NHTSA owner reports · September 18, 2026 snapshot.
Equipment complaints
16 reportsClear category filterMileage unknown · Dec 17, 2015
Electrical SystemEquipment
TL* THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT STATED THAT THERE WAS A PROGRESSING FAILURE IN WHICH THE RADIO STAYED ON WHEN THE VEHICLE WAS TURNED OFF. THERE WAS AN ERROR MESSAGE ON THE RADIO DISPLAY PANEL, INDICATING "CHECK CD". THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE CONTACT LATER RECEIVED…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT STATED THAT THERE WAS A PROGRESSING FAILURE IN WHICH THE RADIO STAYED ON WHEN THE VEHICLE WAS TURNED OFF. THERE WAS AN ERROR MESSAGE ON THE RADIO DISPLAY PANEL, INDICATING "CHECK CD". THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE) AND WAS UNABLE TO DETERMINE WHEN THE PARTS WOULD BECOME AVAILABLE TO RECEIVE THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND WAS NOT ABLE TO DETERMINE A REASONABLE TIME FRAME OF WHEN THE PARTS WOULD BECOME AVAILABLE TO SUPPLY TO THE DEALER. THE FAILURE MILEAGE WAS NOT AVAILABLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. UPDATED 03/09/16*LJ; 05/14/18*JB *TR
NHTSA ODI #10810965
Mileage unknown · Oct 11, 2011
Electrical SystemEquipment
MY CAR WILL NOT START DUE TO AN ISSUE WITH THE PASSKEY/PASSLOCK SYSTEM. IT IS A ANTI THEFT FUNCTION INSTALLED ON SEVERAL OF THE GM MODELS THAT WHEN IT FAILS TO WORK IT ACTUALLY KEEPS THE OWNER FROM USING THE VEHICLE. AFTER GOING ON LINE TO RESEARCH THIS ISSUE I NOTICED THAT THIS WAS A VERY COMMON AND EXPENSIVE PROBLEM TO HAVE. I…
Read full complaint
MY CAR WILL NOT START DUE TO AN ISSUE WITH THE PASSKEY/PASSLOCK SYSTEM. IT IS A ANTI THEFT FUNCTION INSTALLED ON SEVERAL OF THE GM MODELS THAT WHEN IT FAILS TO WORK IT ACTUALLY KEEPS THE OWNER FROM USING THE VEHICLE. AFTER GOING ON LINE TO RESEARCH THIS ISSUE I NOTICED THAT THIS WAS A VERY COMMON AND EXPENSIVE PROBLEM TO HAVE. IN ADDITION TO GETTING THE SYSTEM FIXED MANY OWNERS SAY THAT AFTER ABOUT 3 OR 4 MONTHS THE PROBLEM COMES BACK AND HAVE EVEN DIED ON THEM AS THEY WERE DRIVING. SOME TRY TO BYPASS THIS SYSTEM AND OTHERS ATTEMPT TO HAVE IT FIXED, BUT REGARDLESS OF HOW THEY DEAL WITH IT, I BELIEVE THAT IT IS THE MANUFACTURES RESPONSIBILITY TO ADDRESS COMMON PROBLEMS WITH THE VEHICLES THEY SELL; NOT TO MENTION THAT HONDA WAS HAVING THE SAME ISSUE WITH THEIR VEHICLES AND ISSUED A RECALL. *KB
NHTSA ODI #10429418
97,000 miles · Apr 21, 2010
Equipment
TL*THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT STATED THAT WHEN SHE TURNED OFF THE VEHICLE AND ACTIVATED THE ALARM, THE VEHICLE SEEMED DIFFICULT TO RESTART. THE LIGHTS AND DOORS WOULD FUNCTION PROPERLY BUT THE VEHICLE TOOK 10-20 MINUTES TO GET IT STARTED. THE VEHICLE HAD NOT BEEN INSPECTED AT THE TIME OF THE COMPLAINT.…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT STATED THAT WHEN SHE TURNED OFF THE VEHICLE AND ACTIVATED THE ALARM, THE VEHICLE SEEMED DIFFICULT TO RESTART. THE LIGHTS AND DOORS WOULD FUNCTION PROPERLY BUT THE VEHICLE TOOK 10-20 MINUTES TO GET IT STARTED. THE VEHICLE HAD NOT BEEN INSPECTED AT THE TIME OF THE COMPLAINT. THE VIN WAS UNAVAILABLE AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE 97,000.
NHTSA ODI #10326838
146,705 miles · Mar 7, 2010
Electrical SystemEquipmentTires
I BOUGHT A 2001 CHEVY IMPALA 1 WEEK AGO AND NOW IT WILL NOT ACCELERATE OVER 30 MILES AN HOUR PLUS IT CUTS OFF WHEN IT REACHES THOSE MILES. I HAD NEW SPARK PLUGS INSTALLED, WIRES, COIL PACKS AND A NEW FUEL FILTER INSTALLED. *TR
NHTSA ODI #10317503
38,000 miles · Oct 7, 2008
Electrical SystemEquipmentService Brakes, Hydraulic
2001 CHEVORLET/IMPALA PURCHASED NEW, CURRENT MILES 51,000. INTERMITTANT LOSS OF DIRECTIONALS. **NOW COMPLETE LOSS OF DIRECTIONALS AND EMERGENCY SIGNALS. FAILED RECENT CAR INSPECTION. ADDITIONAL FAILURES INCLUDE: COMPLETE BRAKE LOSS AT 38,000. RESULTING IN REPLACEMENT OF ENTIRE BRAKE SYSTEM. FIRESTONE TIRE, WEST ROXBURY, MA …
Read full complaint
2001 CHEVORLET/IMPALA PURCHASED NEW, CURRENT MILES 51,000. INTERMITTANT LOSS OF DIRECTIONALS. **NOW COMPLETE LOSS OF DIRECTIONALS AND EMERGENCY SIGNALS. FAILED RECENT CAR INSPECTION. ADDITIONAL FAILURES INCLUDE: COMPLETE BRAKE LOSS AT 38,000. RESULTING IN REPLACEMENT OF ENTIRE BRAKE SYSTEM. FIRESTONE TIRE, WEST ROXBURY, MA STATED ON DOCUMENTS THAT "ROTORS WERE THINNED DOWN TO SIZE OF SHEET OF PAPER &/OR COMPLETELY GONE." TWO TIRE BLOWOUTS AT 35,000, ALSO REPLACED BY ABOVE REPAIR SHOP, WITH 4 NEW TIRES. BATTERY LEAK WITH CORROSION TO EXTENT OF NEED OF CONNECTION CABLES TO BE REBUILT FOR ATTACHMENT. BATTERY REPLACED WITH NEW CONNECTIONS AT 40,000 BY SEARS AUTO BODY IN DEDHAM, MA. PASSENGAR SIDE WIPER FIXED AND REPLACED AFTER FAILURE. WORKED FOR 3 MONTHS AND HAS FAILED AGAIN, HAS NOT AT PRESENT BEEN REPLACED/REPAIRED. CARE OF CAR WAS UPDATED AND MAINTAINED ACCORDING TO ALL REQUIREMENTS/RECOMMENDATIONS BY MANUFACTURER. NO HISTORY OF ACCIDENTS. THIS INCLUDING, OIL CHANGES, WIPER BLADE CHANGES, TIRE ROTATIONS WITH EVEY OTHER OIL CHANGE, WHICH WAS DONE EVERY 3 MONTS, ETC. BRAKE INSPECTION AND PADS CHANGED ON CAR 1 YEAR BEFORE COMPLETE FAILURE. BRAKE LOSS WAS THANKFULLY UNEVENTFUL ONLY DUE TO TIME OF NIGHT AND LOW TRAFFIC, ONLY ABLE TO STOP CAR WITH GLIDING TO STOP. THEN TOWED TO SERVICE STATION. ON AVERAGE MY PRESENT YEARLY MILAGE IS PROBABLY LESS THAN 3000. I AM THE ONLY DRIVER/OPERATOR TO THIS CAR AND ALTHOGH MENTIONED #1 OWNER, MY FATHER ORIGINALLY PURCHASED THE CAR, (HOWARD CHEVORLET, WEST ROXBURY, MA) BUT DID NOT DRIVE IT. I CURRENTLY AM THE TITLE HOLDER. PLEASE FEEL FREE TO CONTACT ME ANYTIME IF YOU HAVE ANY RECOMMENDATIONS THAT COULD HELP ME. I FEEL THAT THERE IS MAJOR FAILURE THAT BEYOND MY CONTROL AND IS DANGEROUS TO MYSELF, OTHERS AND MOST IMPORTANT TO ME, MY 4 Y/O DAUGHTER. THANK YOU FOR YOUR TIME. I HOPE TO HEAR FROM YOU (SOMEONE) SOON. TERESA CORRIGAN *TR
NHTSA ODI #10244594
Mileage unknown · Jan 20, 2008
EquipmentFuel System, GasolineFuel System, OtherFire
2001 CHEVY IMPALA I WENT OUTSIDE TO START THE VEHICLE AND THE BATTERY WAS DEAD, IT HAD ENOUGH POWER TO POWER UP THE LIGHTS ETC. HOWEVER, IT DID NOT HAVE ENOUGH POWER TO START THE ENGINE. I THAN MOVED ANOTHER VEHICLE UP NEXT TO IT AND CONNECTED JUMPER CABLES. I WAITED FOR IT TO CHARGE AND TURNED THE KEY. WHEN I TURNED THE KEY OV…
Read full complaint
2001 CHEVY IMPALA I WENT OUTSIDE TO START THE VEHICLE AND THE BATTERY WAS DEAD, IT HAD ENOUGH POWER TO POWER UP THE LIGHTS ETC. HOWEVER, IT DID NOT HAVE ENOUGH POWER TO START THE ENGINE. I THAN MOVED ANOTHER VEHICLE UP NEXT TO IT AND CONNECTED JUMPER CABLES. I WAITED FOR IT TO CHARGE AND TURNED THE KEY. WHEN I TURNED THE KEY OVER, THE PLASTIC INTAKE MANIFOLD VIOLENTLY EXPLODED. I HAD A HUGE FIRE UNDER MY HOOD. THE EXPLOSION SHOT PARTS ACROSS MY YARD. I HAD TO USE THE WATER HOSE TO PUT THE FIRE OUT, THE CAR WAS LESS THAN 10 FEET FROM MY HOME. I LEFT IT ALONE AND CONTACTED A DEALERSHIP MECHANIC THE VERY NEXT DAY. I WAS TOLD THAT THEY HAD RECENTLY HAD 2 OF THE SAME VEHICLES COME IN WITH THE SAME PROBLEM, AND THAT IT WAS DUE TO A FAULTY FUEL PRESSURE REGULATOR AND THE FACT THAT THE MANIFOLD IS MADE OF PLASTIC. THIS EXPLOSION COULD HAVE VERY WELL KILLED SOMEONE. I HAVE RESEARCHED THIS ISSUE, AND FOUND THAT THERE WAS A RECALL DONE ON OVER 900,000 OF THESE VEHICLES, HOWEVER, WHEN I CONTACTED GENERAL MOTORS, MY VIN # WAS NOT INCLUDED IN THE RECALL LIST ACCORDING TO GENERAL MOTORS!!!!!!!!!!!!! *TR
NHTSA ODI #10215474
Mileage unknown · Jan 15, 2008
Engine And Engine CoolingEquipmentExterior Lighting
THIS CAR HAS BEEN A ELECTRICAL/MECHANICAL NIGHTMARE AND I'M FINDING MANY, MANY, REPORTS ON THE INTERNET OF OWNERS HAVING THE SAME PROBLEM(S). 1) INTAKE MANIFOLD GASKET LEAKS CAUSING CATALYTIC CONVERTER AND EGR VALVE TO CLOG. THE RESULT OF THIS IS EXHAUST GASES CAN'T ESCAPE , BACKING UP AND BURNING/BLOWING A HOLE IN THE INTAKE…
Read full complaint
THIS CAR HAS BEEN A ELECTRICAL/MECHANICAL NIGHTMARE AND I'M FINDING MANY, MANY, REPORTS ON THE INTERNET OF OWNERS HAVING THE SAME PROBLEM(S). 1) INTAKE MANIFOLD GASKET LEAKS CAUSING CATALYTIC CONVERTER AND EGR VALVE TO CLOG. THE RESULT OF THIS IS EXHAUST GASES CAN'T ESCAPE , BACKING UP AND BURNING/BLOWING A HOLE IN THE INTAKE MANIFOLD ITSELF. ALL ABOVE ITEMS HAD TO BE REPLACED AT A VERY SUBSTANTIAL COST. 2) BLINKERS INTERMITTENTLY WORK. MOSTLY THEY DON'T WORK. THIS IS CAUSED BY A DEFECTIVE (FLASHER) MODULE LOCATED IN THE DASH BEHIND THE 'FLASHER" BUTTON. THIS IA VERY,VERY COMMON. 3) A/C HEATER BLOWER FAN STOPS WORKING ON SPEEDS 1,2 THEN 3 RESULTING. THIS IS DUE TO RESISTORS BURNING UP ON A MODULE MOUNTED BEHIND THE DASH AND IN FRONT OF THE BLOWER MOTOR. MY QUESTION HERE IS, AT WHAT POINT DOES SOMEONE HOLD THE MANUFACTURER RESPONSIBLE FOR THESE OBVIOUS FACTORY DEFECTS. ALL YOU HAVE TO DO IS GOOGLE ANY OF THE ABOVE COMPLAINTS AND SEE HOW MANY PEOPLE ARE AFFECTED. HELP !!! *TR
NHTSA ODI #10214887
99,000 miles · Nov 9, 2007
Equipment
THE PASSLOCK SYSTEM ON MY 2001 IMPALA IS NOT WORKING PROPERLY AND WILL CAUSE THE CAR NOT TO START FOR 10-20 MINUTES. THIS HAPPENS RANDOMLY AND ALWAYS AFTER THE CAR IS STARTED FOR THE FIRST TIME IN THE DAY, SO I HAVE BEEN STRANDED AT THE GYM, RESTAURANTS, GAS STATIONS, WORK, ETC. MOST OF THE TIME, THIS HAPPENS AT NIGHT AFTER I M…
Read full complaint
THE PASSLOCK SYSTEM ON MY 2001 IMPALA IS NOT WORKING PROPERLY AND WILL CAUSE THE CAR NOT TO START FOR 10-20 MINUTES. THIS HAPPENS RANDOMLY AND ALWAYS AFTER THE CAR IS STARTED FOR THE FIRST TIME IN THE DAY, SO I HAVE BEEN STRANDED AT THE GYM, RESTAURANTS, GAS STATIONS, WORK, ETC. MOST OF THE TIME, THIS HAPPENS AT NIGHT AFTER I MAKE A STOP IN BETWEEN WORK AND COMING HOME. THIS COULD BE VERY DANGEROUS FOR SINGLE WOMEN WHO ARE STRANDED IN A PARKING LOT IN THE MIDDLE OF THE NIGHT WAITING FOR 20 MINUTES FOR THEIR CAR TO START. *TR
NHTSA ODI #10208543
79,500 miles · Mar 20, 2007
EquipmentPower TrainService Brakes, Hydraulic
THE TRACTION SYSTEM WAS ACTIVATING FOR NO REASON. SERVICE ABS LIGHT CAME ON IN VEHICLE. DEALER REPLACED LEFT WHEEL HUB, INCLUDING SENSOR. PROBLEM RECURRED THE DAY AFTER AND THE WRONG ASSEMBLY WAS INSTALLED, THE CORRECT ASSEMBLY WAS INSTALLED. ONE MONTH LATER PROBLEM RECURRED. DEALER CLAIMED IT WAS A LOOSE CONNECTION ON W…
Read full complaint
THE TRACTION SYSTEM WAS ACTIVATING FOR NO REASON. SERVICE ABS LIGHT CAME ON IN VEHICLE. DEALER REPLACED LEFT WHEEL HUB, INCLUDING SENSOR. PROBLEM RECURRED THE DAY AFTER AND THE WRONG ASSEMBLY WAS INSTALLED, THE CORRECT ASSEMBLY WAS INSTALLED. ONE MONTH LATER PROBLEM RECURRED. DEALER CLAIMED IT WAS A LOOSE CONNECTION ON WHEEL HUB ASSEMBLY. SEVEN MONTHS LATER PROBLEM RECURRED. DEALER NOW SAYS THE RIGHT HUB ASSEMBLY NEEDED REPLACING, AS WELL AS THE TRANSMISSION SOLENOID. REPAIRS HAVE NOT BEEN DONE FOR THE LATTER BECAUSE WE WANT DEALERSHIP TO REPAIR FREE OF CHARGE.*AK
NHTSA ODI #10185599
50,508 miles · Mar 24, 2006
Engine And Engine CoolingEquipment
LOW COOLANT LIGHT STAYS ON - REPLACED FIRST TIME LOW COOLANT LIGHT STAYS ON - REPLACED SECOND TIME. *JB
NHTSA ODI #10153631
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 29, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence & remedy
Consequence: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration