IllustrationCAR WOULD NOT START CHANGED PASSLOCK AND STILL WILL NOT START. SECURITY LIGHT IS ON, RADIO IS LOCKED AND THE CHEVY DEALERSHIP DOES NOT KNOW WHAT IS WRONG WITH IT, THEY ARE GUESSING THAT IS THE BCM AND THE SDM BUT THEY CANNOT PROMISE THAT IT WILL WORK. *TR
2002 Chevrolet Impala
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Impala years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
590–25K
9725–50K
10950–75K
10775–100K
130100–150K
69150K+
571 reports with mileage · 224 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 305 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 123 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports32 fire reports27 injury reports
What owners actually said
795 reportsMULTI-FUNCTION SWITCH FAILED ON 2002 CHEVROLET IMPALA CAUSING A LOSS OF HIGH BEAM LIGHTS. THE SWITCH AND THE HIGH BEAM BULBS HAD TO BE REPLACED FOR SAFETY REASONS. *TR
2002 CHEVROLET IMPALA LS - SECURITY/PASSLOCK SYSTEM PROBLEM - SUMMER 2007 - TOOK IN TO CHEVROLET DEALER (SINCE OUT OF BUSINESS - PALM BAY CHEVROLET IN FLORIDA) BECAUSE SECURITY LIGHT WOULD COME ON AT TIMES, EVENTUALLY DISABLING CAR FOR SHORT PERIODS OF TIME. FIRST REPAIR, BCM REPLACED - SAME ISSUE TWO MONTHS LATER - IGNITION CY…
Read full complaint
2002 CHEVROLET IMPALA LS - SECURITY/PASSLOCK SYSTEM PROBLEM - SUMMER 2007 - TOOK IN TO CHEVROLET DEALER (SINCE OUT OF BUSINESS - PALM BAY CHEVROLET IN FLORIDA) BECAUSE SECURITY LIGHT WOULD COME ON AT TIMES, EVENTUALLY DISABLING CAR FOR SHORT PERIODS OF TIME. FIRST REPAIR, BCM REPLACED - SAME ISSUE TWO MONTHS LATER - IGNITION CYLINDER REPLACED - TWO MONTHS LATER, SECURITY LIGHT WOULD COME ON AGAIN. DEALERSHIP OUT OF BUSINESS THAT DID TWO ORIGINAL REPAIRS FOR 1200.00 - TODAY, SECURITY LIGHT WAS FLASHING AND CAR WOULD NOT START. LOOKING ONLINE, THIS IS A VERY COMMON ISSUE WITH IMPALAS FROM 2000 - 2005 - WHY IS THERE NO RECALL? *TR
2002 IMPALA TURN SIGNALS WORK AT TIMES AND THEN DON'T WORK. I FOUND THAT PRESSING THE HAZARD SWITCH SEVERAL TIMES DID WORK BUT ONLY FOR A SHORT WHILE UNTIL IT HAPPENED AGAIN. *TR
INITIALLY STARTED WITH THE ENGINE NOT TURNING OVER. FULL BATTERY POWER, PUT CAR IN N TO START, NOTHING. PUT CAR IN EMERGENCY PARK TO START AND IT DID. THIS HAPPENED REPEATEDLY, WITH NO WARNING. NOW THE CAR STARTS EVERY TIME. THE PROBLEM NOW IS INTERIOR/EXTERIOR LIGHTS FLASH LIKE STROBE LIGHTS EVERY TIME I START MY CAR …
Read full complaint
INITIALLY STARTED WITH THE ENGINE NOT TURNING OVER. FULL BATTERY POWER, PUT CAR IN N TO START, NOTHING. PUT CAR IN EMERGENCY PARK TO START AND IT DID. THIS HAPPENED REPEATEDLY, WITH NO WARNING. NOW THE CAR STARTS EVERY TIME. THE PROBLEM NOW IS INTERIOR/EXTERIOR LIGHTS FLASH LIKE STROBE LIGHTS EVERY TIME I START MY CAR TILL THE TIME I TURN IT OFF, SO I CAN'T DRIVE AT NIGHT. THE "SECURITY" LIGHT PASS LOCK ISSUE INTERFERES WITH THE A/C COMPRESSOR AND WILL BLOW HOT AIR. A CONSTANT CLICKING FROM THE RELAYS IN THE PASSENGER SIDE FUSE BOX. WHY IS IT MANY GM DEALERSHIPS ACROSS THE COUNTRY CANNOT DIAGNOSE THIS WHEN CONSUMERS HAVE BROUGHT IN THE VEHICLE FOR ASSESSMENT. CHECK OUT THE WEBSITE OF CARCOMPLAINTS.COM FOR MORE OF THE SAME ISSUE. FELLOW IMPALA OWNERS; LETS FILE CLASS ACTION LAW SUIT AGAIN GM TO GET THIS RESOLVED. BUT SADLY IT WILL TAKE ONE DEATH OR MORE FOR ANY ACTION FROM GM. "THE AMERICAN WAY IS LETS DO SOMETHING AFTER THE FACT AND NOT BE PROACTIVE TO PREVENT". *TR
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA LS. WHILE WAITING IN A LINE, THE CONTACT TURNED OFF THE VEHICLE AND IT WOULD NOT RESTART. THE VEHICLE HAD TO BE TOWED TO A MECHANIC AND THEY FOUND NO FAILURES. THE CONTACT BELIEVES THAT THE FAILURE WAS DUE TO THE PASS LOCK. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WER…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA LS. WHILE WAITING IN A LINE, THE CONTACT TURNED OFF THE VEHICLE AND IT WOULD NOT RESTART. THE VEHICLE HAD TO BE TOWED TO A MECHANIC AND THEY FOUND NO FAILURES. THE CONTACT BELIEVES THAT THE FAILURE WAS DUE TO THE PASS LOCK. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 50,000.
AT RANDOM TIMES, THE CAR WILL NOT START WHEN THE IGNITION IS TURNED. THERE IS NO RESPONSE FROM MOTOR AT ALL. THE SECURITY LIGHT WILL FLASH ON THE INFORMATION CENTER DISPLAY WHEN THIS HAPPENS. AFTER WAITING 10-20 MINUTES THE CAR WILL START. THE FIRST INCIDENT OCCURRED ABOUT 1 YEAR AGO AND HAS BEEN OCCURRING AT RANDOM TIMES EV…
Read full complaint
AT RANDOM TIMES, THE CAR WILL NOT START WHEN THE IGNITION IS TURNED. THERE IS NO RESPONSE FROM MOTOR AT ALL. THE SECURITY LIGHT WILL FLASH ON THE INFORMATION CENTER DISPLAY WHEN THIS HAPPENS. AFTER WAITING 10-20 MINUTES THE CAR WILL START. THE FIRST INCIDENT OCCURRED ABOUT 1 YEAR AGO AND HAS BEEN OCCURRING AT RANDOM TIMES EVER SINCE. VEHICLE WAS TAKEN TO A GM DEALER SERVICE DEPARTMENT AFTER THE FIRST TIME IT OCCURRED AND THEY WERE UNABLE TO DIAGNOSE THE PROBLEM. SINCE THEN I HAVE NOTICED THAT THE FAN FOR THE HVAC SYSTEM WILL NOT WORK AT TIMES AND THE SECURITY LIGHT AND OTHER LIGHTS WILL APPEAR ON THE INFORMATION CENTER DISPLAY AT RANDOM TIMES. *TR
I OWN A 2002 CHEVY IMPALA. ON 5/20/05 THE SECURITY LIGHT STARTED COMING ON AND WOULD REMAIN ON. THE SECURITY LIGHT CONTINUED TO COME ON AND NOW THE CAR WOULD NOT START. IT WOULD TAKE 10-30MINUTES BEFORE I COULD START THE CAR. I TOOK THE CAR TO A DEALERSHIP AND THEY REPLACED THE IGNITION CYLINDER. ON 6/15/05 THE SAME EXACT PROBLE…
Read full complaint
I OWN A 2002 CHEVY IMPALA. ON 5/20/05 THE SECURITY LIGHT STARTED COMING ON AND WOULD REMAIN ON. THE SECURITY LIGHT CONTINUED TO COME ON AND NOW THE CAR WOULD NOT START. IT WOULD TAKE 10-30MINUTES BEFORE I COULD START THE CAR. I TOOK THE CAR TO A DEALERSHIP AND THEY REPLACED THE IGNITION CYLINDER. ON 6/15/05 THE SAME EXACT PROBLEM STARTED UP AGAIN. THIS TIME THE DEALERSHIP INSTALLED A NEW STARTER. ON 7/16/05 SAME PROBLEM AROSE AGAIN WITH SECURITY LIGHT. A DIAGNOSTIC WAS DONE AND CODES CAME UP FROM A NOTICE FROM GM (8/04). THE CODE #'S WERE B2958 AND B2960. THE CODE SAID TO REPAIR POOR TERMINAL CONNECTIONS AT BODY CONTROL MODULE. THE SECURITY LIGHT CONTINUES TO COME ON AND CAR DOES NOT START. THIS CONTINUES ON/OFF FROM 9/11/05-11/28/05. ON 11/28/05 THE IGNITION LOCK/SENSOR IS REPLACED AND THE PCM IS REPROGRAMMED. AND I AM GIVEN A NEW KEY. LOOKS LIKE AT THE MOMENT THE PROBLEM IS SOLVED. WELL TODAY 7/17/08 I NOTICE THAT THE SECURITY LIGHT IS BACK ON AND I BEGIN TO CRINGE BECAUSE OF WHAT I WENT THROUGH IN 05'. I GET ONLINE TO SEE IF ANYONE ELSE IS EXPERIENCING THE SAME PROBLEM AND I WAS SHOCKED TO SEE THE # OF COMPLAINTS FROM DISGRUNTLED CUSTOMERS ABOUT THIS SECURITY LIGHT. THIS IS AN OUTRAGE! GM BY NOW IS WELL AWARE OF THE PROBLEM WITH THIS SECURITY LIGHT GOING ON. IT WOULD SEEM TO ME THAT THERE WOULD HAVE BEEN A RECALL NOTICE GOING OUT TO CHEVY IMPALA OWNERS. I HAVE CONTACTED GM. MY COMPLAINT IS ON FILE. I HAVE 2 FILE #'S. ONE FOR IN 2005--# [XXX] AND A NEW ONE JUST STARTED TODAY (7/17/08)--#-[XXX]. PLEASE GOOGLE CHEVY IMPALA AND SECURITY LIGHT PROBLEM AND SEE THE LIST OF COMPLAINTS THAT COME UP. THIS IS AN ABSOLUTE DISGRACE! I FEEL THAT THIS IS SOMETHING THAT NEEDS TO BE LOOKED INTO ASAP. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
2002 CHEVROLET IMPALA WITH BAD INTAKE MANIFOLD GASKET AND BRAKES. CONSUMER WAS INFORMED THAT THE INTAKE MANIFOLD GASKET LEAK IS A COMMON PROBLEM IN THESE VEHICLES. BRAKES HAVE BEEN REPLACED THREE TIMES. HE STATES THAT THIS IS ALSO A COMMON PROBLEM. *KB THE CONSUMER STATED THE ROTORS WERE WARPED. THE ENGINE AND RADIATOR WERE RE…
Read full complaint
2002 CHEVROLET IMPALA WITH BAD INTAKE MANIFOLD GASKET AND BRAKES. CONSUMER WAS INFORMED THAT THE INTAKE MANIFOLD GASKET LEAK IS A COMMON PROBLEM IN THESE VEHICLES. BRAKES HAVE BEEN REPLACED THREE TIMES. HE STATES THAT THIS IS ALSO A COMMON PROBLEM. *KB THE CONSUMER STATED THE ROTORS WERE WARPED. THE ENGINE AND RADIATOR WERE REPLACED DUE TO A LEAK. *JB
ABS LIGHT COMES ON FREQUENTLY AND WHEN BRAKES ARE APPLIED, IT FEELS EXTREMELY UNSAFE. BRAKES EITHER DO NOT RESPOND OR SKID WHEN ATTEMPTING TO STOP. AFRAID TO DRIVE VEHICLE. HAD MECHANICS CHECK VEHICLE AND ISSUE CANNOT BE IDENTIFIED FROM FAILURE CODES. APPEARS WIRING MAY BE DAMAGED AND WILL COST QUITE A BIT TO REPAIR. MECHAN…
Read full complaint
ABS LIGHT COMES ON FREQUENTLY AND WHEN BRAKES ARE APPLIED, IT FEELS EXTREMELY UNSAFE. BRAKES EITHER DO NOT RESPOND OR SKID WHEN ATTEMPTING TO STOP. AFRAID TO DRIVE VEHICLE. HAD MECHANICS CHECK VEHICLE AND ISSUE CANNOT BE IDENTIFIED FROM FAILURE CODES. APPEARS WIRING MAY BE DAMAGED AND WILL COST QUITE A BIT TO REPAIR. MECHANICS UNSURE THIS WILL SOLVE IT. DON'T WANT TO SELL VEHICLE AS IT WILL MAKE IT SOMEONE ELSE'S PROBLEM.
Official recalls
415V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
02V222000 · Air Bags:frontal
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.