMATURE AND WERE CAUSED BY A VERY LOOSE STEERING RACK . HE TOLD ME THAT I SHOULD CONTACT SOMEONE TO SEE IF THERE IS A REPAIR BULLETIN FOR THIS PROBLEM. I DON'T THINK A CAR SHOULD NEED THAT KIND OF FRONT END WORK A 30,000 MILES . I'M ALSO CONCERNED THAT MY WIFE ,WHO DRIVES THE CAR ON A DAILY BASIS, IS AT RISK WHILE DRIVING HERSELF AND OUR 2 KIDS TO AND FROM THEIR DAILY ROUTINES. PLEASE LET ME KNOW IF ANYTHING CAN BE DONE TO CORRECT THIS PROBLEM AS SOON AS POSSIBLE!! THANK YOU!! *NM
NHTSA ODI #10170824
30,000 miles · Mar 22, 2006
Structure
WATER LEAKING INTO PASSENGER COMPARTMENT THROUGH ROOF THROUGH TRIP COMPUTER. LEFT REAR DRAIN HOSE PINCHED CLOSED DURING ASSEMBLY. YEARS OF DIRT ACCUMULATION CLOGGED THE RESTRICTED HOSE CAUSING WATER OVERFLOW TO ENTER VEHICLE CABIN DURING HEAVY RAIN STORMS. *JB
NHTSA ODI #10153398
Mileage unknown · Oct 3, 2002
StructureVisibility
CONSUMER STATED THAT THE WINDSHIELD HAS A DENSE GLARE WHICH CAUSES EYE STRAIN AND FATIGUE HAZARD WHILE DRIVING. *YH
NHTSA ODI #8020167
Mileage unknown · Jun 3, 2002
Structure
THERE IS A KNOCKING NOISE COMING FROM THE ROOF TOP OF THE VEHICLE WHEN THE VEHICLE HAS SET IN PARKING WHEN THE TEMPERATURES ARE HIGH AND/OR HOT. DEALERSHIP IS AWARE OF PROBLEM. *AK *SCC
NHTSA ODI #8010953
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration