NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
263 reports86,000 miles · Mar 15, 2018
EnginePower Train
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE OPERATING THE VEHICLE, THE TEMPERATURE GAUGE INDICATED THAT THE ENGINE HAD OVERHEATED. UPON INSPECTION, IT WAS DISCOVERED THAT HOT WATER HAD LEAKED FROM THE ENGINE AREA. THE VEHICLE WAS TOWED TO THE LOCAL DEALER (UNITED BMW, 11458 ALPHARETTA HWY, ROSWELL GA) WHERE IT WAS DIAGNOSED THAT T…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE OPERATING THE VEHICLE, THE TEMPERATURE GAUGE INDICATED THAT THE ENGINE HAD OVERHEATED. UPON INSPECTION, IT WAS DISCOVERED THAT HOT WATER HAD LEAKED FROM THE ENGINE AREA. THE VEHICLE WAS TOWED TO THE LOCAL DEALER (UNITED BMW, 11458 ALPHARETTA HWY, ROSWELL GA) WHERE IT WAS DIAGNOSED THAT THE WATER PUMP AND THERMOSTAT HAD FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT WHILE LEAVING THE DEALER, THE VEHICLE BEGAN TO VIOLENTLY SHAKE AND RATTLE. THE VEHICLE WAS TOWED BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DRIVE SHAFT AND TRANSFER CASE FAILED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 86,000.
NHTSA ODI #11079553
69,000 miles · Feb 14, 2018
EnginePower Train
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING 35 MPH, THE CONTACT SMELLED A BURNING ODOR FROM THE AIR CONDITIONING VENTS, AND THE VEHICLE STALLED AND COULD NOT BE RESTARTED. THERE WERE NO WARNING INDICATORS ILLUMINATED BEFORE THE FAILURE. THE VEHICLE WAS TOWED TO THE DEALER (BMW OF TULSA, 9702 S MEMORIAL DR, TULSA, OK 74133)…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING 35 MPH, THE CONTACT SMELLED A BURNING ODOR FROM THE AIR CONDITIONING VENTS, AND THE VEHICLE STALLED AND COULD NOT BE RESTARTED. THERE WERE NO WARNING INDICATORS ILLUMINATED BEFORE THE FAILURE. THE VEHICLE WAS TOWED TO THE DEALER (BMW OF TULSA, 9702 S MEMORIAL DR, TULSA, OK 74133), BUT THE CAUSE OF THE FAILURE COULD NOT BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE MANUFACTURER WAS WILLING TO PAY HALF FOR A REPLACEMENT ENGINE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND CONFIRMED WITH THE CONTACT THAT THEY WOULD PAY HALF OF THE COST FOR A REPLACEMENT ENGINE. THE MANUFACTURER OPENED A CASE. THE FAILURE MILEAGE WAS 69,000.
NHTSA ODI #11072881
40,000 miles · Dec 18, 2017
Engine
INTAKE AND EXHAUST VALVE SEALS WENT BAD. WHICH THIS IS A KNOWN PROBLEM FOR N63 ENGINES. BMW HAS A BULLETIN FOR IT, BUT THE EXTENDED WARRANTY WILL NOT HONOR THAT BECAUSE IT'S A KNOWN PROBLEM. AND BMW WON'T HONOR IT CAUSE THEY WON'T DO A RECALL ON IT EITHER. WHEN THIS HAPPENS, IT CONSUMES OIL AND YOU HAVE BLUE SMOKE GOING OUT YOUR…
Read full complaint
INTAKE AND EXHAUST VALVE SEALS WENT BAD. WHICH THIS IS A KNOWN PROBLEM FOR N63 ENGINES. BMW HAS A BULLETIN FOR IT, BUT THE EXTENDED WARRANTY WILL NOT HONOR THAT BECAUSE IT'S A KNOWN PROBLEM. AND BMW WON'T HONOR IT CAUSE THEY WON'T DO A RECALL ON IT EITHER. WHEN THIS HAPPENS, IT CONSUMES OIL AND YOU HAVE BLUE SMOKE GOING OUT YOUR TAILPIPE. I'VE BEEN GOING BACK AND FORTH WITH EXTENDED WARRANTY, BMW DEALER, AND BMW CORPORATION. THEY WANT ME TO PAY OVER $9000 TO FIX THIS, CAUSE YOU HAVE TO PULL THE MOTOR OUT. AND THIS GONNA GET WORSE IF YOU GONNA KEEP DRIVING IT
NHTSA ODI #11055291
Mileage unknown · Dec 17, 2017
Engine
VALVE SEALS PROBLEMS IN 90 % OF X5 FROM 2010 TO 2013, I BOUGHT MINES FROM THE DEALER WITH THIS PROBLEM... THEY TOLD ME AT THE DEALER NOTHING WAS WRONG.... I AM VERY UPSET ABOUT THIS. *TR
NHTSA ODI #11055121
53,000 miles · Dec 12, 2017
Engine
SINCE THE N63 ENGINE TECHNICAL UPDATE (AKA N63 CUSTOMER CARE PACKAGE) WAS PERFORMED ON OUR 2011 X5, WE NOTICED AN INCREASE IN ENGINE OIL CONSUMPTION EVIDENCED BY THE ONBOARD SYSTEM ALERTING US TO LOW ENGINE OIL CONDITION REQUIRING ADDING ENGINE OIL. IN ADDITION TO THIS SYMPTOM THE ONBOARD SYSTEM IS ALERTING LOW COOLANT FLUID AND…
Read full complaint
SINCE THE N63 ENGINE TECHNICAL UPDATE (AKA N63 CUSTOMER CARE PACKAGE) WAS PERFORMED ON OUR 2011 X5, WE NOTICED AN INCREASE IN ENGINE OIL CONSUMPTION EVIDENCED BY THE ONBOARD SYSTEM ALERTING US TO LOW ENGINE OIL CONDITION REQUIRING ADDING ENGINE OIL. IN ADDITION TO THIS SYMPTOM THE ONBOARD SYSTEM IS ALERTING LOW COOLANT FLUID AND REQUIRING COOLANT FLUID TOP OFF. PRIOR TO THIS N63 TECHNICAL UPDATE PERFORMED ON OUR X5, THE VEHICLE DID NOT REQUIRE ENGINE OIL OR COOLANT FLUID TOP OFF AS IT DOES NOW AND WENT EVEN AS FAR AS BETWEEN MAINTENANCE CYCLE WITHOUT REQUIRING OIL OR COOLANT TOP OFF. WE HAVE COMMUNICATED THIS PECULIAR LEVEL OF CONSUMPTION ON A NUMBER OF OCCASIONS TO THE SERVICE ADVISOR AT THE ONSET OF THE SYMPTOM AND WHILE DURING THE WARRANTY COVERAGE PERIOD AND WE WERE TOLD THAT THIS CONSUMPTION BY THE N63 ENGINE IS NORMAL AND IS TO BE EXPECTED AND TO TOP IT OFF WHEN LOW AND AS REQUIRED. AS SUCH IN ITS CURRENT STATE WE ARE NOT CONFIDENT WITH DRIVING OUR X5 ON LONG DISTANCE LIKE A ROAD TRIP FROM LA TO SF WHICH WE HAVE ENJOYED - THE N63 IS EXTREMELY NEEDY FOR FLUIDS BETWEEN RELATIVELY SHORT MILEAGE INTERVALS.
NHTSA ODI #11054248
78,000 miles · Dec 10, 2017
Electrical System
WIRES INSIDE THE COMFORT ACCESS DOOR HANDLES HAVE APPARENTLY SHORTED OUT AND ARE CAUSING THE DRIVER SIDE REAR DOOR HANDLE TO BE VERY HOT TO THE TOUCH (MEASURED AT 134 DEG F). PEMBROKE PINES BMW AND BMW NA WERE NOTIFIED IN NOVEMBER. THEY ADVISED THAT I WOULD HAVE PAY $700 TO HAVE IT REPLACED SINCE IT WAS OUT OF WARRANTY. LATER …
Read full complaint
WIRES INSIDE THE COMFORT ACCESS DOOR HANDLES HAVE APPARENTLY SHORTED OUT AND ARE CAUSING THE DRIVER SIDE REAR DOOR HANDLE TO BE VERY HOT TO THE TOUCH (MEASURED AT 134 DEG F). PEMBROKE PINES BMW AND BMW NA WERE NOTIFIED IN NOVEMBER. THEY ADVISED THAT I WOULD HAVE PAY $700 TO HAVE IT REPLACED SINCE IT WAS OUT OF WARRANTY. LATER THEY OFFERED A 20% DISCOUNT. AN INTERNET SEARCH REVEALED IT IS A COMMON PROBLEM. I AM CONCERNED THAT THE SHORT MAY EVENTUALLY CAUSE THE WIRES OR OTHER MATERIALS IN THE DOOR TO CATCH ON FIRE. I MEASURED AND PHOTOGRAPHED THE DOOR HANDLE AND ADJACENT AREA. THE DOOR WAS 84.8 DEGREES F WHILE THE DOOR HANDLE WAS 134 DEGREES F.
NHTSA ODI #11053737
69,000 miles · Nov 15, 2017
Power Train
I NOTICE WHEN TURNING A VIBRATION OR SHUDDER COMING FROM THE FRONT OF THE VEHICLE. DOING SOME ONLINE RESEARCH, INCLUDING THE NHTSA SITE, I FIND THAT THIS IS A COMMON PROBLEM FOR X5S. THE APPARENT FIX FOR THIS IS TO REPLACE THE TRANSFER CASE, A SEVERAL THOUSAND DOLLAR REPAIR. I BOUGHT THIS FOR MY WIFE BUT I WOULD NOT HAVE HER DRI…
Read full complaint
I NOTICE WHEN TURNING A VIBRATION OR SHUDDER COMING FROM THE FRONT OF THE VEHICLE. DOING SOME ONLINE RESEARCH, INCLUDING THE NHTSA SITE, I FIND THAT THIS IS A COMMON PROBLEM FOR X5S. THE APPARENT FIX FOR THIS IS TO REPLACE THE TRANSFER CASE, A SEVERAL THOUSAND DOLLAR REPAIR. I BOUGHT THIS FOR MY WIFE BUT I WOULD NOT HAVE HER DRIVE IT BECAUSE BETWEEN THE TRANSFER CASE AND THE DRIVESHAFT, BOTH KNOWN ISSUES, I AM CONCERNED FOR HER SAFETY. MY VEHICLE ONLY HAS 69,000 MILES ON IT, THERE IS NO WAY IT SHOULD HAVE THESE KIND OF PROBLEMS BARRING A VERY POOR DESIGN.
NHTSA ODI #11046296
56,000 miles · Nov 6, 2017
Unknown Or OtherFire
MY WIFE'S BMW WAS PARKED IN OUR GARAGE UPON RETURNING FROM THE DEALERSHIP WHERE A SERVICE RECALL HAD BEEN PERFORMED. THE CAR SELF COMBUSTED DESTROYING THE BMW X5 , MY BMW 328 XI, OUR GARAGE AND PORTIONS OF OUR CONDO ADJACENT TO THE GARAGE.
NHTSA ODI #11043735
Mileage unknown · Nov 2, 2017
Air Bags
TAKATA RECALL I HAVE RECEIVED TWO NOTICES CONCERNING THIS SITUATION OVER A YEAR PERIOD, WHEN I CONTACTED BMW OF MANHATTAN AFTER THE FIRST NOTICE THEY SAID THEY WOULD CONTACT ME ONCE PARTS ARE RECEIVED. IT'S BEEN WELL OVER A YEAR NOW AND I HAVE RECEIVED YET ANOTHER NOTICE, STILL NO REPLACEMENT OF NEW AIRBAGS.
NHTSA ODI #11042279
Mileage unknown · Oct 29, 2017
Air Bags
TAKATA RECALL: I CALLED THE WAYNE, NJ BMW DEALERSHIP MULTIPLE TIMES TO REPLACE THE AFFECTED TAKATA INFLATORS AIRBAGS. WAYNE BMW DEALERSHIP STATED THEY WERE UNABLE TO REPLACE TAKATA INFLATORS AIRBAGS.
NHTSA ODI #11040960
Official recalls
14Oct 20, 2023
BMW of North America, LLC (BMW) is recalling certain 2010-2012 1 Series Coupe, 1 Series Convertible, 3 Series Sedan, 3 Series Convertible, 2010-2011 3 Series Sportswagon, 3 Series Coupe, 5 Series Sedan, X3 xDrive 28i, X3 xDrive 30i, X5 xDrive30i, and Z4 sDrive30i vehicles. The aluminum bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and possibly break.
Consequence & remedy
Consequence: Loose or broken VANOS unit bolts can result in an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the four VANOS bolts, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed December 18, 2023. Owner notification letters were mailed June 19, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2009-2012 X5 xDrive35d, 2008-2012 X6 xDrive35i, X6 xDrive50i and X6 M, 2007-2012 X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M and 2010-2011 X6 ActiveHybrid vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSPI-2) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until this remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag, free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 14, 2019
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, 2008-2014 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, 2009-2013 X5 xDrive35d vehicles and 2010-2011 X6 ActiveHybrid vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
May 23, 2018
BMW of North America, LLC (BMW) is recalling certain 2009-2013 X5 xDrive 35d diesel vehicles. The engine idler pulley bolt may loosen over time and break.
Consequence & remedy
Consequence: If the idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the idler pulley bolt with an improved part, free of charge. The recall began March 11, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Apr 18, 2018
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence & remedy
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Engine And Engine Cooling:engine
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Jan 9, 2018
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, 2009-2010 X5 xDrive35d vehicles and 2009-2013 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." BMW is also recalling certain 2007-2010 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." BMW is also recalling certain 2007-2009 X5 xDrive30i, X5 xdrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag module, free of charge. The recall is expected to begin March 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
Mar 2, 2017
BMW of North America, LLC, (BMW) is recalling certain 2011-2013 X5 xDrive35i, X5 xDrive50i, X5 M and X5 xDrive35d vehicles, 2011-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles, and 2011 x6 ActiveHybrid Vehicles. Water and debris may enter the front driveshaft's universal joint, causing excessive wear and possibly resulting in the joint's failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on April 18, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Oct 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
Consequence & remedy
Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 25, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, 2009-2011 X5 xDrive35d vehicles, 2008-2011 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, and 2010-2011 X6 ActiveHybrid vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain model year 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, and 2008 BMW X6 xDrive35i, X6 xDrive50i and X6 M vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger frontal air bag inflator or air bag module, free of charge. The recall began July 28, 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2011 X5 xDrive 35i, xDrive50i, X5 M, X6 xDrive35i, X6 xDrive50i, and X6 M vehicles manufactured April 5, 2010, to November 20, 2010, 2011 X5 xDrive35d diesel vehicles manufactured April 7, 2010, to November 20, 2010, and 2011 X6 Active Hybrid vehicles manufactured April 15, 2010, to November 17, 2010. The affected vehicles have a front driveshaft universal joint that may not seal out water and debris from getting in and damaging the joint, which could lead to its failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on July 8, 2016. Owners may contact BMW customer service at 1-800-525-7417.
Oct 20, 2011
BMW IS RECALLING CERTAIN MODEL YEAR 2011 5-SERIES, MODEL YEAR 2010-2011 5-SERIES GRAN TURISMO, MODEL YEAR 2009-2011 7-SERIES, MODEL YEAR 2010-2011 X5 SAV, AND MODEL YEAR 2008-2011 X6 SAV VEHICLES EQUIPPED WITH 8- OR 12-CYLINDER, TURBOCHARGED, ENGINES BECAUSE THE CIRCUIT BOARD FOR THE ELECTRIC AUXILIARY WATER PUMP CAN OVERHEAT.
Consequence & remedy
Consequence: THIS COULD LEAD TO A SMOLDERING OF THE PUMP OR AN ENGINE COMPARTMENT OR VEHICLE FIRE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE AUXILIARY WATER PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 19, 2011. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Jun 2, 2010
BMW IS RECALLING CERTAIN MODEL YEAR 2011 X5 SAV AND X6 SAV PASSENGER VEHICLES MANUFACTURED FROM APRIL 1 THROUGH MAY 8, 2010. THE TIRE LABEL DOES NOT CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE VEHICLES ARE EQUIPPED WITH 20-INCH WHEELS, BUT THE LABEL STATES THAT THE VEHICLES WERE EQUIPPED WITH 19-INCH WHEELS AND THE STATED TIRE PRESSURE IS INCORRECT FOR THE EQUIPPED WHEELS.
Consequence & remedy
Consequence: IMPROPER TIRE INFLATION CAN RESULT IN PREMATURE TIRE FAILURE OR REDUCED VEHICLE HANDLING PERFORMANCE, EITHER OF WHICH CAN INCREASE THE RISK OF A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND PROVIDE CORRECT LABELS FREE OF CHARGE. THE OWNER WILL HAVE THE OPTION TO AFFIX THE LABEL THEMSELVES OR THEY MAY TAKE THEIR VEHICLE TO A BMW DEALER WHO WILL AFFIX THE LABEL FOR THEM AT NO COST. THE SAFETY RECALL BEGAN ON OCTOBER 8, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration