ON APPROXIMATELY JULY 5, 2006 I HEARD A NOISE COMING FROM THE LEFT FRONT OF MY 1991 BUICK REGAL [XXX]. AS I AM A CERTIFIED MECHANIC, I REMOVED THE WHEEL AND TIRE IN ORDER TO INSPECT THE FRONT END COMPONENTS FOR A PROBLEM. I FOUND THAT THE STEEL WHEEL HAD A LARGE CRACK THAT WRAPPED ABOUT TWO THIRDS OF THE AREA AROUND THE LUG HO…
Read full complaint
ON APPROXIMATELY JULY 5, 2006 I HEARD A NOISE COMING FROM THE LEFT FRONT OF MY 1991 BUICK REGAL [XXX]. AS I AM A CERTIFIED MECHANIC, I REMOVED THE WHEEL AND TIRE IN ORDER TO INSPECT THE FRONT END COMPONENTS FOR A PROBLEM. I FOUND THAT THE STEEL WHEEL HAD A LARGE CRACK THAT WRAPPED ABOUT TWO THIRDS OF THE AREA AROUND THE LUG HOLES. THIS CRACK APPEARED TO BE CAUSED BY METAL FATIGUE. I THEN REMOVED THE OTHER WHEELS ON THE VEHICLE AND FOUND SMALLER CRACKS AROUND TWO OF THE REMAINING THREE WHEELS. I REPORTED THE PROBLEM TO BOTH GENERAL MOTORS AND MY DEALERSHIP. THIS VEHICLE WAS ORIGINALLY PURCHASED BY MY WIFE AND HAS NEVER BEEN ABUSED OR WRECKED. SINCE THERE ARE MANY THOUSANDS OF VEHICLES WHICH ARE USING THESE WHEELS, I FEEL THAT THERE IS A SIGNIFICANT SAFETY RISK WITH ALL VEHICLES USING THESE WHEELS. I HAVE PHOTOGRAPHED THESE CRACKS FOR RECORD KEEPING PURPOSES, AND I WILL BE HAPPY TO SEND THEM IN WITH THIS COMPLAINT. THIS COULD BE THE BEGINNING OF A REAL PROBLEM AND PEOPLE COULD BE SERIOUSLY INJURED. *NM UPDATED 07/12/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10162842
Mileage unknown · Feb 10, 2004
Wheels
WHILE DRIVING THE CONSUMER'S LEFT REAR TIRE FELL OFF. THE TIRE TRAVELED OVER THE MEDIAN WALL AND STRUCK A MOVING VEHICLE (OHIO TRAFFIC CRASH REPORT). *PH *NM
NHTSA ODI #10057808
86,419 miles · Jun 26, 2003
Wheels
THE RIM WHICH HELD THE DRIVERS SIDE TIRE, CRACKED. THE CONSUMER STATED TWO YEARS AGO THE FRONT PASSENGER SIDE CRACKED. CAUSE WAS UNKNOWN. *TS *JB
NHTSA ODI #10004461
Mileage unknown · Feb 14, 2000
Wheels
ALUMINUM ALLOY WHEELS ARE EXPERIENCING CRACKS AROUND THE WHOLE WHEEL; 3 OUT OF 4 WERE NOTICED. WHEELS ARE AVAILABLE FOR INSPECTION IF NEEDED. DEALER NOTIFIED. *AK *ML
NHTSA ODI #856863
Mileage unknown · Aug 7, 1996
Wheels
DRIVER/PASS. FRONT STEEL WHEEL RIM MOUNTINGS HAVE DEVELOPED CRACKS. *AK
NHTSA ODI #800623
Mileage unknown · Aug 6, 1996
Service Brakes, HydraulicWheels
VEHICLES REAR DISC CALIPER LINKAGES HAD TO BE REPLACED 3 TIMES DUE TO FREEZING.THIS IS CAUSING EXCESSIVE WEAR AND TEAR ON REAR BRAKES.THERE IS NO FORWARNING NOISE AND OR LIGHTS INDICATING THIS FAILURE.*AK
NHTSA ODI #800526
Mileage unknown · Apr 5, 1995
Wheels
ALL FOUR WHEEL RIMS WERE CRACKED, CAUSING LOUD NOISES WHEN TURNING STEERING WHEEL. *SKD
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, WHERE ROAD SALT USE IS HEAVY. A CONDITION WHERE ONE OR BOTH FRONT ENGINE CRADLE BOLTS CAN PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINERS.
Consequence & remedy
Consequence: IF BOTH BOLTS PULL THROUGH, THE FRONT OF THE CRADLE WOULD NO LONGER BE SUPPORTED AT THE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT COULD SEPARATE FROM THE STEERING GEAR.
Remedy: DEALERS WILL REPLACE THE FRONT AND REAR FRAME/CRADLE BOLTS AND RETAINERS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT AND WISCONSIN. THE REAR CRADLE BOLTS PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINER. IF BOTH BOLTS PULL THROUGH, THE REAR CRADLE WOULD NOT LONGER BE SUPPORTED AT THESE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT CAN SEPARATE FROM THE STEERING GEAR.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A VEHICLE CRASH COULD RESULT.
Remedy: DEALERS WILL REPLACE THE REAR CRADLE BOLTS AND RETAINERS.
INCORRECT CLEAR FRONT SIDE MARKER BULBS WERE INSTALLED RATHER THAN AMBER BULBS. THIS DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: DURING ILLUMINATION, THE BULBS WILL SHOW CLEAR RATHER THAN AMBER AND COULD MOMENTARILY CONFUSE OTHER DRIVERS.
Remedy: DEALERS WILL REPLACE THE CLEAR BULBS WITH THE CORRECT AMBER BULBS.
FRONT SHOULDER SAFETY BELT WEBBING MAY SEPARATE AT FRONT BELT UPPER GUIDE LOOPS ON EITHER SIDE OF THE FRONT SEAT.
Consequence & remedy
Consequence: WEBBING SEPARATION COULD OCCUR WITHOUT PRIOR WARNING ANDINCREASE THE RISK OF INJURY TO BELTED FRONT OUTBOARD OCCUPANTS IN A HIGH ENERGYCRASH.
Remedy: INSTALL A CONTROLLED ROTATION BRACKET ON DRIVER AND PASSENGER SIDE FRONT SEAT BELT GUIDE LOOPS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
10
RP01001 · Structure
Opened Nov 28, 2001 · Closed Jun 13, 2002
Status: closed (inferred from source dates) · Structure
There is no summary currently available
EA00011 · Engine Cradle Separation
Opened Apr 10, 2000 · Closed Jan 12, 2001
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE ENGINE CRADLE FRONT BOLTS AND/OR RETAINERS MAY FAIL, ALLOWING THE FRONT OF THE ENGINE CRADLE TO FALL, POSSIBLY SEPARATING THE STEERING INTERMEDIATE SHAFT FROM THE STEERING GEAR, WITH COMPLETE LOSS OF STEERING CONTROL
RQ99002 · Engine Cradle Separation
Opened Mar 4, 1999 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine
ON APRIL 1, 1997, GENERAL MOTORS CORPORATION FILED A DEFECT INFORMATION REPORT TO RECALL THE SUBJECT VEHICLES, REGISTERED IN 14 HIGH CORROSION STATES, TO REPLACE THE REAR ENGINE CRADLE BOLTS AND RETAINERS.THE REAR ENGINE CRADLE BOLTS WOULD EITHER FRACTURER OR PULL THROUGH THE RETIANERS DUE TO CORROSION.AS OF SEPTEMBER 1998, THE SIXTH QUARTER, 59.3% OF THE SUBJECT VEHICLES HAD BEEN REPAIRED.IN ADDITION TO THE COMPLAINTS OF FRONT ENGINE CRADLE BOLT FAILURES IN THE ABOVE FAILURE REPORT SUMMARY, ODI HAS RECEIVED SIX REPORTS OF POSSIBLE FRONT ENGINE CRADLE BOLT FAILURES, INCLUDING TWO CRASHES.AN RQ IS WARRANTED TO DETERMINE THE EXTENT OF FAILURES OF THE FRONT ENGINE CRADLE BOLTS AND RETAINERS ON THE SUBJECT VEHICLES.
RQ97017 · Cradle Bolt Failures
Opened Oct 2, 1997 · No close date supplied
Status: open (inferred from source dates) · Structure
There is no summary currently available
PE94063 · Corroded Rear Disk Brakes
Opened Aug 12, 1994 · Closed Dec 21, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE94048 · SUB-FRAME Absorber Failure
Opened Jun 21, 1994 · Closed Dec 30, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE93039 · Fuel Line Separation
Opened Apr 27, 1993 · Closed Sep 14, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA92024 · Sticking Throttle
Opened Jun 26, 1992 · Closed Jan 31, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA91049 · Jack Failure
Opened Nov 26, 1991 · Closed Oct 28, 1992
Status: closed (inferred from source dates) · Equipment
===
PE91072 · Steering Wheel Separation
Opened May 1, 1991 · Closed Jul 8, 1991
Status: closed (inferred from source dates) · Steering
There is no summary currently available
1991 Buick Regal Problems, Complaints & Recalls | Skip That Year
Illustration