NHTSA owner reports · September 18, 2026 snapshot.
Traction Control System complaints
14 reportsClear category filter189,000 miles · Dec 19, 2016
Service BrakesTraction Control SystemCrash
I HAVE BEEN HAVING PROBLEMS WITH THE TRACTION CONTROL SYSTEM ON MY 2002 CHEVY IMPALA FOR THE LAST FIVE YEARS. ON DECEMBER 16TH I WAS INVOLVED IN A COLLISION WITH ANOTHER VEHICLE WHEN I COULD NOT STOP ST A RED LIGHT. TRACTION LIGHT KEPT COMING ON AND OFF ALL DAY. ABS PUMP WOULD RUN FOR NO REASON. AS I APPROACHED THE TRAFFIC LIGHT…
Read full complaint
I HAVE BEEN HAVING PROBLEMS WITH THE TRACTION CONTROL SYSTEM ON MY 2002 CHEVY IMPALA FOR THE LAST FIVE YEARS. ON DECEMBER 16TH I WAS INVOLVED IN A COLLISION WITH ANOTHER VEHICLE WHEN I COULD NOT STOP ST A RED LIGHT. TRACTION LIGHT KEPT COMING ON AND OFF ALL DAY. ABS PUMP WOULD RUN FOR NO REASON. AS I APPROACHED THE TRAFFIC LIGHT THE REACTION LIGHT CAME ON AGAIN AND MY BRAKES FAILED. CAUSING ME TO HO THROUGH THE RED LIGHT AND HIT CAR PASSING THROUGH INTERSECTION. *TR
NHTSA ODI #10936363
109,000 miles · Jul 28, 2013
Electronic Stability Control (esc)Traction Control System
THE SERVICE TRACTION SYSTEM AND ABS LIGHT CAME ON INDICATING THE CAR HAD LOST THE ABS FUNCTION. ACCORDING TO THE DEALER THE HYDRAULIC BRAKE FUNCTION WAS SUPPOSED TO STILL WORK. HOWEVER, IF WHAT I EXPERIENCED RECENTLY USING THE HYDRAULIC FUNCTION IS SUPPOSED TO CONSOLE ME OR OFFER BRAKING SECURITY IT HASN'T LEADING ME TO HAVE M…
Read full complaint
THE SERVICE TRACTION SYSTEM AND ABS LIGHT CAME ON INDICATING THE CAR HAD LOST THE ABS FUNCTION. ACCORDING TO THE DEALER THE HYDRAULIC BRAKE FUNCTION WAS SUPPOSED TO STILL WORK. HOWEVER, IF WHAT I EXPERIENCED RECENTLY USING THE HYDRAULIC FUNCTION IS SUPPOSED TO CONSOLE ME OR OFFER BRAKING SECURITY IT HASN'T LEADING ME TO HAVE MY BRAKES WORKED ON AT MIDAS. WHAT LED ME TO MIDAS WAS THE UNNERVING FEELING OF MY RIGHT FRONT BRAKE SHUDDERING AND GRABBING. THEY SAID THE FRONT BRAKES AND PADS WERE FINE BUT THEY DID DO THE REARS. I CALLED GM AND WAS TOLD THERE WAS NO RECALL ON THIS. I THEN WENT TO THE DEALER AND THEY STATED THEY HAD NO SERVICE BULLETIN ON THIS. SINCE THIS IS PART OF THE BRAKING SYSTEM I AM ASTONISHED THAT THIS PROBLEM HAS NOT BEEN RECALLED. I AM NOT THE ONLY CUSTOMER WITH THIS PROBLEM ACCORDING TO MY OWN INTERNET INVESTIGATING. ACCORDING TO CHEVY THIS PROBLEM COULD COST THOUSANDS. THE PROBLEM DOES NOT APPEAR MECHANICAL BUT ELECTRICAL INVOLVING THE ABS SENSORS AND/OR ECB MODULE. *TR
NHTSA ODI #10532242
85,000 miles · Dec 30, 2011
Service Brakes, HydraulicTraction Control System
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE TRACTION CONTROL AND THE ABS LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE ABS HUB ASSEMBLY WAS REPLACED, BUT THE FAILURE WAS NOT CORRECTED. THE TRACTION CONTROL AND THE ABS WARNING LIGHTS CONTINUED TO ILLUMINATE I…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE TRACTION CONTROL AND THE ABS LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE ABS HUB ASSEMBLY WAS REPLACED, BUT THE FAILURE WAS NOT CORRECTED. THE TRACTION CONTROL AND THE ABS WARNING LIGHTS CONTINUED TO ILLUMINATE INTERMITTENTLY. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 85,000 AND THE CURRENT MILEAGE WAS 90,000.
NHTSA ODI #10441778
70,000 miles · Aug 26, 2011
Traction Control System
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE TRACTION CONTROL SYSTEM FAILED WITH THE ILLUMINATED OF THE TRACTION CONTROL WARNING LIGHT. THE FAILURE CAUSED AN ABNORMAL INCREASE IN STOPPING DISTANCE. THE DEALER INSPECTED THE VEHICLE AND ADVISED THAT THE TRACTION CONTROL NEEDED TO BE REPAIRED. THE VEHIC…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE TRACTION CONTROL SYSTEM FAILED WITH THE ILLUMINATED OF THE TRACTION CONTROL WARNING LIGHT. THE FAILURE CAUSED AN ABNORMAL INCREASE IN STOPPING DISTANCE. THE DEALER INSPECTED THE VEHICLE AND ADVISED THAT THE TRACTION CONTROL NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 80,000.
NHTSA ODI #10421557
115,000 miles · Jul 28, 2011
Traction Control System
FOR THE PAST 2 WEEKS MY TRACTION ON LIGHT APPEARS AND WHEN TURNING RIGHT, THE RIGHT FRONT END HESITATES AND BOGS DOWN AND MAKES A WHIRRING NOISE. I THOUGHT IT MIGHT BE MY BRAKES. ONCE LAST WEEK AFTER THIS HAPPENED THE ABS LIGHT APPEARED. I IMMEDIATELY STOPPED AND TURNED THE CAR OFF. WHEN RESTARTING THE LIGHTS DISAPPEARED. T…
Read full complaint
FOR THE PAST 2 WEEKS MY TRACTION ON LIGHT APPEARS AND WHEN TURNING RIGHT, THE RIGHT FRONT END HESITATES AND BOGS DOWN AND MAKES A WHIRRING NOISE. I THOUGHT IT MIGHT BE MY BRAKES. ONCE LAST WEEK AFTER THIS HAPPENED THE ABS LIGHT APPEARED. I IMMEDIATELY STOPPED AND TURNED THE CAR OFF. WHEN RESTARTING THE LIGHTS DISAPPEARED. THE ABS LIGHT HAS NOT SINCE APPEARED BUT THE TRACTION ON LIGHT AND EFFECTS CONTINUE. *TR
NHTSA ODI #10415492
70,150 miles · Oct 23, 2010
Traction Control System
WHEN WHEELS ARE TURNED TO THE RIGHT EITHER SLIGHTLY OR ALL THE WAY THE TRACTION CONTROL KICKS IN, LOSS OF POWER AND LOSS OF BRAKES WHEN ABS ALSO KICKS IN. BOUGHT THE 2002 CHEVY IMPALA LS JUST A WEEK AGO. THIS ISSUE STARTED AS VERY INTERMITTENT BUT I CAN RE-CREATE THE ISSUES NOW JUST ABOUT EVERY TIME I DRIVE THE CAR BY TURNING RI…
Read full complaint
WHEN WHEELS ARE TURNED TO THE RIGHT EITHER SLIGHTLY OR ALL THE WAY THE TRACTION CONTROL KICKS IN, LOSS OF POWER AND LOSS OF BRAKES WHEN ABS ALSO KICKS IN. BOUGHT THE 2002 CHEVY IMPALA LS JUST A WEEK AGO. THIS ISSUE STARTED AS VERY INTERMITTENT BUT I CAN RE-CREATE THE ISSUES NOW JUST ABOUT EVERY TIME I DRIVE THE CAR BY TURNING RIGHT FROM A STOP. AT THIS POINT NOTHING HAS BEEN DONE TO FIX THE ISSUE BECAUSE NO ONE KNOWS WHY IT IS HAPPENING. *TR
NHTSA ODI #10362071
122,000 miles · Sep 29, 2010
Service Brakes, HydraulicTraction Control System
HAVE HAD "TRACTION CONTROL" PROBLEMS FOR 2 YEARS. WAS TOLD MANY THINGS COULD CAUSE THIS. NOW DRIVING WITH NO TRACTION CONTROL AND NO ABS, JUST REGULAR BRAKES. HAVE REPLACED HUBS AND BRAKES. HAVE TO FILE FOR WAIVER FOR INSPECTION. WILL TRY REPLACING ABS PUMP NEXT IF CAN EVER AFFORD SUCH A BIG REPAIR. DANGEROUS ISSUE. *TR
NHTSA ODI #10358338
150,000 miles · Aug 21, 2010
Traction Control System
MY 2002 CHEVY IMPALA 3.8L V-6 HAS A PROBLEM WITH THE TRACTION CONTROL ENGAGING WHEN BRAKING IN TURNS TO THE LEFT. THIS CAUSES THE BRAKES TO SLIP AND GRIND. A HUMMING SOUND CAN BE HEARD WHEN THIS OCCURS. THE TRACTION CONTROL AND SOMETIMES THE "CHECK ABS " LIGHT BECOMES ILLUMINATED AT THE SAME TIME. THE CAR HAS BEEN TAKEN TO A LOC…
Read full complaint
MY 2002 CHEVY IMPALA 3.8L V-6 HAS A PROBLEM WITH THE TRACTION CONTROL ENGAGING WHEN BRAKING IN TURNS TO THE LEFT. THIS CAUSES THE BRAKES TO SLIP AND GRIND. A HUMMING SOUND CAN BE HEARD WHEN THIS OCCURS. THE TRACTION CONTROL AND SOMETIMES THE "CHECK ABS " LIGHT BECOMES ILLUMINATED AT THE SAME TIME. THE CAR HAS BEEN TAKEN TO A LOCAL CHEVY DEALER FOR REPAIR. BOTH RIGHT AND LEFT FRONT WHEEL HUB ASSEMBLIES WERE REPLACED. I REQUESTED A CHECK OF WIRING HARNESSES TO SEE IF THERE WAS DETERIORATION. NONE WAS APPARENTLY FOUND BY THE SHOP. IM AFRAID TO DRIVE THIS CAR OR ALLOW OTHERS IN MY SON TO DRIVE IT INCASE THE BRAKES CANT ENGAGE PROPERLY. FROM READING ONLINE ACCOUNTS OF OTHER DRIVERS, I AM NOT THE ONLY ONE WITH THIS PROBLEM WITH A CHEVROLET OF THIS MODEL. AFTER HAVING THE RIGHT FRONT HUB ASSEMBLY REPLACED, I THOUGHT IT WAS FIXED. THEN AFTER HAVING THE LEFT FRONT REPLACED AS WELL TO THE TUNE OF AROUND $350.00 A PIECE, I THOUGH THE PROBLEM WAS FIXED. NOT SO. WHERE DOES THIS END. I URGE YOU TO LOOK INTO A RECALL OF THIS MODEL AND HAVE GM ULTIMATELY FIX THIS PROBLEM AND AVOID ALLOWING FOR A POSSIBLE ACCIDENT WITH INJURIES OR DEATH. THIS IS SOMETHING THAT GM KNOWS THERE IS A PROBLEM AND AGAIN SHOULD BE RECALLED. *TR
NHTSA ODI #10351051
110,000 miles · Jul 31, 2010
Traction Control System
MY 2002 CHEVY IMPALA 3.8L V-6 HAS A PROBLEM WITH THE TRACTION CONTROL ENGAGING WHEN BRAKING IN TURNS TO THE LEFT. THIS CAUSES THE BRAKES TO SLIP AND GRIND. A HUMMING SOUND CAN BE HEARD WHEN THIS OCCURS. THE TRACTION CONTROL AND SOMETIMES THE "CHECK ABS " LIGHT BECOMES ILLUMINATED AT THE SAME TIME. THE CAR HAS BEEN TAKEN TO A…
Read full complaint
MY 2002 CHEVY IMPALA 3.8L V-6 HAS A PROBLEM WITH THE TRACTION CONTROL ENGAGING WHEN BRAKING IN TURNS TO THE LEFT. THIS CAUSES THE BRAKES TO SLIP AND GRIND. A HUMMING SOUND CAN BE HEARD WHEN THIS OCCURS. THE TRACTION CONTROL AND SOMETIMES THE "CHECK ABS " LIGHT BECOMES ILLUMINATED AT THE SAME TIME. THE CAR HAS BEEN TAKEN TO A LOCAL CHEVY DEALER FOR REPAIR. BOTH RIGHT AND LEFT FRONT WHEEL HUB ASSEMBLIES WERE REPLACED. I REQUESTED A CHECK OF WIRING HARNESSES TO SEE IF THERE WAS DETERIORATION. NONE WAS APPARENTLY FOUND BY THE SHOP. I'M AFRAID TO DRIVE THIS CAR OR ALLOW OTHERS IN MY FAMILY TO DRIVE IT INCASE THE BRAKES CAN'T ENGAGE PROPERLY. FROM READING ONLINE ACCOUNTS OF OTHER DRIVERS, I AM NOT THE ONLY ONE WITH THIS PROBLEM WITH A CHEVROLET OF THIS MODEL. AFTER HAVING THE RIGHT FRONT HUB ASSEMBLY REPLACED, I THOUGHT IT WAS FIXED. THEN AFTER HAVING THE LEFT FRONT REPLACED AS WELL TO THE TUNE OF AROUND $500.00 A PIECE, I THOUGH THE PROBLEM WAS FIXED. NOT SO. WHERE DOES THIS END. I URGE YOU TO LOOK INTO A RECALL OF THIS MODEL AND HAVE GM ULTIMATELY FIX THIS PROBLEM AND AVOID ALLOWING FOR A POSSIBLE ACCIDENT WITH INJURIES OR DEATH. *TR
NHTSA ODI #10346503
Mileage unknown · Jul 21, 2010
Service Brakes, HydraulicTraction Control System
SINCE WE BOUGHT THIS CHEVY IMPALA AT GENE PANKEY MOTOR IN TACOMA WASHINGTON WE HAVE HAD NOTHING BUT ISSUES WITH THE TRACTION CONTROL SYSTEM LIGHTS COMING ON WHEN WE WOULD RETURN TO THE DEALER TO HAVE IT WORKED ON THEY WOULD CLEAR THE COMPUTER WHICH WOULD CLEARS THE PROBLEM FOR A FEW DAYS BUT IT ALWAYS COMES BACK. WE HAVE HAD OUR…
Read full complaint
SINCE WE BOUGHT THIS CHEVY IMPALA AT GENE PANKEY MOTOR IN TACOMA WASHINGTON WE HAVE HAD NOTHING BUT ISSUES WITH THE TRACTION CONTROL SYSTEM LIGHTS COMING ON WHEN WE WOULD RETURN TO THE DEALER TO HAVE IT WORKED ON THEY WOULD CLEAR THE COMPUTER WHICH WOULD CLEARS THE PROBLEM FOR A FEW DAYS BUT IT ALWAYS COMES BACK. WE HAVE HAD OUR IMPALA IN ALOT OF TIMES AT LEAST 15X WE NEVER THOUGHT TO KEEP TRACK HOW MANY TIMES WE HAVE HAD TO HAVE THIS WORKED ON ITS BEEN TO 4 DIFFERENT SHOPS FOR THE SAME THING. WE LOVE THIS CAR IT IS A GREAT CAR LOTS OF ROOM AND HAS GIDDY UP AND WELL ITS HOT AND ITS PAID FOR. WE REALLY WANT OUR CAR FIXED WE ARE TIRED OF TAKING IT IN TO BE FIXED AND NOTHING GETS DONE. THEY HAVE REPLACED THE CATALYTIC CONVERTER AT THE CHEVY DEALER SAYING THAT WAS BAD AND REPLACED THE FRONT RIGHT WHEEL SENSOR TWICE AT AMCO TRANSMISSION SHOP IN FIRCREST ITS BEEN TO BITTERLINGS IN TACOMA AS WELL AS THE DEALER WE BOUGHT IT FROM GENE PANKEY. AND WE STILL HAVE THE SAME ISSUES. THE TRACTION CONTROL LIGHT KEEPS COMING ON AND THE ABS LIGHT NOW COMES ON, IT HAPPENS INTERMITTENTLY. I FEEL IT HAS SOMETHING TO DO WITH THE BRAKES OR THE TRANSMISSION! THE BRAKES GO SPONGY WHEN THE TRACTION CONTROL LIGHT COMES ON WE LOSE OUR BRAKES!!!! I AM STILL UNDER WARRANTY TIL 100,000 MILES AND IM ONLY AT 80,000 BUT I JUST DON'T HAVE TIME TO KEEP TAKING THIS THING TO THE DEALER. I WANT MY RIDE FIXED AND I WANT IT FIXED NOW. CANT WE START A CLASS ACTION LAWSUIT!!!!!
NHTSA ODI #10344325
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration