NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
225 reportsClear category filter120,000 miles · Mar 30, 2010
Electrical System
I BEGAN HAVING ELECTRICAL PROBLEMS IN MY 2001 CHEVROLET IMPALA IN MID 2008, WHICH CONTINUED TO GET WORSE UNTIL AROUND LATE 2009 WHEN THE CAR WAS NO LONGER SAFE TO DRIVE. THESE PROBLEMS CONSISTED OF HEADLIGHTS FLICKERING ON AND OFF RANDOMLY, INTERMITTENT TURN SIGNAL FAILURE, AND A VARIETY OF OTHER ELECTRICAL RELATED ISSUES. DOING…
Read full complaint
I BEGAN HAVING ELECTRICAL PROBLEMS IN MY 2001 CHEVROLET IMPALA IN MID 2008, WHICH CONTINUED TO GET WORSE UNTIL AROUND LATE 2009 WHEN THE CAR WAS NO LONGER SAFE TO DRIVE. THESE PROBLEMS CONSISTED OF HEADLIGHTS FLICKERING ON AND OFF RANDOMLY, INTERMITTENT TURN SIGNAL FAILURE, AND A VARIETY OF OTHER ELECTRICAL RELATED ISSUES. DOING MINIMAL RESEARCH ON THE INTERNET SHOWS THAT MANY CONSUMERS HAVE OR ARE SUFFERING FROM THE EXACT SAME PROBLEMS, AND IT APPEARS THAT THE MAJORITY OF THESE CLAIMS ARE (TEMPORARILY?) SOLVED BY REPLACING THE BODY CONTROL MODULE IN THESE VEHICLES. AFTER REPLACING MY BODY CONTROL MODULE AT THE DEALER ($600), THE AIRBAG LIGHT CAME ON WITHIN A FEW DAYS OF THE REPAIR. I PRESUME IT IS ALSO RELATED TO A FAULTY BODY CONTROL MODULE SINCE THAT IS WHAT MANY VOICES ON THE INTERNET SAY TO CHECK. I CALLED MY LOCAL CHEVROLET DEALER AND ASKED ABOUT ANOTHER REPLACEMENT, AND THEY TOLD ME IT WOULD COST 170$ JUST TO LOOK AT IT AND THEY SAID IT WAS INSTEAD RELATED TO AN AIRBAG CONTROL MODULE (MORE ELECTRICAL). THIS VEHICLE HAS BEEN IN MY FAMILY SINCE IT WAS PURCHASED BRAND NEW, AND HAS EXPERIENCED A VARIETY OF ELECTRICAL PROBLEMS, MOST OF WHICH WENT AWAY AFTER REPLACING THE BODY CONTROL MODULE. AFTER REPLACING THE BCM, SOME HAVE COME BACK ALREADY. PLEASE PUT A STOP TO THIS! IT IS HIGHLY DANGEROUS TO BE DRIVING DOWN THE FREEWAY AT NIGHT AND HAVE MY HEADLIGHTS SUDDENLY STOP WORKING OR TURN SIGNALS THAT ARE UNRELIABLE AT BEST OR AN AIRBAG THAT FAILS TO LAUNCH DURING AN ACCIDENT. THE SYMPTOMS SEEM TO GET WORSE THE OLDER THE BODY CONTROL MODULE, AND I CAN SEE IT HAPPENING ALL OVER AGAIN NOW THAT MY AIRBAG LIGHT IS ON AFTER REPLACING MY BODY CONTROL MODULE.
NHTSA ODI #10322754
175,000 miles · Mar 26, 2010
Electrical System
THIS HAS HAPPENED ABOUT A DOZEN TIMES IN LAST SEVERAL MONTHS SINCE I PURCHASED THE CAR. I GO TO START IT AND NOTHING. IT WILL NOT TURN OVER. SECURITY LIGHT COMES ON. RADIO AND LIGHTS CONTINUE TOL WORK. IF I WAIT 10 MINUTES IT WILL START. IT HAPPENED AGAIN TODAY MAKING ME LATE TO WORK AGAIN.
NHTSA ODI #10322378
85,000 miles · Mar 26, 2010
Electrical System
TURN SIGNAL ON 2001 CHEVY IMPALA WORKS INTERMITTENTLY. EXPENSIVE REPAIR. BLOG SITES HAVE MANY ENTRIES COMPLAINING OF THE SAME THING. THIS IS A SAFETY ISSUE IF MY TURN SIGNALS WORK ON AND OFF.
NHTSA ODI #10322361
146,705 miles · Mar 7, 2010
Electrical SystemEquipmentTires
I BOUGHT A 2001 CHEVY IMPALA 1 WEEK AGO AND NOW IT WILL NOT ACCELERATE OVER 30 MILES AN HOUR PLUS IT CUTS OFF WHEN IT REACHES THOSE MILES. I HAD NEW SPARK PLUGS INSTALLED, WIRES, COIL PACKS AND A NEW FUEL FILTER INSTALLED. *TR
NHTSA ODI #10317503
110,000 miles · Mar 1, 2010
Electrical SystemExterior LightingInterior LightingCrash
2000-2005 CHEVY IMPALAS EXPERIENCE FLICKERING INTERIOR LIGHTS AND EXTERIOR LIGHTS, FAULTY DASH GAUGES, NO SHIFTER SIGNS ON DASH, NO MANUAL INTERIOR LIGHTING OR EXTERIOR LIGHTS, NO CRANK OR START. WAS TOLD THAT A BAD BCM WAS THE PROBLEM. (BODY CONTROL MODULE) PART# GMAB166 IS VERY OLD FOR THE MAKE OF CAR THE IT WAS PUT IN. THERE …
Read full complaint
2000-2005 CHEVY IMPALAS EXPERIENCE FLICKERING INTERIOR LIGHTS AND EXTERIOR LIGHTS, FAULTY DASH GAUGES, NO SHIFTER SIGNS ON DASH, NO MANUAL INTERIOR LIGHTING OR EXTERIOR LIGHTS, NO CRANK OR START. WAS TOLD THAT A BAD BCM WAS THE PROBLEM. (BODY CONTROL MODULE) PART# GMAB166 IS VERY OLD FOR THE MAKE OF CAR THE IT WAS PUT IN. THERE IS A NHTSA BULLETIN OUT AND GM REFUSE TO FIX IT. BULLETIN $ 010603005 AND 110501. BECAUSE OF THIS HAZARD I CRASHED MY CAR INTO THE BACK OF ANOTHER GOING 65 MPH WHEN THE CAR JUST SUDDENLY STALLED AND THERE WASN'T ADEQUATE BRAKE PRESSURE TO STOP THE CAR. *TR
NHTSA ODI #10315038
144,000 miles · Jan 3, 2010
Electrical System
ON MY 201 IMPALA, THE TURN SIGNALS SOMETIME FAIL TO OPERATE - I HAVE FOUND THAT I CAN TURN ON THE EMERGENCY SIGNALS AND THEN DISENGAGE THEM TO RESTART NORMAL TURN SIGNALS. INSTRUMENT LIGHTS ALSO DIM AT TIMES MAKING IT IMPOSSIBLE TO READ SPEED OR ANY OTHER INSTRUMENTS - PROBLEMS DO NOT NECESSARILY OCCUR TOGETHER BUT CAN AND DO A…
Read full complaint
ON MY 201 IMPALA, THE TURN SIGNALS SOMETIME FAIL TO OPERATE - I HAVE FOUND THAT I CAN TURN ON THE EMERGENCY SIGNALS AND THEN DISENGAGE THEM TO RESTART NORMAL TURN SIGNALS. INSTRUMENT LIGHTS ALSO DIM AT TIMES MAKING IT IMPOSSIBLE TO READ SPEED OR ANY OTHER INSTRUMENTS - PROBLEMS DO NOT NECESSARILY OCCUR TOGETHER BUT CAN AND DO AT TIMES - RANDOM IN PROBLEM OCCURRENCE; MILEAGE APPROX 144,000. *TR
NHTSA ODI #10297873
127,000 miles · Jan 1, 2010
Electrical System
DASH AND INSTRUMENT LIGHTS DIM TO WHERE I CAN'T SEE WHAT SPEED I'M DOING WHILE DRIVING AT NIGHT. I CAN'T MANUALLY ADJUST THEM WITH HEADLIGHT KNOB WHEN THIS PROBLEM OCCURS MAKING FOR A VERY DANGEROUS SITUATION WHILE DRIVING AT NIGHT. *TR
NHTSA ODI #10297741
Mileage unknown · Dec 9, 2009
Electrical System
PASSLOCK SYSTEM FAILURE INTERMITTENTLY. CAR WILL NOT START FOR 10/15 MIN. I'VE BEEN STRANDED LATE AT NIGHT AND IN SOME BAD WEATHER. DEALERSHIP SAID THEY DON'T KNOW WHAT IT IS UNLESS THE PROBLEM HAPPENS AT THE GARAGE, OTHERWISE THEY DON'T KNOW WHAT THE PROBLEM IS. I'VE SPENT IN THE THOUSANDS OF DOLLARS. HAVE HAD BCM REPLACED, CYL…
Read full complaint
PASSLOCK SYSTEM FAILURE INTERMITTENTLY. CAR WILL NOT START FOR 10/15 MIN. I'VE BEEN STRANDED LATE AT NIGHT AND IN SOME BAD WEATHER. DEALERSHIP SAID THEY DON'T KNOW WHAT IT IS UNLESS THE PROBLEM HAPPENS AT THE GARAGE, OTHERWISE THEY DON'T KNOW WHAT THE PROBLEM IS. I'VE SPENT IN THE THOUSANDS OF DOLLARS. HAVE HAD BCM REPLACED, CYLINDERS AND SENSORS REPLACED. STILL DOESN'T WORK. DEALERSHIP SAID THEY DON'T KNOW WHAT THE PROBLEM IS. THERE ARE MANY COMPLAINTS ON THIS PROBLEM. (SEE CARCOMPLAINTS.COM AND LOOK UNDER ELECTRICAL PROBLEMS). *TR
NHTSA ODI #10295114
150,000 miles · Dec 4, 2009
Electrical System
TL*THE CONTACT OWNS A 2001 CHEVY IMPALA. WHILE DRIVING THE PASS LOCK SYSTEM LIGHT BEGAN FLASHING. WHEN THE PASS LOCK SYSTEM LIGHT FLASHED THE RADIO TURNS OFF, THE DOORS LOCKS, THE DOME LIGHT FLASHED ON AND OFF, THE TRUCK LID OPENS, AND SOMETIMES THE VEHICLE WILL SHUT OFF AND WILL NOT RESTART. THE FUSE MUST BE REMOVED IN ORDER TO…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVY IMPALA. WHILE DRIVING THE PASS LOCK SYSTEM LIGHT BEGAN FLASHING. WHEN THE PASS LOCK SYSTEM LIGHT FLASHED THE RADIO TURNS OFF, THE DOORS LOCKS, THE DOME LIGHT FLASHED ON AND OFF, THE TRUCK LID OPENS, AND SOMETIMES THE VEHICLE WILL SHUT OFF AND WILL NOT RESTART. THE FUSE MUST BE REMOVED IN ORDER TO RESTART THE VEHICLE. THE FAILURE IS CURRENTLY CAUSING THE HEADLIGHTS TO SHUT OFF INTERMITTENTLY WHILE DRIVING. THE MANUFACTURER INFORMED THE CONTACT THAT THEY WERE UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE CONTACT IS CONCERNED ABOUT THE SAFETY RISK SINCE A CRASH COULD OCCUR DUE TO THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 150,000.
NHTSA ODI #10294494
173,000 miles · Oct 29, 2009
Electrical System
I HAVE A 2001 CHEVROLET IMPALA SEDAN. WITHOUT WARNING THE TURN SIGNALS STOP WORKING. IF I STOP THE CAR AND RESTART IT, THE SIGNALS USUALLY START WORKING AGAIN, BUT FOR HOW LONG? THE MILEAGE IS 175,000. I WENT ONLINE AND FOUND THAT GM HAS IDENTIFIED THAT THE HAZARD SWITCH IS THE ROOT CAUSE. THIS SWITCH IS THE SAME SWITCH ON SEVE…
Read full complaint
I HAVE A 2001 CHEVROLET IMPALA SEDAN. WITHOUT WARNING THE TURN SIGNALS STOP WORKING. IF I STOP THE CAR AND RESTART IT, THE SIGNALS USUALLY START WORKING AGAIN, BUT FOR HOW LONG? THE MILEAGE IS 175,000. I WENT ONLINE AND FOUND THAT GM HAS IDENTIFIED THAT THE HAZARD SWITCH IS THE ROOT CAUSE. THIS SWITCH IS THE SAME SWITCH ON SEVERAL MODELS. I WENT TO CHANDLER CHEVROLET IN TAPPAHANNOCK , VA .GM WILL REPLACE THE HAZARD SWITCH ON THE 2001 MALIBU (THIS IS THE SAME SWITCH THAT IS IN MY CAR). THEN THE SERVICE MANAGER SAID UP TO 150,000 MILES. NHTSA INVESTIGATION #PEO2064 MY OTHER PROBLEM IS THAT I HAVE EXPERIENCED RIGHT REAR STOP LIGHT FAILURE. HOWEVER THE RUNNING TAIL LIGHT DOES WORK. AT FIRST THE SHOP WHERE I TOOK IT, REYNOLDS GARAGE IN OTTOMAN, VA FIGURED IT WAS A BURNED OUT STOP LIGHT ELEMENT. REPLACING THE BULB DID NOT BRING THE STOP LIGHT BACK INTO SERVICE. THEN WE REPLACED THE SECTION OF WIRING HARNESS. STILL NO LUCK. I LEFT THE CAR AT THE SHOP AND MR. REYNOLDS SPENT A LOT OF TIME ON IT W/O SOLVING THE PROBLEM. I WONDER IF THIS RIGHT REAR STOP LIGHT PROBLEM IS RELATED TO THE FAILED HAZARD SWITCH AND ITS WEAK SOLDER JOINTS. THANK YOU FOR LISTENING. *TR WILLIAM E. STEINMETZ
NHTSA ODI #10290197
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 29, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence & remedy
Consequence: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration