NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
225 reportsClear category filter91,000 miles · Oct 16, 2009
Electrical System
MY 2001 IMPALA WITH A 3.8 V-6 WOULD NOT START AFTER GOLF LAST THURSDAY, SO I HAD IT TOWED TO A REPAIR SHOP. THE SHOP PUT IN A NEW FUEL PUMP, FUEL FILTER, SPARK PLUGS AND WIRES. THE BILL CAME TO $900. I HAD THE SAME PROBLEM VARIOUS OCCASIONS OVER THE NEXT COUPLE WEEKS AND DECIDED TO LOOK ON THE INTERNET. THIS SITE POPPED UP WHEN …
Read full complaint
MY 2001 IMPALA WITH A 3.8 V-6 WOULD NOT START AFTER GOLF LAST THURSDAY, SO I HAD IT TOWED TO A REPAIR SHOP. THE SHOP PUT IN A NEW FUEL PUMP, FUEL FILTER, SPARK PLUGS AND WIRES. THE BILL CAME TO $900. I HAD THE SAME PROBLEM VARIOUS OCCASIONS OVER THE NEXT COUPLE WEEKS AND DECIDED TO LOOK ON THE INTERNET. THIS SITE POPPED UP WHEN I "SEARCHED STALLS WHILE DRIVING" BECAUSE THE CAR STARTED STALLING OCCASIONALLY WHILE DRIVING UNDER JUST ABOUT ANY CONDITION. I BOUGHT A NEW CRANKSHAFT POSITION SENSOR FROM CAR QUEST INSTALLED IT MYSELF IN LESS THAN AN HOUR AND HAVEN'T HAD ANY PROBLEMS FOR ABOUT A WEEK NOW. THANKS FOR THE INFO. *TR
NHTSA ODI #10288698
100,000 miles · Oct 16, 2009
Air BagsElectrical SystemTraction Control System
SECURITY LIGHT COMES ON, TRACTION LIGHT COMES ON, RPM'S DROP TO 0, GAS DROPS TO 0, CONSTANT DRAINING OF BATTERY AND IS DEAD AFTER 10 OR SO HOURS. MANY PEOPLE ON FORUMS ARE ALL COMPLAINING OF THE SAME THING AND EVEN MECHANICS SAY THAT THIS IS A VERY COMMON PROBLEM WITH THESE CARS YET THERE IS NO RECALL! I HAVE SPENT AS OF NOW …
Read full complaint
SECURITY LIGHT COMES ON, TRACTION LIGHT COMES ON, RPM'S DROP TO 0, GAS DROPS TO 0, CONSTANT DRAINING OF BATTERY AND IS DEAD AFTER 10 OR SO HOURS. MANY PEOPLE ON FORUMS ARE ALL COMPLAINING OF THE SAME THING AND EVEN MECHANICS SAY THAT THIS IS A VERY COMMON PROBLEM WITH THESE CARS YET THERE IS NO RECALL! I HAVE SPENT AS OF NOW 1000 DOLLARS ON THIS PROBLEM AND MY DEALER IS TELLING ME THAT MIGHT NOT FIX THE PROBLEM COMPLETELY!!! I HAVE PUT IN A NEW ALTERNATOR, NEW BATTERY, NEW BCM, AND NOW A NEW IGNITION SWITCH! I CURRENTLY HAVE THE OLD BCM AND THE NEW ONE IS IN MY CAR. *TR
NHTSA ODI #10288697
107,000 miles · Aug 8, 2009
Electrical System
SECURITY LIGHT FLASHES AND CAR WILL NOT START. *TR
NHTSA ODI #10279761
126,000 miles · Jul 30, 2009
Electrical System
I HAVE A 2001 CHEVROLET IMPALA. I HAVE HAD MY CAR SINCE FEBRUARY OF 2009 AND IT IS A TERRIFIC CAR WITH THE EXCEPTION OF THE CAR CUTS OFF IN THE MIDDLE OF TRAFFIC, ON THE HIGHWAY AND ANYWHERE IT LIKES. I COULD BE DRIVING DOWN THE ROAD AND THE CAR JUST CUTS OFF. THE BATTERY LIGHT COMES ONE AND I TURN THE CAR SWITCH OFF AND BACK…
Read full complaint
I HAVE A 2001 CHEVROLET IMPALA. I HAVE HAD MY CAR SINCE FEBRUARY OF 2009 AND IT IS A TERRIFIC CAR WITH THE EXCEPTION OF THE CAR CUTS OFF IN THE MIDDLE OF TRAFFIC, ON THE HIGHWAY AND ANYWHERE IT LIKES. I COULD BE DRIVING DOWN THE ROAD AND THE CAR JUST CUTS OFF. THE BATTERY LIGHT COMES ONE AND I TURN THE CAR SWITCH OFF AND BACK ON AND IT STARTS UP AGAIN. I HAVE TAKEN IT TO SEVERAL PLACES AND NO ONE SEEMS TO KNOW WHAT THE PROBLEM IS. THIS IS VERY DANGEROUS FOR A PERSON TO BE DRIVING AND THIS HAPPEN TO THEM. I HAVE GONE ON THE 2001 CHEVROLET IMPALA WEBSITE FOR RECALLS, DEFECTS, AND OTHER ISSUES AND THERE ARE SOOO MANY IMPALA'S WITH THIS SAME ISSUE. I HAVE THREE SMALL CHILDREN AND THIS IS NOT SAFE BUT IT IS MY ONLY SOURCE OF TRANSPORTATION. *TR
NHTSA ODI #10278830
130,000 miles · Jul 21, 2009
Electrical System
WHILE OPERATING MY CAR, WHEN MOVING OR STOPPED AT A LIGHT, THE ENGINE WOULD SUDDENLY SHUT DOWN. IF THE CAR IS MOVING AT 50 TO 65 MPH THE ENGINE WOULD RESTART ON ITS OWN. AT 35 MPH OR LESS I MUST COAST TO THE SIDE OF THE ROAD, STOP MOVING AND PUT THE CAR IN PARK. THE CAR WILL RESTART WITH THE TURNING OF THE IGNITION SWITCH TO ST…
Read full complaint
WHILE OPERATING MY CAR, WHEN MOVING OR STOPPED AT A LIGHT, THE ENGINE WOULD SUDDENLY SHUT DOWN. IF THE CAR IS MOVING AT 50 TO 65 MPH THE ENGINE WOULD RESTART ON ITS OWN. AT 35 MPH OR LESS I MUST COAST TO THE SIDE OF THE ROAD, STOP MOVING AND PUT THE CAR IN PARK. THE CAR WILL RESTART WITH THE TURNING OF THE IGNITION SWITCH TO START. *TR
NHTSA ODI #10277600
137,933 miles · Jul 20, 2009
Electrical System
TL*THE CONTACT OWNS A 2001 CHEVROLET IMPALA. WHILE ATTEMPTING TO START THE VEHICLE, THE CONTACT NOTICED THAT IT WOULD NOT START DUE TO THE SECURITY PASS LOCK. THE ISSUE HAS BEEN OCCURRING FOR THE PAST THREE YEARS. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 137,933.
NHTSA ODI #10277466
Mileage unknown · Jul 16, 2009
Electrical SystemSeats
SEVERAL ELECTRICAL PROBLEMS ONE TURN SIGNALS AND FLASHER ONLY WORK ABOUT HALF TIME, ONE BRAKE LIGHT WORKS ABOUT 1/2 TIME DRIVERSIDE HEATED SEAT OVER HEATED COULD NOT CUT IT OFF TOOK STRAIGHT TO DEALER POGUE CHEVROLET SAID THEY WOULD HAVE TO PUT IT ON COMPUTER TO SEE WHAT THE PROBLEM IS, SAID IT WOULD COST $100.00 TO CHECK IT OU…
Read full complaint
SEVERAL ELECTRICAL PROBLEMS ONE TURN SIGNALS AND FLASHER ONLY WORK ABOUT HALF TIME, ONE BRAKE LIGHT WORKS ABOUT 1/2 TIME DRIVERSIDE HEATED SEAT OVER HEATED COULD NOT CUT IT OFF TOOK STRAIGHT TO DEALER POGUE CHEVROLET SAID THEY WOULD HAVE TO PUT IT ON COMPUTER TO SEE WHAT THE PROBLEM IS, SAID IT WOULD COST $100.00 TO CHECK IT OUT I ASKED THEM IF THEY COULD CHECK IT WITH OUT ME PAYING THE $100.00 THEY SAID NO I TOLD THEM I COULD NOT DRIVE IT LIKE THAT THEY UNPLUGGED THE SEAT, LATER I WAS INFORMED BY MY COUSIN WHO CAME UP FROM FLORIDA THIS WAS A SAFETY ISSUE AND I SHOULD FILE A COMPLAINT WITH YOU PEOPLE HE SAID CHEVROLET WERE OBLIGATED TO FIX ANY SAFETY ISSUES. *TR
NHTSA ODI #10277056
Mileage unknown · Jun 18, 2009
Electrical System
THIS PROBLEM STARTED SEVERAL YEARS AGO. AT RANDOM ENGINE WILL NOT START. THIS SEEMS TO AFFECT MANY DIFFERENT MODELS OF CARS. I HAVE A 2001 CHEVY IMPALA. I USED TO HAVE TO REPLACE THE BATTERY BC IT WOULD HAPPEN EVERY YR. NOW I HAVE TO TURN KEY TO ON AND WAIT TEN MINUTES TO CRANK IT. I AM A SINGLE FEMALE AND THIS PROBLEM IS NOT…
Read full complaint
THIS PROBLEM STARTED SEVERAL YEARS AGO. AT RANDOM ENGINE WILL NOT START. THIS SEEMS TO AFFECT MANY DIFFERENT MODELS OF CARS. I HAVE A 2001 CHEVY IMPALA. I USED TO HAVE TO REPLACE THE BATTERY BC IT WOULD HAPPEN EVERY YR. NOW I HAVE TO TURN KEY TO ON AND WAIT TEN MINUTES TO CRANK IT. I AM A SINGLE FEMALE AND THIS PROBLEM IS NOT ONLY INCONVENIENT BUT UNSAFE. SOMETHING NEEDS TO BE DONE TO CORRECT IT. I HAVE SPOKEN WITH MY DEALER AND THEY ACKNOWLEDGE THE PROBLEM BUT SAY NOTHING WORKS FOR IT AND NOT TO SPEND THE MONEY AND THERE IS NOTHING THEY CAN DO. THERE HAS TO BE SOMETHING BECAUSE OF NUMEROUS COMPLAINTS HERE AND ON THE INTERNET. *TR
NHTSA ODI #10274285
75,000 miles · Jun 16, 2009
Electrical System
2001 IMPALA WON'T START AT DIFFERENT TIMES HAVE TO WAIT 20-30 MINUTES, DOOR LOCKS DON'T WORK ANYMORE, INSIDE LIGHTS DON'T WON'T WHEN THIS HAPPENS THEY COME ON AT DIFFERENT TIMES, WHEN SECURITY LIGHT COMES ON SOMETIMES THE AC DOESN'T WORK. I HAD THE IGNITION LOCK CHANGED BUT STILL SAME PROBLEM. THIS IS A SAFETY ISSUE AT NIGHT SI…
Read full complaint
2001 IMPALA WON'T START AT DIFFERENT TIMES HAVE TO WAIT 20-30 MINUTES, DOOR LOCKS DON'T WORK ANYMORE, INSIDE LIGHTS DON'T WON'T WHEN THIS HAPPENS THEY COME ON AT DIFFERENT TIMES, WHEN SECURITY LIGHT COMES ON SOMETIMES THE AC DOESN'T WORK. I HAD THE IGNITION LOCK CHANGED BUT STILL SAME PROBLEM. THIS IS A SAFETY ISSUE AT NIGHT SINCE I AM A SINGLE PARENT WITH GRANDCHILDREN AND ALSO IN THE HEAT OF SUMMER HAVING TO WAIT FOR THE CAR TO START. *TR
NHTSA ODI #10273969
125,000 miles · Jun 2, 2009
Electrical System
I HAVE 2001 CHEVY IMPALA AND IT HAS STARTING ISSUES. IT DOESN'T START AT TIMES AND IT'S GETTING TO BE MORE OFTEN AND NOTHING WILL GET IT TO START. I JUST LEAVE IT SIT, SOMETIIMES FOR 2 HOURS AND IT MAY OR MAY NOT START. IT QUIT WHILE GETTING READY TO STOP AT A RED LIGHT AND ALMOST CAUSED AN ACCIDENT, AS I COULDN'T STEER MY CAR …
Read full complaint
I HAVE 2001 CHEVY IMPALA AND IT HAS STARTING ISSUES. IT DOESN'T START AT TIMES AND IT'S GETTING TO BE MORE OFTEN AND NOTHING WILL GET IT TO START. I JUST LEAVE IT SIT, SOMETIIMES FOR 2 HOURS AND IT MAY OR MAY NOT START. IT QUIT WHILE GETTING READY TO STOP AT A RED LIGHT AND ALMOST CAUSED AN ACCIDENT, AS I COULDN'T STEER MY CAR AND IT SMELLED HOT. ALSO THE BLINKERS WON'T WORK AT TIMES AND I HAVE TO PRESS MY EMERGENCY FLASHER SWITCH TO GET THEM TO WORK. I HAVE REPLACED THE STARTER AND THE STARTING ISSUE HASN'T IMPROVED AT ALL. IT IS VERY MADDENING AS I NEVER KNOW WHEN IT WILL NOT START WHEN I GO TO LEAVE SOMEWHERE AND IT'S VERY UNDEPENDABLE TO TAKE ANYWHERE. PLEASE CAN YOU HELP WITH THIS PROBLEM? IT HAS BEEN HAPPENING FOR THE LAST YEAR AND IS HAPPENING MORE OFTEN LATELY. *TR
NHTSA ODI #10272613
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 29, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence & remedy
Consequence: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration