NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
18 reportsClear category filterMileage unknown · Nov 17, 2023
Power TrainService BrakesSteering
Transfer case actuators plastic gear(s) might be worn out due to bad quality of the material used. On some of the BMW X5 models there was a problem with the differentials and a recall was issued to fix those. But some how some cars with particular VINs went missing in that. Codes thrown by my system are : 005219, 005F3A, 006EC4…
Read full complaint
Transfer case actuators plastic gear(s) might be worn out due to bad quality of the material used. On some of the BMW X5 models there was a problem with the differentials and a recall was issued to fix those. But some how some cars with particular VINs went missing in that. Codes thrown by my system are : 005219, 005F3A, 006EC4 Code 005F3A signifies that the Transfer case actuator is not engaging properly. This problem put me at risk when taking a U-turn as the gears did not engage properly and my car did not accelerate on time. The on coming traffic came very close and I somehow avoided a T-bone Collison. My cars dashboard produces warning signs occasionally when the actuator does not engage. This is a big problem as the 4x4 system stops working and puts the car in RWD mode. In winters this could be dangerous to people driving as it happens without the driver's attention. I have attached reports from NHTSA for the same issue on other BMW models where a recall was issued. I request NHTSA to issue a recall on 2011 BMW X5 xdrive 35i as the same issue persists.
NHTSA ODI #11555719
Mileage unknown · Aug 11, 2023
Steering
The contact owns a 2011 BMW X5. The contact stated while driving 60 MPH, the steering wheel became stiff. No warning light was illuminated. The contact was able to pull to the side of the road. The vehicle had not been diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and …
Read full complaint
The contact owns a 2011 BMW X5. The contact stated while driving 60 MPH, the steering wheel became stiff. No warning light was illuminated. The contact was able to pull to the side of the road. The vehicle had not been diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and confirmed that the vehicle was not included in a recall. The failure mileage was unknown.
NHTSA ODI #11537873
Mileage unknown · Sep 9, 2022
Electrical SystemEngineSteering
I was driving to work one morning On the highway, when I suddenly heard a loud sharp noise from the engine bay that followed with the engine and battery lights turning blinking on my display with sudden loss of steering. I panicked but quickly put my vehicle into neutral with my hazard lights on and slowly hit my brakes till I c…
Read full complaint
I was driving to work one morning On the highway, when I suddenly heard a loud sharp noise from the engine bay that followed with the engine and battery lights turning blinking on my display with sudden loss of steering. I panicked but quickly put my vehicle into neutral with my hazard lights on and slowly hit my brakes till I came to a complete stop on the highway. I got my vehicle towed back and upon further inspection saw that the idler pulley bolt snapped completely off. I researched and saw that this bolt has been recalled twice already with the same issue. If this was during a heavy traffic situation it could have been far worse.
NHTSA ODI #11483747
Mileage unknown · Sep 1, 2022
Steering
Front drive shaft broke while driving and almost lost control.
NHTSA ODI #11482331
76,000 miles · Jan 2, 2020
Power TrainSteeringWheels
VEHICLE SHUDDERS AND HESITATES WHEN MAKING A HARD LEFT OF RIGHT TURN FROM A FULL STOP. (IE. TURNING RIGHT ON RED OR PULLING OUT OF A PLACE OF BUSINESS ONTO AN ACTIVE HIGHWAY.) I READ ABOUT 30 OTHER COMPLAINTS ABOUT THE SAME ISSUE - ALL POINTING A FAULTY "TRANSFER CASE". MY VEHICLE 2011 BWM X5 35I HAS 76,000 MILES. I DO …
Read full complaint
VEHICLE SHUDDERS AND HESITATES WHEN MAKING A HARD LEFT OF RIGHT TURN FROM A FULL STOP. (IE. TURNING RIGHT ON RED OR PULLING OUT OF A PLACE OF BUSINESS ONTO AN ACTIVE HIGHWAY.) I READ ABOUT 30 OTHER COMPLAINTS ABOUT THE SAME ISSUE - ALL POINTING A FAULTY "TRANSFER CASE". MY VEHICLE 2011 BWM X5 35I HAS 76,000 MILES. I DO SEE A POWER TRAIN RECALL FOR THE 2011 X5'S BUT MINE (FOR SOME UNKNOWN REASON IS NOT INCLUDED AND IT IS A 2011 (RECALL 17V138000) MY MECHANIC SAID IT WAS THE TRANSFER CASE AND WILL COST $3,000 TO REPAIR.
NHTSA ODI #11296776
120,000 miles · Apr 5, 2018
Engine And Engine CoolingSteering
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING IN REVERSE, THE STEERING WHEEL BECAME HARD TO TURN. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE POWER STEERING PUMP BOLT ON THE PULLEY FAILED, WHICH CAUSED THE STEERING WHEEL TO SEIZE AND THE ALTERNATOR BELT NOT TO FUNCTION. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAG…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING IN REVERSE, THE STEERING WHEEL BECAME HARD TO TURN. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE POWER STEERING PUMP BOLT ON THE PULLEY FAILED, WHICH CAUSED THE STEERING WHEEL TO SEIZE AND THE ALTERNATOR BELT NOT TO FUNCTION. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V550000 (STEERING, ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 120,000.
NHTSA ODI #11083479
111,200 miles · Mar 28, 2018
EngineFuel/propulsion SystemSteering
DRIVING DOWN STREET STEERING WHEEL LOCKED UP ,CAR SHUT DOWN,HAD IT TOWED TO BMW,THEY SAID ENGINE,POWERTRAIN FAILED,WARRANTY PEOPLE REFUSE TO PAY TO HAVE FIXED
NHTSA ODI #11081907
700,000 miles · Mar 13, 2017
Power TrainService BrakesSteering
2011 BMW X5 35I XDRIVE - MY DRIVE SHAFT BROKE (VIOLENT BANGING NOISE FROM THE FRONT OF THE CAR) WHILE I WAS GOING 65 MILES PER HOUR ON THE FREEWAY CAUSING ME TO SWERVE TO THE LEFT LANE BACK OVER TO THE RIGHT LANE. SUPER LUCKY THAT I BARELY MISSED HITTING THE CARS NEXT TO ME! I HAD HARDLY ANY CONTROL OF THE VEHICLE AND THE ENGI…
Read full complaint
2011 BMW X5 35I XDRIVE - MY DRIVE SHAFT BROKE (VIOLENT BANGING NOISE FROM THE FRONT OF THE CAR) WHILE I WAS GOING 65 MILES PER HOUR ON THE FREEWAY CAUSING ME TO SWERVE TO THE LEFT LANE BACK OVER TO THE RIGHT LANE. SUPER LUCKY THAT I BARELY MISSED HITTING THE CARS NEXT TO ME! I HAD HARDLY ANY CONTROL OF THE VEHICLE AND THE ENGINE WAS STILL RUNNING WHILE I COASTED OVER TO THE SIDE OF THE ROAD / DITCH. I LOST ALMOST 7 QUARTS OF OIL ON THE SIDE OF THE ROAD. MY ENGINE HAS A HOLE IN IT FROM THE DRIVE SHAFT. I DID NOT RECEIVE A RECALL NOTICE IN THE MAIL. THE MANUFACTURE WILL BE REPLACING MY ENGINE AND SOME HOSES THAT WERE DESTROYED. THE DEALER SAID THIS WASN'T A RECALL, JUST AN EXTENDED WARRANTY SINCE WE HAVE APPROX. 70,000 MILES ON THE CAR. THE DEALER GAVE US A LOANER CAR TO USE UNTIL OUR CAR IS REPAIRED. MY CONCERN IS THAT OWNERS SHOULD BE NOTIFIED IMMEDIATELY! HAD I KNOWN, I WOULD OF HAD MY CAR INSPECTED... NOW I'M OUT $325 DOLLARS FOR TOWING EXPENSES, A CAR THAT MIGHT NOT EVER BE QUITE THE SAME, LIVE 1HR 20 MINUTES FROM THE DEALER, AND THE MEMORY OF THE DRAMATIC EVENT.
NHTSA ODI #10965742
56,000 miles · Feb 24, 2017
EngineSteering
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING APPROXIMATELY 7 MPH, A LOUD NOISE WAS HEARD FROM THE ENGINE COMPARTMENT AND THE STEERING WHEEL LOST POWER WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED AND REPLACED THE BELT BOLT. THE FAILURE RECURRED AFTER SIX MONTHS. THE MANUFACTURER WAS MADE A…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING APPROXIMATELY 7 MPH, A LOUD NOISE WAS HEARD FROM THE ENGINE COMPARTMENT AND THE STEERING WHEEL LOST POWER WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED AND REPLACED THE BELT BOLT. THE FAILURE RECURRED AFTER SIX MONTHS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO A DEALER. THE DEALER STATED THAT A RECALL REPAIR WAS ALREADY PERFOMED AND COULD NOT BE REPEATED. THE VEHICLE WAS NOT REPAIRED. THE RECALL DETAILS WERE NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 56,000.
NHTSA ODI #10956710
67,000 miles · Jan 27, 2017
Air BagsEngineSteering
I PURCHASED CAR 2011-SOLE OWNER DEALER STATE REPLACES ENGINE PULLEY BOLT 2012? DRIVING IN DARK AND RAIN IN MOUNTAINS NC 1/24/17. ALL OF A SUDDEN LOST ABILITY TO STEER WITHOUT A LOT OF FORCE. THEN GOT DASH ERRORS "CHARGING MALFUNCTION", "ENGINE OVERHEATING" TRANSMISSION FAILURE "NO ABS" "DRIVE CAUTIOUSLY ""TURN OFF ENGINE". I …
Read full complaint
I PURCHASED CAR 2011-SOLE OWNER DEALER STATE REPLACES ENGINE PULLEY BOLT 2012? DRIVING IN DARK AND RAIN IN MOUNTAINS NC 1/24/17. ALL OF A SUDDEN LOST ABILITY TO STEER WITHOUT A LOT OF FORCE. THEN GOT DASH ERRORS "CHARGING MALFUNCTION", "ENGINE OVERHEATING" TRANSMISSION FAILURE "NO ABS" "DRIVE CAUTIOUSLY ""TURN OFF ENGINE". I COULD NOT TURN STEERING WHEEL HARD ENOUGH TO GET OFF ROAD. PULLED BARELY TO SIDE AND TURNED ENGINE OFF. COMPLETELY STRANDED AND SCARED TO DEATH. SAME BROKEN BOLT TO BE REPLACED. THIS IS LETHAL SITUATION AND I AM STUCK WITH A KILLER CAR. CANNOT AFFORD TO DUMP IT. THIS CAR HAS REQUIRED TOWING SEVERAL TIMES FOR ENGINE FAILURE THAT WAS "REPAIRED". BUT I DON'T KNOW WHAT WAS DONE. IN PRIOR SEPARATE INCIDENT I WAS DRIVING ALONG ENGINE LIGHT CAME ON CAR SPUTTERED AND STOPPED-REQUIRED TOWING. AND TAKATA RECALL ALSO STILL WAITING FOR AIRBAGS SHOOT SHARDS. BMW WILL NOT REPLACE. THEY THINK IT IS NOT HOT IN NC. I CALL 104 DEGREES HOT.
NHTSA ODI #10948014
Official recalls
14Oct 20, 2023
BMW of North America, LLC (BMW) is recalling certain 2010-2012 1 Series Coupe, 1 Series Convertible, 3 Series Sedan, 3 Series Convertible, 2010-2011 3 Series Sportswagon, 3 Series Coupe, 5 Series Sedan, X3 xDrive 28i, X3 xDrive 30i, X5 xDrive30i, and Z4 sDrive30i vehicles. The aluminum bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and possibly break.
Consequence & remedy
Consequence: Loose or broken VANOS unit bolts can result in an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the four VANOS bolts, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed December 18, 2023. Owner notification letters were mailed June 19, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2009-2012 X5 xDrive35d, 2008-2012 X6 xDrive35i, X6 xDrive50i and X6 M, 2007-2012 X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M and 2010-2011 X6 ActiveHybrid vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSPI-2) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until this remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag, free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 14, 2019
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, 2008-2014 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, 2009-2013 X5 xDrive35d vehicles and 2010-2011 X6 ActiveHybrid vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
May 23, 2018
BMW of North America, LLC (BMW) is recalling certain 2009-2013 X5 xDrive 35d diesel vehicles. The engine idler pulley bolt may loosen over time and break.
Consequence & remedy
Consequence: If the idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the idler pulley bolt with an improved part, free of charge. The recall began March 11, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Apr 18, 2018
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence & remedy
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Engine And Engine Cooling:engine
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Jan 9, 2018
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, 2009-2010 X5 xDrive35d vehicles and 2009-2013 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." BMW is also recalling certain 2007-2010 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." BMW is also recalling certain 2007-2009 X5 xDrive30i, X5 xdrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag module, free of charge. The recall is expected to begin March 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
Mar 2, 2017
BMW of North America, LLC, (BMW) is recalling certain 2011-2013 X5 xDrive35i, X5 xDrive50i, X5 M and X5 xDrive35d vehicles, 2011-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles, and 2011 x6 ActiveHybrid Vehicles. Water and debris may enter the front driveshaft's universal joint, causing excessive wear and possibly resulting in the joint's failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on April 18, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Oct 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
Consequence & remedy
Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 25, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, 2009-2011 X5 xDrive35d vehicles, 2008-2011 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, and 2010-2011 X6 ActiveHybrid vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain model year 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, and 2008 BMW X6 xDrive35i, X6 xDrive50i and X6 M vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger frontal air bag inflator or air bag module, free of charge. The recall began July 28, 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2011 X5 xDrive 35i, xDrive50i, X5 M, X6 xDrive35i, X6 xDrive50i, and X6 M vehicles manufactured April 5, 2010, to November 20, 2010, 2011 X5 xDrive35d diesel vehicles manufactured April 7, 2010, to November 20, 2010, and 2011 X6 Active Hybrid vehicles manufactured April 15, 2010, to November 17, 2010. The affected vehicles have a front driveshaft universal joint that may not seal out water and debris from getting in and damaging the joint, which could lead to its failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on July 8, 2016. Owners may contact BMW customer service at 1-800-525-7417.
Oct 20, 2011
BMW IS RECALLING CERTAIN MODEL YEAR 2011 5-SERIES, MODEL YEAR 2010-2011 5-SERIES GRAN TURISMO, MODEL YEAR 2009-2011 7-SERIES, MODEL YEAR 2010-2011 X5 SAV, AND MODEL YEAR 2008-2011 X6 SAV VEHICLES EQUIPPED WITH 8- OR 12-CYLINDER, TURBOCHARGED, ENGINES BECAUSE THE CIRCUIT BOARD FOR THE ELECTRIC AUXILIARY WATER PUMP CAN OVERHEAT.
Consequence & remedy
Consequence: THIS COULD LEAD TO A SMOLDERING OF THE PUMP OR AN ENGINE COMPARTMENT OR VEHICLE FIRE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE AUXILIARY WATER PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 19, 2011. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Jun 2, 2010
BMW IS RECALLING CERTAIN MODEL YEAR 2011 X5 SAV AND X6 SAV PASSENGER VEHICLES MANUFACTURED FROM APRIL 1 THROUGH MAY 8, 2010. THE TIRE LABEL DOES NOT CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE VEHICLES ARE EQUIPPED WITH 20-INCH WHEELS, BUT THE LABEL STATES THAT THE VEHICLES WERE EQUIPPED WITH 19-INCH WHEELS AND THE STATED TIRE PRESSURE IS INCORRECT FOR THE EQUIPPED WHEELS.
Consequence & remedy
Consequence: IMPROPER TIRE INFLATION CAN RESULT IN PREMATURE TIRE FAILURE OR REDUCED VEHICLE HANDLING PERFORMANCE, EITHER OF WHICH CAN INCREASE THE RISK OF A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND PROVIDE CORRECT LABELS FREE OF CHARGE. THE OWNER WILL HAVE THE OPTION TO AFFIX THE LABEL THEMSELVES OR THEY MAY TAKE THEIR VEHICLE TO A BMW DEALER WHO WILL AFFIX THE LABEL FOR THEM AT NO COST. THE SAFETY RECALL BEGAN ON OCTOBER 8, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration