IllustrationWhile driving at 70 mph my car just shut off. The radio and lights stayed on. The oil and battery light came on before it just shut down. Steering locked up. When safely to side, and turned key off it starts right back up, but now traction system is off. Has gas and nothing is broken.
2001 Chevrolet Impala
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Impala years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
470–25K
8825–50K
8350–75K
7375–100K
112100–150K
73150K+
476 reports with mileage · 266 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 225 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 123 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
33 crash reports67 fire reports27 injury reports
Engine complaints
68 reportsafter car not used for two days, turning ignition on and attempted to start the engine a extremely load explosion came from engine compartment! Upon looking at the engine the PLASTIC intake manifold was blown to pieces. no warning a explosion was to occur, car was running normal prior to explosion.
When the Mass Airflow Sensor gets dirty, engine shuts off..
MY CAR SHUTS OFF WHEN DRIVING. THE SECURITY LIGHT COMED ON. SOMETIMES NO POWER TO START SO I SEITCH KEYD. THERE BEEN A RECALL BUT WAS NOT PROPERLY FIXED. MY LIFE IS IN DANGER DRIVING AND I REPLACED SO MANY PARTS THAT WAS NEVER THE PROBLEM.
ENGINE OIL LEAKS ON MANIFOLD AND COULD CAUSE A FIRE
TL* THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT STATED THAT WHEN THE KEY WAS TURNED TO THE START POSITION, SEVERAL WARNING LIGHTS ILLUMINATED AND THE VEHICLE FAILED TO START. THE CONTACT STATED THAT THE ABS WARNING LIGHT AND CHECK ENGINE LIGHTS WERE ILLUMINATED. THE VEHICLE WAS STARTED AND THE VEHICLE LOSS BRAKES AND P…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT STATED THAT WHEN THE KEY WAS TURNED TO THE START POSITION, SEVERAL WARNING LIGHTS ILLUMINATED AND THE VEHICLE FAILED TO START. THE CONTACT STATED THAT THE ABS WARNING LIGHT AND CHECK ENGINE LIGHTS WERE ILLUMINATED. THE VEHICLE WAS STARTED AND THE VEHICLE LOSS BRAKES AND POWER STEERING FUNCTIONALITY WITH THE CHECK ENGINE WARNING LIGHT REMAINING ILLUMINATED. THE CONTACT WAS PREVIOUSLY INFORMED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) HOWEVER, THE VEHICLE WAS NOT REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000.
TL* THE CONTACT OWNS A 2001 CHEVROLET IMPALA. UPON STARTING THE VEHICLE, THE CONTACT HEARD A LOUD BANG AND AN UNKNOWN WARNING INDICATOR ILLUMINATED. A FIRE STARTED FROM UNDERNEATH THE HOOD AND THE CONTACT'S HUSBAND CAME OUTSIDE AND INSTRUCTED HER TO GRAB THE FIRE EXTINGUISHER. HER HUSBAND EXTINGUISHED THE FIRE. A FIRE REPORT WAS…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET IMPALA. UPON STARTING THE VEHICLE, THE CONTACT HEARD A LOUD BANG AND AN UNKNOWN WARNING INDICATOR ILLUMINATED. A FIRE STARTED FROM UNDERNEATH THE HOOD AND THE CONTACT'S HUSBAND CAME OUTSIDE AND INSTRUCTED HER TO GRAB THE FIRE EXTINGUISHER. HER HUSBAND EXTINGUISHED THE FIRE. A FIRE REPORT WAS NOT FILED. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 09V116000 (ENGINE, ENGINE COOLING), WHICH SHE RELATED DIRECTLY WITH HER FAILURE. THE CONTACT SPOKE WITH THE MANUFACTURER AND WAS OFFERED AN AMOUNT FOR THE REPAIRS TO THE VEHICLE; HOWEVER, THERE WAS NO RESOLUTION TO THE MATTER. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN.
I DROVE THE CAR TO A STORE, PARKED, TURNED THE ENGINE OFF AND EXITED THE VEHICLE. WHEN I GOT OUT OF THE CAR IT WAS SMOKING UNDER THE HOOD. A SHORT TIME LATER THE CAR WAS ON FIRE IN THE ENGINE BAY. I'D SAY FLAMES ERUPTED APPROXIMATELY 10 MINUTES AFTER I EXITED THE VEHICLE.
WHILE DRIVING THE CAR THE ENGINE SIMPLY SHUTS OFF WHETHER ON THE HIGHWAY AT 70 MPH, ON CITY STREETS AT 40 MPH OR BACKING OUT OF MY DRIVEWAY. USUALLY AFTER WAITING A FEW MINUTES IT WILL RESTART. THE PROBLEM BEGAN IN FEBRUARY 2019 AND HAS BEEN ONGOING. MY MECHANIC HAS HAD THE CAR MULTIPLE TIMES AND I HAVE HAD THE CAR TOWED TO MY M…
Read full complaint
WHILE DRIVING THE CAR THE ENGINE SIMPLY SHUTS OFF WHETHER ON THE HIGHWAY AT 70 MPH, ON CITY STREETS AT 40 MPH OR BACKING OUT OF MY DRIVEWAY. USUALLY AFTER WAITING A FEW MINUTES IT WILL RESTART. THE PROBLEM BEGAN IN FEBRUARY 2019 AND HAS BEEN ONGOING. MY MECHANIC HAS HAD THE CAR MULTIPLE TIMES AND I HAVE HAD THE CAR TOWED TO MY MECHANIC 3 TIMES MAKING SURE NOT TO START THE CAR. IT HAS NO CODES STORED TO HELP MY MECHANIC FIND THE PROBLEM. THEY HAVE TRIED SEVERAL DIFFERENT THINGS BUT AS USUALLY EVEN WHEN THEY KEPT IT 2 WEEKS THE CAR FAILED TO STALL ON THEM WHEN THEY TEST DROVE IT. I HAVE SEEN ARTICLES AND EVEN COMPLAINTS ON YOUR WEBSITE OF THIS ISSUE. THIS IS SERIOUS AND DANGEROUS AND I CANNOT BELIEVE A RECALL HAS NOT BEEN ISSUED.
TL* THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE CONTACT CALLED AN UNKNOWN DEALER LOCATED IN FRENDALE, MICHIGAN AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO C…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE CONTACT CALLED AN UNKNOWN DEALER LOCATED IN FRENDALE, MICHIGAN AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Official recalls
715V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
01V136000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
00V371000 · Air Bags:side/window
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
00V244000 · Air Bags
Aug 29, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence & remedy
Consequence: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.