NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
110 reportsClear category filterMileage unknown · May 9, 2026
Engine
There's currently an open recall for a number of BMW engines involving aluminum bolts in the vanos assembly that shear, strip, and break off completely. The open recall is somehow excluding some vehicles with the same exact problem like my 2011 BMW X5 xdrive35i N55 E70 with the inline 6. Currently my vanos bolts are already shea…
Read full complaint
There's currently an open recall for a number of BMW engines involving aluminum bolts in the vanos assembly that shear, strip, and break off completely. The open recall is somehow excluding some vehicles with the same exact problem like my 2011 BMW X5 xdrive35i N55 E70 with the inline 6. Currently my vanos bolts are already sheared off and sitting in my oil pan. My vehicle started misfiring and acting strange while I was traveling at 75mph, luckily I made it into a gas station and had to have it towed from there because it wouldn't start again and hasn't since. BMW knows about these hazardous bolts and chose to not repair some of them directly endangering drivers and their families. My local BMW dealership won't even confirm that the bolts in my oil pan are the vanos bolts even after I showed them photographic evidence which I still have. I've spoken with BMW North America and they said I need to get it confirmed by my local dealership, so where dies that leave me? Here...over $8,000 in damage/loss from an obvious manufacturer error that THEY ARE AWARE OF!
NHTSA ODI #11736796
132,000 miles · May 27, 2025
Electrical SystemEngine
The contact owns a 2011 BMW X5. The contact stated that the vehicle failed to start. The vehicle was towed to an unknown dealer but was not diagnosed or repaired. The dealer informed the contact that the VIN was not under recall. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The fai…
Read full complaint
The contact owns a 2011 BMW X5. The contact stated that the vehicle failed to start. The vehicle was towed to an unknown dealer but was not diagnosed or repaired. The dealer informed the contact that the VIN was not under recall. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 132,000.
NHTSA ODI #11663129
Mileage unknown · Feb 12, 2025
Engine
EGR failure where the diesel emissions come into the cabin via the hvac system Dealer said the EGR cooler needs to be replaced. This is a know problem and recall on the 2012 and 2013. This makes the fumes to the driver when first driving the car in the morning dangerous as carbon monoxide and diesel exhaust enter the car. My…
Read full complaint
EGR failure where the diesel emissions come into the cabin via the hvac system Dealer said the EGR cooler needs to be replaced. This is a know problem and recall on the 2012 and 2013. This makes the fumes to the driver when first driving the car in the morning dangerous as carbon monoxide and diesel exhaust enter the car. My friend has an exact similar problem and this issue is known on all the BMW boards
NHTSA ODI #11642373
Mileage unknown · Jan 24, 2024
EngineFuel/propulsion SystemPower Train
I own a 2011 BMW x5. The NHTSA shows 15 recalls for my vehicle type; however, NHTSA must be relying upon BMW for the VIN numbers as: 1.) my vehicle doesn't show up for recalls; 2.) I have never been contacted by BMW for many of those recalls - in fact, I have not received a letter from BMW in many many years, and among the 15 r…
Read full complaint
I own a 2011 BMW x5. The NHTSA shows 15 recalls for my vehicle type; however, NHTSA must be relying upon BMW for the VIN numbers as: 1.) my vehicle doesn't show up for recalls; 2.) I have never been contacted by BMW for many of those recalls - in fact, I have not received a letter from BMW in many many years, and among the 15 recalls above, I have never received any notification of for at least October 20, 2023 NHTSA CAMPAIGN NUMBER: 23V707000 Camshaft Timing Bolts May Loosen Causing Stall Loose or broken VANOS unit bolts can result in an engine stall, increasing the risk of a crash. April 18, 2018 NHTSA CAMPAIGN NUMBER: 18V248000 Electric Auxiliary Water Pump Failure October 30, 2017 NHTSA CAMPAIGN NUMBER: 17V683000 PCV Heater may Short Circuit March 2, 2017 NHTSA CAMPAIGN NUMBER: 17V138000 Front Driveshaft Universal Joint may Fail May 17, 2016 NHTSA CAMPAIGN NUMBER: 16V311000 Front Driveshaft Universal Joint may Fail. When I call BMW, they say there are no recalls outstanding on my vehicle and this NHTSA states there are recalls, but does not associate my VIN with the recalls, so say there are no recalls outstanding. The most prominent recent issue was that when my BMW dealership diagnosed a check engine light in my vehicle, they wanted to replace a SCR DEF active tank for $3,000, but it turned out that BMW had an almost 100% failure rate for the same part and issued an extended warranty for this part under their technical bulletin SI B01 23 16. They denied replacing the parts under the warranty stating that it was limited to 10 years/120,000 miles. I had only 101,600 miles on my car, but they stated the 10 year limited out the warranty from the in-service date. However, my car had many emission system related issues including just a few years previous.
NHTSA ODI #11567475
Mileage unknown · Jan 15, 2024
Engine
After BMW replaced my battery on 1/11/24, a check engine light immediately appeared. It said that the Scr Active Tank needed to be replaced and it would cost upwards of $3,000. I immediately found a NHTSA bulletin that informed that this particular part had been on recall, but had a 10 year/120k mile limitation. My car only h…
Read full complaint
After BMW replaced my battery on 1/11/24, a check engine light immediately appeared. It said that the Scr Active Tank needed to be replaced and it would cost upwards of $3,000. I immediately found a NHTSA bulletin that informed that this particular part had been on recall, but had a 10 year/120k mile limitation. My car only had 101k miles, but BMW denied my recall work on goodwill because they say it was well past 10 years of my in-service date. The warranty, however, should still be effective, as many customers have different rates of utilization and I am still 19k short of the mileage limitation, which should not be time limited. BMW worked with the NHTSA for a reason - they acknowledged that they had a flawed part, and this needs to be changed at their expense, not passed on as $3,000 unfairly to the customer. Please see the recall bulletin attached.
NHTSA ODI #11565609
107,000 miles · Oct 18, 2023
Engine
The contact owns a 2011 BMW X5. The contact stated that while stopped at a stop sign, the vehicle unexpectedly turned off and independently shifted into neutral. The “Engine Failure - Reduced Power” message was displayed. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the failure …
Read full complaint
The contact owns a 2011 BMW X5. The contact stated that while stopped at a stop sign, the vehicle unexpectedly turned off and independently shifted into neutral. The “Engine Failure - Reduced Power” message was displayed. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the failure was due to a faulty variable valve timing system. The vehicle had not been repaired. The manufacturer was made aware of the failure and determined that the VIN was not included in a recall. The failure mileage was approximately 107,000.
NHTSA ODI #11550652
Mileage unknown · Sep 22, 2023
Engine
Passport BMW told us that there was a recall on the engine of our X5 and asked if we had to add oil periodically; our answer was yes. We were told that the engine failed the oil consumption test performed by Passport BMW and the engine needed to be replaced. Passport then said that we had to pay for the replacement of the engi…
Read full complaint
Passport BMW told us that there was a recall on the engine of our X5 and asked if we had to add oil periodically; our answer was yes. We were told that the engine failed the oil consumption test performed by Passport BMW and the engine needed to be replaced. Passport then said that we had to pay for the replacement of the engine, $2,500. The engine has been replaced, however the engine still leaks oil and now also leaks antifreeze additionally, engine malfunction is displayed permanently on the dashboard.
NHTSA ODI #11545979
Mileage unknown · Sep 9, 2022
Electrical SystemEngineSteering
I was driving to work one morning On the highway, when I suddenly heard a loud sharp noise from the engine bay that followed with the engine and battery lights turning blinking on my display with sudden loss of steering. I panicked but quickly put my vehicle into neutral with my hazard lights on and slowly hit my brakes till I c…
Read full complaint
I was driving to work one morning On the highway, when I suddenly heard a loud sharp noise from the engine bay that followed with the engine and battery lights turning blinking on my display with sudden loss of steering. I panicked but quickly put my vehicle into neutral with my hazard lights on and slowly hit my brakes till I came to a complete stop on the highway. I got my vehicle towed back and upon further inspection saw that the idler pulley bolt snapped completely off. I researched and saw that this bolt has been recalled twice already with the same issue. If this was during a heavy traffic situation it could have been far worse.
NHTSA ODI #11483747
Mileage unknown · Jun 24, 2022
EngineFuel/propulsion SystemFire
Our car get on fire from begin low on oil, we stopped on the side and went on another car to get oil at the gas station and Suddenly star on fire and our entire car truck burned. Luckily we were able to get out off the car on time.
NHTSA ODI #11470883
Mileage unknown · Jun 20, 2022
EnginePower TrainVehicle Speed Control
As I was slowing down to make a turn, the vehicle went into neutral and shut off. I immediately turned it back on and put it in drive and the same thing occurred moments later. I start it again and drove away enough to safely park. I let the car rest in the off position for 30 minutes and it drove fine. There were no warning lig…
Read full complaint
As I was slowing down to make a turn, the vehicle went into neutral and shut off. I immediately turned it back on and put it in drive and the same thing occurred moments later. I start it again and drove away enough to safely park. I let the car rest in the off position for 30 minutes and it drove fine. There were no warning lights and the vehicle is well maintained with scheduled services. I contacted the nearest reputable mechanic and explained the situation. I drove it there. They found no faulty codes when they plugged in the computer and the battery has no issues. The vehicle drives fine now, but this is very concerning especially since this took place in local traffic.
NHTSA ODI #11470015
Official recalls
14Oct 20, 2023
BMW of North America, LLC (BMW) is recalling certain 2010-2012 1 Series Coupe, 1 Series Convertible, 3 Series Sedan, 3 Series Convertible, 2010-2011 3 Series Sportswagon, 3 Series Coupe, 5 Series Sedan, X3 xDrive 28i, X3 xDrive 30i, X5 xDrive30i, and Z4 sDrive30i vehicles. The aluminum bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and possibly break.
Consequence & remedy
Consequence: Loose or broken VANOS unit bolts can result in an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the four VANOS bolts, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed December 18, 2023. Owner notification letters were mailed June 19, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2009-2012 X5 xDrive35d, 2008-2012 X6 xDrive35i, X6 xDrive50i and X6 M, 2007-2012 X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M and 2010-2011 X6 ActiveHybrid vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSPI-2) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until this remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag, free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 14, 2019
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, 2008-2014 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, 2009-2013 X5 xDrive35d vehicles and 2010-2011 X6 ActiveHybrid vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
May 23, 2018
BMW of North America, LLC (BMW) is recalling certain 2009-2013 X5 xDrive 35d diesel vehicles. The engine idler pulley bolt may loosen over time and break.
Consequence & remedy
Consequence: If the idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the idler pulley bolt with an improved part, free of charge. The recall began March 11, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Apr 18, 2018
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence & remedy
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Engine And Engine Cooling:engine
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Jan 9, 2018
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, 2009-2010 X5 xDrive35d vehicles and 2009-2013 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." BMW is also recalling certain 2007-2010 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." BMW is also recalling certain 2007-2009 X5 xDrive30i, X5 xdrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag module, free of charge. The recall is expected to begin March 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
Mar 2, 2017
BMW of North America, LLC, (BMW) is recalling certain 2011-2013 X5 xDrive35i, X5 xDrive50i, X5 M and X5 xDrive35d vehicles, 2011-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles, and 2011 x6 ActiveHybrid Vehicles. Water and debris may enter the front driveshaft's universal joint, causing excessive wear and possibly resulting in the joint's failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on April 18, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Oct 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
Consequence & remedy
Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 25, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, 2009-2011 X5 xDrive35d vehicles, 2008-2011 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, and 2010-2011 X6 ActiveHybrid vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain model year 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, and 2008 BMW X6 xDrive35i, X6 xDrive50i and X6 M vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger frontal air bag inflator or air bag module, free of charge. The recall began July 28, 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2011 X5 xDrive 35i, xDrive50i, X5 M, X6 xDrive35i, X6 xDrive50i, and X6 M vehicles manufactured April 5, 2010, to November 20, 2010, 2011 X5 xDrive35d diesel vehicles manufactured April 7, 2010, to November 20, 2010, and 2011 X6 Active Hybrid vehicles manufactured April 15, 2010, to November 17, 2010. The affected vehicles have a front driveshaft universal joint that may not seal out water and debris from getting in and damaging the joint, which could lead to its failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on July 8, 2016. Owners may contact BMW customer service at 1-800-525-7417.
Oct 20, 2011
BMW IS RECALLING CERTAIN MODEL YEAR 2011 5-SERIES, MODEL YEAR 2010-2011 5-SERIES GRAN TURISMO, MODEL YEAR 2009-2011 7-SERIES, MODEL YEAR 2010-2011 X5 SAV, AND MODEL YEAR 2008-2011 X6 SAV VEHICLES EQUIPPED WITH 8- OR 12-CYLINDER, TURBOCHARGED, ENGINES BECAUSE THE CIRCUIT BOARD FOR THE ELECTRIC AUXILIARY WATER PUMP CAN OVERHEAT.
Consequence & remedy
Consequence: THIS COULD LEAD TO A SMOLDERING OF THE PUMP OR AN ENGINE COMPARTMENT OR VEHICLE FIRE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE AUXILIARY WATER PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 19, 2011. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Jun 2, 2010
BMW IS RECALLING CERTAIN MODEL YEAR 2011 X5 SAV AND X6 SAV PASSENGER VEHICLES MANUFACTURED FROM APRIL 1 THROUGH MAY 8, 2010. THE TIRE LABEL DOES NOT CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE VEHICLES ARE EQUIPPED WITH 20-INCH WHEELS, BUT THE LABEL STATES THAT THE VEHICLES WERE EQUIPPED WITH 19-INCH WHEELS AND THE STATED TIRE PRESSURE IS INCORRECT FOR THE EQUIPPED WHEELS.
Consequence & remedy
Consequence: IMPROPER TIRE INFLATION CAN RESULT IN PREMATURE TIRE FAILURE OR REDUCED VEHICLE HANDLING PERFORMANCE, EITHER OF WHICH CAN INCREASE THE RISK OF A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND PROVIDE CORRECT LABELS FREE OF CHARGE. THE OWNER WILL HAVE THE OPTION TO AFFIX THE LABEL THEMSELVES OR THEY MAY TAKE THEIR VEHICLE TO A BMW DEALER WHO WILL AFFIX THE LABEL FOR THEM AT NO COST. THE SAFETY RECALL BEGAN ON OCTOBER 8, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration