NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
305 reportsClear category filter50,000 miles · Jul 22, 2008
Electrical System
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA LS. WHILE WAITING IN A LINE, THE CONTACT TURNED OFF THE VEHICLE AND IT WOULD NOT RESTART. THE VEHICLE HAD TO BE TOWED TO A MECHANIC AND THEY FOUND NO FAILURES. THE CONTACT BELIEVES THAT THE FAILURE WAS DUE TO THE PASS LOCK. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WER…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA LS. WHILE WAITING IN A LINE, THE CONTACT TURNED OFF THE VEHICLE AND IT WOULD NOT RESTART. THE VEHICLE HAD TO BE TOWED TO A MECHANIC AND THEY FOUND NO FAILURES. THE CONTACT BELIEVES THAT THE FAILURE WAS DUE TO THE PASS LOCK. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 50,000.
NHTSA ODI #10235259
Mileage unknown · Jul 21, 2008
Electrical System
AT RANDOM TIMES, THE CAR WILL NOT START WHEN THE IGNITION IS TURNED. THERE IS NO RESPONSE FROM MOTOR AT ALL. THE SECURITY LIGHT WILL FLASH ON THE INFORMATION CENTER DISPLAY WHEN THIS HAPPENS. AFTER WAITING 10-20 MINUTES THE CAR WILL START. THE FIRST INCIDENT OCCURRED ABOUT 1 YEAR AGO AND HAS BEEN OCCURRING AT RANDOM TIMES EV…
Read full complaint
AT RANDOM TIMES, THE CAR WILL NOT START WHEN THE IGNITION IS TURNED. THERE IS NO RESPONSE FROM MOTOR AT ALL. THE SECURITY LIGHT WILL FLASH ON THE INFORMATION CENTER DISPLAY WHEN THIS HAPPENS. AFTER WAITING 10-20 MINUTES THE CAR WILL START. THE FIRST INCIDENT OCCURRED ABOUT 1 YEAR AGO AND HAS BEEN OCCURRING AT RANDOM TIMES EVER SINCE. VEHICLE WAS TAKEN TO A GM DEALER SERVICE DEPARTMENT AFTER THE FIRST TIME IT OCCURRED AND THEY WERE UNABLE TO DIAGNOSE THE PROBLEM. SINCE THEN I HAVE NOTICED THAT THE FAN FOR THE HVAC SYSTEM WILL NOT WORK AT TIMES AND THE SECURITY LIGHT AND OTHER LIGHTS WILL APPEAR ON THE INFORMATION CENTER DISPLAY AT RANDOM TIMES. *TR
NHTSA ODI #10235235
Mileage unknown · Jul 17, 2008
Electrical System
I OWN A 2002 CHEVY IMPALA. ON 5/20/05 THE SECURITY LIGHT STARTED COMING ON AND WOULD REMAIN ON. THE SECURITY LIGHT CONTINUED TO COME ON AND NOW THE CAR WOULD NOT START. IT WOULD TAKE 10-30MINUTES BEFORE I COULD START THE CAR. I TOOK THE CAR TO A DEALERSHIP AND THEY REPLACED THE IGNITION CYLINDER. ON 6/15/05 THE SAME EXACT PROBLE…
Read full complaint
I OWN A 2002 CHEVY IMPALA. ON 5/20/05 THE SECURITY LIGHT STARTED COMING ON AND WOULD REMAIN ON. THE SECURITY LIGHT CONTINUED TO COME ON AND NOW THE CAR WOULD NOT START. IT WOULD TAKE 10-30MINUTES BEFORE I COULD START THE CAR. I TOOK THE CAR TO A DEALERSHIP AND THEY REPLACED THE IGNITION CYLINDER. ON 6/15/05 THE SAME EXACT PROBLEM STARTED UP AGAIN. THIS TIME THE DEALERSHIP INSTALLED A NEW STARTER. ON 7/16/05 SAME PROBLEM AROSE AGAIN WITH SECURITY LIGHT. A DIAGNOSTIC WAS DONE AND CODES CAME UP FROM A NOTICE FROM GM (8/04). THE CODE #'S WERE B2958 AND B2960. THE CODE SAID TO REPAIR POOR TERMINAL CONNECTIONS AT BODY CONTROL MODULE. THE SECURITY LIGHT CONTINUES TO COME ON AND CAR DOES NOT START. THIS CONTINUES ON/OFF FROM 9/11/05-11/28/05. ON 11/28/05 THE IGNITION LOCK/SENSOR IS REPLACED AND THE PCM IS REPROGRAMMED. AND I AM GIVEN A NEW KEY. LOOKS LIKE AT THE MOMENT THE PROBLEM IS SOLVED. WELL TODAY 7/17/08 I NOTICE THAT THE SECURITY LIGHT IS BACK ON AND I BEGIN TO CRINGE BECAUSE OF WHAT I WENT THROUGH IN 05'. I GET ONLINE TO SEE IF ANYONE ELSE IS EXPERIENCING THE SAME PROBLEM AND I WAS SHOCKED TO SEE THE # OF COMPLAINTS FROM DISGRUNTLED CUSTOMERS ABOUT THIS SECURITY LIGHT. THIS IS AN OUTRAGE! GM BY NOW IS WELL AWARE OF THE PROBLEM WITH THIS SECURITY LIGHT GOING ON. IT WOULD SEEM TO ME THAT THERE WOULD HAVE BEEN A RECALL NOTICE GOING OUT TO CHEVY IMPALA OWNERS. I HAVE CONTACTED GM. MY COMPLAINT IS ON FILE. I HAVE 2 FILE #'S. ONE FOR IN 2005--# [XXX] AND A NEW ONE JUST STARTED TODAY (7/17/08)--#-[XXX]. PLEASE GOOGLE CHEVY IMPALA AND SECURITY LIGHT PROBLEM AND SEE THE LIST OF COMPLAINTS THAT COME UP. THIS IS AN ABSOLUTE DISGRACE! I FEEL THAT THIS IS SOMETHING THAT NEEDS TO BE LOOKED INTO ASAP. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10234695
130,000 miles · Jun 25, 2008
Electrical System
WHEN THE CAR STARTS, SECURITY LIGHT APPEARS ON DASH, A/C MALFUNCTIONS, TRUNK OPENS AUTOMATICALLY, RADIO DISPLAYS "LOCKED OUT" MESSAGE, LIGHTS FLICKER OFF AND ON, QUICK CLICKING SOUND ON PASSENGER SIDE OF DASHBOARD. THE CAR HAS A 50/50 CHANCE OF STARTING. *TR
NHTSA ODI #10232313
90,000 miles · May 16, 2008
Electrical System
20002 CHEVROLET IMPALA, FREQUENTLY DOES NOT START ABOUT ONE IN EVERY TEN TRIES. I HAVE TAKEN IT TO TWO DIFFERENT MECHANICS ONE SAID COULD FIND NOTHING THE SECOND TIME I LEFT IT AT THE GARAGE FOR A WEEK AND A HALF BEFORE IT WOULDN'T START FOR THE MECHANIC. HE CHECKED THE CODES AND THEY SAID IT NEED A NEW IGNITION SWITCH. I AM…
Read full complaint
20002 CHEVROLET IMPALA, FREQUENTLY DOES NOT START ABOUT ONE IN EVERY TEN TRIES. I HAVE TAKEN IT TO TWO DIFFERENT MECHANICS ONE SAID COULD FIND NOTHING THE SECOND TIME I LEFT IT AT THE GARAGE FOR A WEEK AND A HALF BEFORE IT WOULDN'T START FOR THE MECHANIC. HE CHECKED THE CODES AND THEY SAID IT NEED A NEW IGNITION SWITCH. I AM RELUCTANT TO INSTALL A NEW SWITCH BECAUSE OF ALL OF THE COMPLAINTS WITH THIS YEAR AND MODEL CAR AND IN MANY CASES A NEW SWITCH AND COMPUTER DID NOT CORRECT THE PROBLEM. *TR
NHTSA ODI #10227973
65,000 miles · Apr 21, 2008
Electrical System
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE SECURITY LIGHT ILLUMINATED WHICH INDICATED THAT THE ANTI-THEFT DEVICE WAS DEFECTIVE. AS A RESULT, SHE WAS UNABLE TO START HER VEHICLE. THE DEALER INSPECTED THE VEHICLE AND STATED THAT THE PATH LOCK SENSOR CAUSED THE FAILURE. THEY MADE THE REPLACEMENT HO…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE SECURITY LIGHT ILLUMINATED WHICH INDICATED THAT THE ANTI-THEFT DEVICE WAS DEFECTIVE. AS A RESULT, SHE WAS UNABLE TO START HER VEHICLE. THE DEALER INSPECTED THE VEHICLE AND STATED THAT THE PATH LOCK SENSOR CAUSED THE FAILURE. THEY MADE THE REPLACEMENT HOWEVER APPROXIMATELY TEN MONTHS LATE THE FAILURE OCCURRED AGAIN. THE MECHANIC STATED THAT THE PATH LOCK SENSOR CAUSED THE FAILURE AND THEY MADE THE REPLACEMENT. APPROXIMATE SIX MONTHS LATER THE FAILURE OCCURRED AGAIN. THE MECHANIC STATED THAT THE PATH LOCK SENSOR CAUSED THE FAILURE. AS OF APRIL 21, 2008, THE MECHANIC HAD NOT REPAIRED THE VEHICLE. THE FAILURE MILEAGE WAS 65,000 AND CURRENT MILEAGE WAS 88,000.
NHTSA ODI #10225300
10,000 miles · Apr 14, 2008
Electrical System
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE DEALER CHANGED THE BCM MODULE; HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE DEALER THEN REPLACED THE BCM MODULE AGAIN. APPROXIMATELY SIX MONTHS LATER THE FAILURE OCCURRED AGAIN. AS A RESULT, THE POWER WINDOWS WERE INOPERABL…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE DEALER CHANGED THE BCM MODULE; HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE DEALER THEN REPLACED THE BCM MODULE AGAIN. APPROXIMATELY SIX MONTHS LATER THE FAILURE OCCURRED AGAIN. AS A RESULT, THE POWER WINDOWS WERE INOPERABLE. THE MECHANIC STATED THAT AN ELECTRICAL SHORT CAUSED THE FAILURE. THEY REPLACED THE WIRES HOWEVER APPROXIMATELY ONE MONTH LATER THE FAILURE OCCURRED AGAIN. AS OF APRIL 14, 2008, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE FAILURE MILEAGE WAS 10,000 AND CURRENT MILEAGE WAS 121,000.
NHTSA ODI #10224511
100,979 miles · Mar 18, 2008
Electrical SystemEngine And Engine CoolingSteering
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THREE DAYS AFTER THE VEHICLE WAS PURCHASED, THE CONTACT FELT A HARD VIBRATION IN THE AXLE AND ALSO HEARD A CRACKING NOISE ON THE DRIVER SIDE OF THE VEHICLE. THE FAILURE OCCURRED WHILE DRIVING 40 MPH. THE OIL LIGHT ILLUMINATED AND THE OIL WAS CHANGED AT 104,000 MILES. BEFORE THE OI…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THREE DAYS AFTER THE VEHICLE WAS PURCHASED, THE CONTACT FELT A HARD VIBRATION IN THE AXLE AND ALSO HEARD A CRACKING NOISE ON THE DRIVER SIDE OF THE VEHICLE. THE FAILURE OCCURRED WHILE DRIVING 40 MPH. THE OIL LIGHT ILLUMINATED AND THE OIL WAS CHANGED AT 104,000 MILES. BEFORE THE OIL CHANGE, THE MECHANIC STATED THAT THE OIL HAD NEVER BEEN CHANGED AND THAT A NEW RACK AND PINION AND SERPENTINE BELT WERE NEEDED. THE CONTACT ALSO EXPERIENCED ELECTRICAL FAILURE THAT CAUSED THE VEHICLE TO SHUT OFF COMPLETELY. THE DEALER WOULD NOT GIVE HER A CARFAX REPORT AFTER ONE WAS REQUESTED. THE POWERTRAIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 100,979 AND CURRENT MILEAGE WAS 105,840.
NHTSA ODI #10221540
15,630 miles · Mar 1, 2008
Electrical System
THE AIR BAG LIGHT BEGAN ILLUMINATING WITH THE RADIO LOCKING OUT ON OUR 2002 IMPALA AT 15,630 MILES. LOVE CHEVY HUMMER RESET THE COMPUTER. LATER THE SAME PROBLEM RECURRED. AT 16,009 MILES LOVE CHEVY HUMMER REPLACED THE INFLATABLE RESTRAINT SENSING AND DIAGNOSTIC MODULE. LATER, THE SAME PROBLEMS RECURRED MANY TIMES BUT, WE FOUND T…
Read full complaint
THE AIR BAG LIGHT BEGAN ILLUMINATING WITH THE RADIO LOCKING OUT ON OUR 2002 IMPALA AT 15,630 MILES. LOVE CHEVY HUMMER RESET THE COMPUTER. LATER THE SAME PROBLEM RECURRED. AT 16,009 MILES LOVE CHEVY HUMMER REPLACED THE INFLATABLE RESTRAINT SENSING AND DIAGNOSTIC MODULE. LATER, THE SAME PROBLEMS RECURRED MANY TIMES BUT, WE FOUND THAT WE COULD RESET THE COMPUTER BY SHUTTING THE CAR OFF, OPENING AND CLOSING THE DOOR AND RESTARTING THE CAR. AT 23720 MILE THE CAR WAS TAKEN BACK TO TUSCALOOSA CHEVROLET. THE COMPUTER INDICATED THE PROBLEM WAS THE BODY CONTROL MODULE. IT WAS REPROGRAMMED. SEVERAL WEEKS LATER THE SAME PROBLEMS RECURRED OVER AND OVER. WE TOOK THE VEHICLE IN TO BARKLEY PONTIAC, CADILLAC, GMC. THE COMPUTER CODE INDICATED A BODY CONTROL MODULE WAD NEEDED BUT THAT SINCE THE CAR WAS OUT OF WARRANTY I WOULD HAVE TO PAY FOR IT. IT WAS NOT REPAIRED AT THIS TIME. WHILE DRIVING AT NIGHT THE HEADLIGHTS WENT OUT. I WAS ABLE TO GET THEM BACK ON BY FLASHING THE LOW BEAM / HIGH BEAM LEAVER. NOTIFIED GENERAL MOTORS CUSTOMER RELATIONSHIP SPECIALIST SPOKE WITH CARLEY LEBLANC. (SERVICE REQUEST: 71-437167435). AFTER SEVERAL EMAILS AND PHONE CONSERVATIONS WE WERE TOLD US TO FIX IT OURSELVES IF WE WERE SO CONCERNED. WE SENT ADDITION INFORMATION TO CARLEY LEBLANC AND LATER ANGELINA MONCIVAIS CONTACTED ABOUT OUR COMPLAINTS. AFTER SEVERAL MORE EMAILS AND PHONE CONVERSATIONS ANGELINA SAID SHE WAS NOT ABLE TO HELP US. IN JANUARY OF 2008 ALL WARNING INDICATORS STARTED CYCLING AND THE WARNING BELLS STARTED RINGING. ON FEBRUARY 6, 2008 THE IMPALA WOULD NOT START. I CHARGED THE BATTERY AND ON FEBRUARY 15, 2008 TOOK IT BACK IN TO TUSCALOOSA CHEVROLET. AFTER ANOTHER DIAGNOSTIC CHECK WAS TOLD THE BODY CONTROL MODULE WOULD NEED REPLACING AT A COST OF NEARLY $600.00. CALLED GM ASKING FOR HELP SINCE THE SAME PROBLEMS WITH THE CAR HAVE OCCURRED SINCE IT WAS PURCHASED NEW ON JUNE 6, 2002. AFTER ABOUT 2 WEEKS OF PHONE CONVERSATIONS WE WERE TOLD THERE WAS NOTHING GM WOULD DO. *TR
NHTSA ODI #10219794
55,000 miles · Mar 1, 2008
Electrical SystemExterior Lighting
WE HAVE BEEN HAVING PROBLEMS WITH OUR TURN SIGNALS NOT WORKING PROPERLY. ALSO THE SECURITY LIGHT FLASHES AND THE RADIO SAYS LOCKED AND THE VEHICLE WILL NOT START. THE ONLY WAY WE CAN GET IT STARTED IS TO DISCONNECT THE BATTERY AND LET THE COMPUTER REBOOT. *TR
NHTSA ODI #10219775
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration