NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
11 reportsClear category filter58,000 miles · Jul 19, 2018
Electrical SystemElectronic Stability Control (esc)Service Brakes
ABS IS KICKING BACK AND TRACTION CONTROL IS COMING ON FOR NO GIVEN REASON MAKING STOPPING THE CAR INCREASINGLY HARD AT SLOW SPEEDS. INEVITABLY CAUSING THE ABS AND SERVICE TRACTION CONTROL LIGHTS TO COME ON THE LIGHT IS NOW STAYING ON AS SOON AS THE CAR IS TURNED ON. TOOK THE CAR TO THE SHOP TO ATTEMPT TO FIND THE PROBLEM BEING T…
Read full complaint
ABS IS KICKING BACK AND TRACTION CONTROL IS COMING ON FOR NO GIVEN REASON MAKING STOPPING THE CAR INCREASINGLY HARD AT SLOW SPEEDS. INEVITABLY CAUSING THE ABS AND SERVICE TRACTION CONTROL LIGHTS TO COME ON THE LIGHT IS NOW STAYING ON AS SOON AS THE CAR IS TURNED ON. TOOK THE CAR TO THE SHOP TO ATTEMPT TO FIND THE PROBLEM BEING TOLD IT IS AN ELECTRICAL GROUNDING PROBLEM ALSO MAKES THE HEADLIGHTS FLICKER WHEN DOING THIS
NHTSA ODI #11112401
189,000 miles · Dec 19, 2016
Service BrakesTraction Control SystemCrash
I HAVE BEEN HAVING PROBLEMS WITH THE TRACTION CONTROL SYSTEM ON MY 2002 CHEVY IMPALA FOR THE LAST FIVE YEARS. ON DECEMBER 16TH I WAS INVOLVED IN A COLLISION WITH ANOTHER VEHICLE WHEN I COULD NOT STOP ST A RED LIGHT. TRACTION LIGHT KEPT COMING ON AND OFF ALL DAY. ABS PUMP WOULD RUN FOR NO REASON. AS I APPROACHED THE TRAFFIC LIGHT…
Read full complaint
I HAVE BEEN HAVING PROBLEMS WITH THE TRACTION CONTROL SYSTEM ON MY 2002 CHEVY IMPALA FOR THE LAST FIVE YEARS. ON DECEMBER 16TH I WAS INVOLVED IN A COLLISION WITH ANOTHER VEHICLE WHEN I COULD NOT STOP ST A RED LIGHT. TRACTION LIGHT KEPT COMING ON AND OFF ALL DAY. ABS PUMP WOULD RUN FOR NO REASON. AS I APPROACHED THE TRAFFIC LIGHT THE REACTION LIGHT CAME ON AGAIN AND MY BRAKES FAILED. CAUSING ME TO HO THROUGH THE RED LIGHT AND HIT CAR PASSING THROUGH INTERSECTION. *TR
NHTSA ODI #10936363
140,000 miles · Apr 19, 2016
Electrical SystemService Brakes
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE DRIVING 60 MPH, THE VEHICLE STALLED WITHOUT WARNING, THE BRAKE PEDAL SEIZED, AND THE CONTACT COASTED THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND LATER TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS THEN…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE DRIVING 60 MPH, THE VEHICLE STALLED WITHOUT WARNING, THE BRAKE PEDAL SEIZED, AND THE CONTACT COASTED THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND LATER TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SECURITY SYSTEM SHUTDOWN AND NEEDED TO BE REPROGRAMMED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) AND STATED THAT THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10860294
50,000 miles · Mar 23, 2016
Service BrakesWheels
WE BOUGHT THIS 2002 CHEVROLET IMPALA IN APRIL OF 2002. FORTUNATELY, WE PURCHASED THE EXTENDED WARRANTY. WE HAVE HAD CONTINUOUS PROBLEMS WITH THE TRACTION CONTROL SYSTEM. INITIALLY, THE WARRANTY COVERED THE MALFUNCTIONS: WHEEL SENSORS, MODULES, BRAKE PUMP, WIRING, ETC. WERE REPLACED. SHORTLY AFTER EACH REPAIR, THE SYSTEM FAI…
Read full complaint
WE BOUGHT THIS 2002 CHEVROLET IMPALA IN APRIL OF 2002. FORTUNATELY, WE PURCHASED THE EXTENDED WARRANTY. WE HAVE HAD CONTINUOUS PROBLEMS WITH THE TRACTION CONTROL SYSTEM. INITIALLY, THE WARRANTY COVERED THE MALFUNCTIONS: WHEEL SENSORS, MODULES, BRAKE PUMP, WIRING, ETC. WERE REPLACED. SHORTLY AFTER EACH REPAIR, THE SYSTEM FAILED AGAIN. WHEN THE WARRANTY EXPIRED WE CONTINUED TO EXPERIENCE SYSTEM MALFUNCTIONS, REPLACING PART AFTER PART. TO DATE, OVER $3.5K HAS BEEN SPENT TO ATTEMPT TO FIX THIS POORLY DESIGNED AND INSTALLED SYSTEM. IT HAS BEEN OUT OF SERVICE FOR MORE YEARS, THAN IT HAS FUNCTIONED. IT HAS BEEN OUT FOR THE LAST 3 YEARS, BECAUSE WE CAN NOT PUT GOOD MONEY AFTER BAD. I RECENTLY CONTACTED GM CORPORATE WITH MY COMPLAINT AND THEY TOLD ME TO TAKE IT IN FOR SYSTEM DIAGNOSIS. SAME RESULT: BRAKE PUMP AND MODULE OUT, WITH POSSIBLE WIRING PROBLEMS AND WHEEL SENSORS. ESTIMATE TO TRY TO FIX: $2.5K. NO GUARANTEE IT WILL WORK. THIS MALFUNCTION OCCURS WITH NO WARNING: SOMETIMES UPON STARTING THE VEHICLE, WHILE DRIVING OR TURNING. I INVESTIGATED THIS PROBLEM ONLINE AND FOUND MANY OTHERS HAVE EXPERIENCED SIMILAR PROBLEMS, NOT BEING ABLE TO GET THEM FIXED PROPERLY. IT OCCURS IN IMPALAS AND MONTE CARLOS OF SIMILAR YEARS, 2002-2008. HOW CAN GM JUSTIFY SPENDING $6K TO MAINTAIN A SINGLE SYSTEM WHICH WORKS DIRECTLY WITH THE ABS BRAKE SYSTEM? MY CONTACT AT GM IS [XXX] 855.880.1500 EXT. [XXX]. CHEVROLET NEEDS TO DO A RECALL ON THIS FAULTY, POORLY ENGINEERED SYSTEM. PLEASE INVESTIGATE. THANK YOU. (I HAVE ATTACHED JUST A FEW OF THE MANY INVOICES I HAVE COLLECTED OVER THE YEARS FOR YOUR INSPECTION.) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10851238
Mileage unknown · Mar 16, 2016
Service Brakes
BOUGHT VEHICLE IN APRIL, 2002. WE HAVE HAD REPEATED MALFUNCTIONS OF THE TRACTION CONTROL SYSTEM. I HAVE UPLOADED A FEW OF THE REPAIR DOCUMENTS WE HAD COLLECTED OVER THE YEARS. I HAVE SEVERAL MORE. DESPITE NUMEROUS REPAIRS, FROM WHEEL SENSORS, TO WIRING (INCLUDING COMPLETE HARNESS), COMPUTER CHIPS, RESETS, ETC. EVERY ATTEMPT…
Read full complaint
BOUGHT VEHICLE IN APRIL, 2002. WE HAVE HAD REPEATED MALFUNCTIONS OF THE TRACTION CONTROL SYSTEM. I HAVE UPLOADED A FEW OF THE REPAIR DOCUMENTS WE HAD COLLECTED OVER THE YEARS. I HAVE SEVERAL MORE. DESPITE NUMEROUS REPAIRS, FROM WHEEL SENSORS, TO WIRING (INCLUDING COMPLETE HARNESS), COMPUTER CHIPS, RESETS, ETC. EVERY ATTEMPT BY CHEVY TO FIX THIS POORLY DESIGNED SYSTEM HAVE FAILED. CHEVY HAS ADMITTED THEY DON'T KNOW WHAT TO DO. THEIR BEST SUGGESTION IS TO TRY YET ANOTHER DEALERSHIP. I AM TIRED OF WASTING MY MONEY ON A POORLY DESIGNED AND INSTALLED SAFETY FEATURE. THE SYSTEM HAS FAILED ON START UP, DRIVING AT HIGHWAY SPEEDS, LOW SPEEDS, WHILE BRAKING, ETC. I HAVE CONTACTED GM CORPORATE TWICE. ONCE THEY REPLACED THE WIRING HARNESS ONLY TO HAVE IT FAIL SHORTLY AFTER. MY SECOND CONTACT IS IN PROGRESS. MY ONLINE SEARCHES OF THIS YEAR AND MODEL HAVE REVEALED MANY SUCH COMPLAINTS ON THIS MODEL AND SIMILAR MODELS. THE STORY IS THE SAME: GM CAN'T FIX THE PROBLEM. WE LIVE IN SNOW COUNTRY, AND TRACTION CONTROL IS IMPORTANT TO US. CURRENTLY THE SYSTEM HAS BEEN OUT OF SERVICE FOR OVER TWO YEARS. IF YOU INVESTIGATE THIS ISSUE ON THIS YEAR AND MODEL, YOU WILL FIND THIS IS A COMMON PROBLEM THAT GM HAS NOT RECALLED. PLEASE INVESTIGATE. THANK YOU. *TR
NHTSA ODI #10850044
159,000 miles · Mar 15, 2016
Electrical SystemService BrakesUnknown Or Other
CAR WAS PARKED I STARTED IT AND BEGAN DRIVING MY ABS JUST WENT CRAZY. THE PUMP WAS TRYING TO ENGAGE OVER AND OVER AGAIN EVEN WHILE DRIVING. WHEN I HIT THE ABS OFF BUTTON THIS PROBLEM CONTINUED. I FEEL THIS CAR COULD AT ANYTIME HAVE SOMETHING IN THE BREAK OR TIRE AREA JUST COMPELETLY FAIL. ALONG WITH ANOTHER LIST OF ISSUES INCLUD…
Read full complaint
CAR WAS PARKED I STARTED IT AND BEGAN DRIVING MY ABS JUST WENT CRAZY. THE PUMP WAS TRYING TO ENGAGE OVER AND OVER AGAIN EVEN WHILE DRIVING. WHEN I HIT THE ABS OFF BUTTON THIS PROBLEM CONTINUED. I FEEL THIS CAR COULD AT ANYTIME HAVE SOMETHING IN THE BREAK OR TIRE AREA JUST COMPELETLY FAIL. ALONG WITH ANOTHER LIST OF ISSUES INCLUDING BURNING OIL FROM THE GASKET. PLEASE TELL ME IF THERE IS ANYTHING THAT CAN BE DONE.
NHTSA ODI #10849700
150,650 miles · Jun 29, 2015
Service BrakesVehicle Speed Control
I WAS STOPPED AT A STOP SIGN ON A DRY ROAD,WHEN I PRESSED THE ACCELERATOR THE CAR FELT LIKE THE ENGINE WAS GOING TO SHUT OFF AND IT WOULD BARELY MOVE. A FEW SECONDS LATER THE TRACTION CONTROL LIGHT AND ABS LIGHTS CAME ON. AFTER THE TRACTION CONTROL AND ABS LIGHTS CAME ON THE CAR WENT FINE.THIS IS NOT THE FIRST TIME THAT THIS HAS…
Read full complaint
I WAS STOPPED AT A STOP SIGN ON A DRY ROAD,WHEN I PRESSED THE ACCELERATOR THE CAR FELT LIKE THE ENGINE WAS GOING TO SHUT OFF AND IT WOULD BARELY MOVE. A FEW SECONDS LATER THE TRACTION CONTROL LIGHT AND ABS LIGHTS CAME ON. AFTER THE TRACTION CONTROL AND ABS LIGHTS CAME ON THE CAR WENT FINE.THIS IS NOT THE FIRST TIME THAT THIS HAS HAPPENED. ALSO SOMETIMES WHEN YOU STEP ON THE BRAKE PEDAL IT FEELS LIKE THERE IS NO PRESSURE ON THE PEDAL. WHEN THIS HAPPENS THE TRACTION CONTROL AND ABS LIGHTS COME ON AGAIN. THIS HAS HAPPENED SEVERAL TIMES IN THE PAST 2 YEARS AND I HAVE TAKEN MY CAR TO SEVERAL DIFFERENT AUTO MECHANICS. I HAVE REPLACED BOTH FRONT WHEEL HUB ASSEMBLIES AT LEAST 4 TIMES IN 2 YEARS. EACH AUTO MECHANIC WILL TELL YOU A DIFFERENT DIAGNOSIS WHEN I TAKE IT TO THE SHOP. I HAVE CONTACTED GM ABOUT THIS PROBLEM ABOUT 10 TO 12 MONTHS AGO AND THEY SAY THEY ARE NOT AWARE OF ANY PROBLEMS WITH THIS MODEL OF CAR. I DON'T KNOW WHAT ELSE TO DO TO RESOLVE THESE PROBLEMS WITH MY CAR. IT IS STARTING TO HAPPEN MORE OFTEN NOW, AND MY WIFE WILL NOT EVEN RIDE IN MY CAR ANYMORE BECAUSE SHE IS SCARED TO. I WOULD REALLY LIKE TO SEE AN INVESTIGATION STARTED INTO THIS MATTER. IF YOU GO TO SOME CHAT ROOMS ON THE WEB YOU WILL FIND MANY MANY PEOPLE HAVING THE SAME PROBLEMS WITH THEIR IMPALAS. THANK YOU FOR READING THIS COMPLAINT. *TR
NHTSA ODI #10731070
34,600 miles · Jan 30, 2015
Electrical SystemEngineService Brakes
THE CAR IGNITION SUDDENLY SHUT OFF AND THE POWER STEERING AND BRAKES FAILED ON A STEEP GRADE. (THE IGNITION RECALL HAD PREVIOUSLY BEEN PERFORMED ON THE VEHICLE, AND THE KEY FOB HAD BEEN REWORKED SO IT SHOULDN'T HAVE BEEN A IGNITION ISSUE). THE TRANSMISSION WAS SHIFTED INTO NEUTRAL AND THE CAR RESTARTED (WHILE STILL COASTING DOWN…
Read full complaint
THE CAR IGNITION SUDDENLY SHUT OFF AND THE POWER STEERING AND BRAKES FAILED ON A STEEP GRADE. (THE IGNITION RECALL HAD PREVIOUSLY BEEN PERFORMED ON THE VEHICLE, AND THE KEY FOB HAD BEEN REWORKED SO IT SHOULDN'T HAVE BEEN A IGNITION ISSUE). THE TRANSMISSION WAS SHIFTED INTO NEUTRAL AND THE CAR RESTARTED (WHILE STILL COASTING DOWN THE HILL) TO REGAIN CONTROL,THIS WAS REPEATED NUMEROUS TIMES UNTIL A SAFE PLACE TO PULL OFF WAS REACHED. THIS GRADE WAS EXTREMELY STEEP, THE ROAD HAD SWITCHBACKS , CLIFFS,AND NO GUARDRAIL, IT WAS A MIRACLE NO ONE WAS INJURED OR KILLED. THIS SAME VEHICLE HAD JUST HAD A DUPLICATE PROBLEM AND WAS REPAIRED AT THE DEALERSHIP IN JULY, LESS THAT 1000 MILES PRIOR TO THIS CURRENT EVENT. THE DEALER IN JULY REPLACED THE MAS SENSOR AND THE BATTERY AS THEY SAID THE MAS WAS CORRODED AND NEEDED TO BE REPLACED. THIS CURRENT EVENT WAS CAUSED BY THE MAP SENSOR AND THE MAIN COMPUTER ACCORDING TO THE DEALER. *TR
NHTSA ODI #10679863
180,000 miles · May 29, 2014
Service Brakes
ALL OF THE SUDDEN OUT OF NO WHERE THE ABS LIGHT AND THE TRAC CONTROL LIGHT COME ON WHILE DRIVING IN THE RAIN AND THE CAR ALMOST SKIDDED OUT OF CONTROL! NOW THE LIGHTS HAVE STAYED ON CONSTANTLY. I HAVE SPENT ABOUT 3 MONTHS RESEARCHING THE WEB TO FIND THAT THOUSANDS OF PEOPLE WITH THIS SAME VEHICLE ARE GOING THROUGH THE SAME ISSUE…
Read full complaint
ALL OF THE SUDDEN OUT OF NO WHERE THE ABS LIGHT AND THE TRAC CONTROL LIGHT COME ON WHILE DRIVING IN THE RAIN AND THE CAR ALMOST SKIDDED OUT OF CONTROL! NOW THE LIGHTS HAVE STAYED ON CONSTANTLY. I HAVE SPENT ABOUT 3 MONTHS RESEARCHING THE WEB TO FIND THAT THOUSANDS OF PEOPLE WITH THIS SAME VEHICLE ARE GOING THROUGH THE SAME ISSUES. NO ONE HAS DONE A RECALL ON THIS IN ALL OF THESE YEARS??? DOES THERE HAVE TO BE A DEATH TO HAVE THE ISSUE FIXED? MAYBE THERE ALREADY HAS BEEN. THIS IS OBVIOUSLY A DEFECT IN THE PARTS OR IT WOULD NOT BE HAPPENING TO THIS AMOUNT OF PEOPLE. IT SHOULD NOT BE A FIX AT THE CONSUMERS EXPENSE WHEN THERE IS A DEFINITE ISSUE WITH RESPECT TO THE PARTS. THIS FIX CAN COST UPWARDS OF $3,000.00. I WOULD ASK THAT SOMEONE INVESTIGATE THESE ISSUES AND DO WHAT NEEDS TO BE DONE TO GET THIS RESOLVED ASAP. I WILL BE KEEPING A RECORD OF ALL CONTACT ABOUT THIS ISSUE. THIS WILL ENSURE THAT IF ANYTHING DOES HAPPEN WITH THE SAFETY OF MY FAMILY OR OTHERS FAMILIES IT WILL SHOW CONTACT WAS MADE AND WHAT STEPS CHEVY HAS TAKEN TO ENSURE THE SAFETY OF THERE CUSTOMERS. *TR
NHTSA ODI #10594961
230,000 miles · Nov 18, 2013
EngineService BrakesSteering
PROBLEM WITH STARTING HAS PROGRESS TO A PROBLEM WITH THE CAR SHUTTING OFF DURING OPERATION. SEVERAL TIMES NOW THE CAR HAS SHUT DOWN WITH NO WARNING AND AT DIFFERENT SPEEDS. THIS CAUSES A LOSS OF CONTROL WITH THE POWER STEERING AND POWER BRAKES. I HAVE BEEN ABLE TO PLACE THE TRANSMISSION IN NEUTRAL AND RESTART THE CAR WHILE MOVIN…
Read full complaint
PROBLEM WITH STARTING HAS PROGRESS TO A PROBLEM WITH THE CAR SHUTTING OFF DURING OPERATION. SEVERAL TIMES NOW THE CAR HAS SHUT DOWN WITH NO WARNING AND AT DIFFERENT SPEEDS. THIS CAUSES A LOSS OF CONTROL WITH THE POWER STEERING AND POWER BRAKES. I HAVE BEEN ABLE TO PLACE THE TRANSMISSION IN NEUTRAL AND RESTART THE CAR WHILE MOVING. THE LAST TIME IT HAPPENED, I WAS MAKING A RIGHT TURN AND MERGING INTO THE FLOW OF TRAFFIC. I HAD PRESSURE ON THE STEERING WHEEL WHILE TRYING TO MAKE THE CURVE WHEN I RESTARTED THE CAR. AT THIS POINT, THE POWER STEERING KICKED IN AND I FOUND MYSELF SWERVING FROM THE SUDDEN SNATCH ON THE STEERING. WE WERE LUCKY THAT WE DIDN'T CAUSE AN ACCIDENT. IF MY WIFE HAD BEEN AT THE CONTROLS I KNOW IT WOULD HAVE TURN OUT BAD! I SEE UNLIMITED COMPLAINS AROUND THIS ITEM. DO WE HAVE TO WAIT ON PEOPLE TO GET INJURED OR KILLED BEFORE THE COMPANY IS FORCE TO BE RESPONSIBLE? IF THIS WAS A FOREIGN CAR COMPANY, THE GOVERNMENT WOULD HAVE ALREADY FORCED A RECALL. *TR
NHTSA ODI #10552694
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration