IllustrationSECURITY LIGHT COMES ON, DOORS LOCK AND WILL NOT OPEN MANUALLY OR ELECTRICALLY. CAR WILL NOT START. SERVICE ENGINE SOON, BRAKES, DOOR AJAR, LIGHTS ALSO COME ON. RED LIGHT ON STEREO FLASHES, HEADLAMPS FLASH. AFTER WAITING 20-30 MINUTES CAR WILL RESTART. HAPPENS OFTEN AND INTERMITTENTLY. REPLACED BATTERY. *TR
2002 Chevrolet Impala
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Impala years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
590–25K
9725–50K
10950–75K
10775–100K
130100–150K
69150K+
571 reports with mileage · 224 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 305 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 123 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports32 fire reports27 injury reports
Electrical System complaints
305 reportsI HAVE A 2002 CHEVROLET IMPALA WHEREAS I BELIEVE THE PASSLOCK IGNITION IS DEFECTIVE. AFTER SEARCHING THE INTERNET, I HAVE FOUND THAT THERE ARE NUMEROUS COMPLAINTS ABOUT THE CAR NOT STARTING. THE FAILURE OCCURS WHEN TRYING TO START THE CAR BY TURNING THE KEY. NOTHING HAS BEEN DO TO CORRECT THIS FAILURE. *TR
I HAVE A 2002 CHEVY IMPALA AND QUITE OFTEN THE CAR WILL NOT START AND DISPLAYS THE SECURITY LIGHT BUT AFTER LEAVING THE KEY IN THE ON POSITION AND PRESSING THE LOCK BUTTON ON THE VEHICLE THE CAR WILL START 10 MINUTES LATER. I HAD TO TAKE MY DAUGHTER TO THE ER BECAUSE OF A BAD CUT ON HER FINGER WHICH WAS BLEEDING PROFUSELY AND WE…
Read full complaint
I HAVE A 2002 CHEVY IMPALA AND QUITE OFTEN THE CAR WILL NOT START AND DISPLAYS THE SECURITY LIGHT BUT AFTER LEAVING THE KEY IN THE ON POSITION AND PRESSING THE LOCK BUTTON ON THE VEHICLE THE CAR WILL START 10 MINUTES LATER. I HAD TO TAKE MY DAUGHTER TO THE ER BECAUSE OF A BAD CUT ON HER FINGER WHICH WAS BLEEDING PROFUSELY AND WE GOT IN THE CAR AND IT WOULDN'T START. AFTER PRESSING THE LOCK BUTTON AND LEAVING THE KEY IN THE ON POSITION FOR 15 MINUTES IT FINALLY STARTED. IT DOES THIS ALL THE TIME AT LEAST 10 TIMES PER WEEK. THANK GOD MY KIDS WEREN'T DYING OR SOMETHING OR THANK HEAVENS IT WASN'T AN EMERGENCY SITUATION WHEN THE CAR WOULDN'T START. BUT I HAVE LOOKED AT NUMEROUS WEBSITES AND IT SEEMS THAT THE 2002 CHEVY IMPALAS HAVE THIS PROBLEM AND IT NEEDS TO BE RECALLED THE OWNERS SHOULD NOT HAVE TO PAY FOR THE PARTS!! *TR
THE PROBLEM IS WITH A 2002 CHEVY IMPALA. THE PROBLEM WITH THE CAR IS THE PASSIVE LOCK 2 SYSTEM.. THIS SYSTEM LOCKS THE CAR OUT AND KEEPS IT FROM STARTING FOR ANY WHERE TO 15-30 MINS AT A TIME. THIS IS A VERY UNSAFE THING FOR ME I AM A SECURITY OFFICER AND FIND MYSELF IN AREAS THAT I NEED TO GET OUT OF AND CAN'T BECAUSE OF THE CA…
Read full complaint
THE PROBLEM IS WITH A 2002 CHEVY IMPALA. THE PROBLEM WITH THE CAR IS THE PASSIVE LOCK 2 SYSTEM.. THIS SYSTEM LOCKS THE CAR OUT AND KEEPS IT FROM STARTING FOR ANY WHERE TO 15-30 MINS AT A TIME. THIS IS A VERY UNSAFE THING FOR ME I AM A SECURITY OFFICER AND FIND MYSELF IN AREAS THAT I NEED TO GET OUT OF AND CAN'T BECAUSE OF THE CAR NOT START DO TO THE FAILING OF THIS SYSTEM THIS IS A ON GOING PROBLEM WITH ALOT OF GM MADE CARS FROM THE YEARS 1999-2004 I HAVE DONE ALOT OF RESEARCH WITH REPAIR SHOPS IN MY AREA AND OUT OF THE AREA. EVERYONE OF THIS PLACE I HAVE CALLED OR BEEN TO HAS TOLD ME THE SAME THING AND THAT IS THEY GET AT LEST ONE GM MADE CAR WITH IN THESE YEARS ONCE A MONTH. THE PROBLEM IS A FAULT IN THE PASS2 SYSTEM THE ONLY WAY TO FIX THIS PROBLEM IS TO TAKE IT TO A GM DEALER OR A AUTO ELECTION TO FIX THIS AND THE COST OF THIS IS OVER $500.00 . CHEVY REFUSES TO DO A RECALL ON THEIR PROBLEM WITH THIS CAR. AND OTHER CARS. *TR
CAR STARTS INTERMITTENTLY, AT FIRST ONCE EVERY MONTH OR SO AND THEN GOT PROGRESSIVELY WORST. THIS PROBLEM HAS BEEN OCCURRING OVER ANY AN EXTENDED PERIOD OF TIME (9-15 MONTHS, MAYBE LONGER). USED AN INDEPENDENT MECHANIC THE MAJORITY OF THE TIME (3-5 VISITS) WAS NEVER ABLE TO IDENTIFY THE PROBLEM. HOWEVER, THE INDEPENDENT MECHA…
Read full complaint
CAR STARTS INTERMITTENTLY, AT FIRST ONCE EVERY MONTH OR SO AND THEN GOT PROGRESSIVELY WORST. THIS PROBLEM HAS BEEN OCCURRING OVER ANY AN EXTENDED PERIOD OF TIME (9-15 MONTHS, MAYBE LONGER). USED AN INDEPENDENT MECHANIC THE MAJORITY OF THE TIME (3-5 VISITS) WAS NEVER ABLE TO IDENTIFY THE PROBLEM. HOWEVER, THE INDEPENDENT MECHANIC WAS REASONABLE IN HIS CHARGES. SINCE 10/23/09 STARTED USING A GM DEALER (A BIG MISTAKE). THEY HAVE CHANGED THE BODY CONTROL MODULE AND REPLACED THE IGNITION CYLINDER WITH PASSLOCK SENSOR. COST APPROACHING $1K AND STILL THE SAME PROBLEM THOUGH WITH LESS FREQUENCY (ABOUT THREE TIMES SINCE 11/10/09). CONTACTED GM FOR ASSISTANCE AND DUE TO MILEAGE (ABOUT 130K) THEY ARE UNWILLING TO HELP. ONLY BUY A GM PRODUCT IF YOU DON'T PLAN TO PUT MUCH MILEAGE ON IT. *TR
I HAVE A SAFETY CONCERN INVOLVING UNRESOLVEABLE ISSUES WITH A 2002 IMPALA LS. DUE TO PASSLOCK, MY CAR WILL RANDOMLY NOT START, THINKING THAT I (THE OWNER) AM TRYING TO STEAL THE CAR. THIS IS A SAFETY ISSUE BEING THAT I AM A YOUNG, UNMARRIED WOMAN, WHO HAS TO DRIVE IN AND THROUGH ROUGH NEIGHBORHOODS TO GET TO WORK AND SCHOOL. THI…
Read full complaint
I HAVE A SAFETY CONCERN INVOLVING UNRESOLVEABLE ISSUES WITH A 2002 IMPALA LS. DUE TO PASSLOCK, MY CAR WILL RANDOMLY NOT START, THINKING THAT I (THE OWNER) AM TRYING TO STEAL THE CAR. THIS IS A SAFETY ISSUE BEING THAT I AM A YOUNG, UNMARRIED WOMAN, WHO HAS TO DRIVE IN AND THROUGH ROUGH NEIGHBORHOODS TO GET TO WORK AND SCHOOL. THIS ISSUE COULD LEAVE ME AND OTHERS STRANDED AT LOCATION. AND WHO KNOWS WHAT COULD HAPPEN FROM THERE, VARYING FROM MURDER TO ASSAULT, ETC. AND IF YOU KNOW FLINT, SAGINAW, AND DETROIT MICHIGAN, THIS IS A HUGE ISSUE. THE CAR HAS BEEN EVALUATED BY THREE DIFFERENT MECHANICS, TWO DEALERSHIPS, AND THERE IS NO SOLUTION. ASIDE FROM THAT ISSUE, THE CAR'S TRACTION CONTROL TURNS ON AT RANDOM, THE ABS BRAKES TURN ON, ALMOST CAUSING ACCIDENTS. THIS IS ANOTHER ISSUE THAT CAN'T BE RESOLVED BY ANY OF THE MECHANICS I'VE TALKED TO. THIS IS COSTING TONS OF MONEY AND GM HAS NO SOLUTION. GM NEEDS TO ISSUE A RECALL AND HAVE THESE ISSUES FIXED. *TR
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE TURN SIGNALS AND HAZARD LIGHTS WERE INOPERATIVE. SHE INSTALLED A NEW FUSE, BUT THAT DID NOT REMEDY THE FAILURE. THE MANUFACTURER NOR THE DEALER WAS NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE 97,624.
2002 CHEVROLET IMPALA LS 60,000 MILES LEAVES WIFE STRANDED DUE TO SOME SECURITY DEVICE THAT DOES NOT ALLOW THE VEHICLE TO START , NO WARNING SIGNS OTHER THAN A SECURITY LIGHT THAT IS DISPLAYED FOR NO APPARENT REASON WHILE DRIVING. I HAVE RESEARCHED ONLINE AND IT SEEMS AS THOUGH THIS IS A COMMON PROBLEM WITH THESE CARS. THE REPAI…
Read full complaint
2002 CHEVROLET IMPALA LS 60,000 MILES LEAVES WIFE STRANDED DUE TO SOME SECURITY DEVICE THAT DOES NOT ALLOW THE VEHICLE TO START , NO WARNING SIGNS OTHER THAN A SECURITY LIGHT THAT IS DISPLAYED FOR NO APPARENT REASON WHILE DRIVING. I HAVE RESEARCHED ONLINE AND IT SEEMS AS THOUGH THIS IS A COMMON PROBLEM WITH THESE CARS. THE REPAIRS ARE EXPENSIVE AND DON'T SEEM TO BE A RELIABLE FIX THIS IS A SAFETY ISSUE TO ME. GM SHOULD FIX IT, AS IT IS A OBVIOUS DESIGN FLAW. *TR
MY 2002 IMPALA WONT START EVERYDAY I HAVE TO GET A BOOST IT MAKES ME LATE FOR WORK I GO TO CRANK IT JUST CLICK CLICK WITH ALL THE INTERIOR LIGHT BLINKING THAT'S NOT SAFE BEING A FATHER OF 2 AND RUNNING THE RISK OF CAR NOT STARTING AFTER SITTING FOR 2 HOURS. *TR
MY 2002 CHEVY IMPALA HAS A RANDOM ISSUE WITH STARTING AND HAS LEFT ME STRANDED SEVERAL TIMES. ONE TIME THE CAR QUIT RUNNING WHILE DRIVING LEAVING ME WITH NO POWER STEERING OR BRAKES GOING DOWN THE HIGHWAY! THEN WOULD NOT START AGAIN FOR ABOUT 15 MINUTES. ON THE INTERNET I SEE WHERE THERE ARE THOUSANDS OF IGNITION SWITCH COMPLAI…
Read full complaint
MY 2002 CHEVY IMPALA HAS A RANDOM ISSUE WITH STARTING AND HAS LEFT ME STRANDED SEVERAL TIMES. ONE TIME THE CAR QUIT RUNNING WHILE DRIVING LEAVING ME WITH NO POWER STEERING OR BRAKES GOING DOWN THE HIGHWAY! THEN WOULD NOT START AGAIN FOR ABOUT 15 MINUTES. ON THE INTERNET I SEE WHERE THERE ARE THOUSANDS OF IGNITION SWITCH COMPLAINTS ON THIS AND SEVERAL OTHER GM MODELS. THIS IS OBVIOUSLY A GM ISSUE THAT THEY HAVE FAILED TO ADDRESS. LEAVING SOMEONE STRANDED OR EVEN WORSE STALLING WHILE DRIVING IS A SAFETY ISSUE. I LIVE IN OHIO WHERE IT CAN EASILY GET BELOW ZERO IN THE WINTER IF MY CAR LEAVES ME STRANDED, IT COULD BE VERY DANGEROUS. *TR
Official recalls
415V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
02V222000 · Air Bags:frontal
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.