NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
10 reportsClear category filterMileage unknown · Jun 13, 2018
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WENT INTO LIMP MODE DUE TO A FAILURE WITH THE AUXILIARY WATER PUMP. THE FAILURE CAUSED THE ENGINE TO OVERHEAT AND PREVENTED THE VEHICLE FROM ACCELERATING PAST 35 MPH. THE DEALER (GERMAIN BMW OF NAPLES, 11286 TAMIAMI TRAIL N, NAPLES, FL 34110, (239) 302…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WENT INTO LIMP MODE DUE TO A FAILURE WITH THE AUXILIARY WATER PUMP. THE FAILURE CAUSED THE ENGINE TO OVERHEAT AND PREVENTED THE VEHICLE FROM ACCELERATING PAST 35 MPH. THE DEALER (GERMAIN BMW OF NAPLES, 11286 TAMIAMI TRAIL N, NAPLES, FL 34110, (239) 302-3837) INITIALLY DIAGNOSED AND REPLACED THE RADIATOR, RESERVOIR TANK, RESERVOIR CAP, AND THERMOSTAT; HOWEVER, THE FAILURE RECURRED. THE CONTACT NOTICED THAT AN UNKNOWN MANUFACTURER RECALL CAMPAIGN WAS ISSUED. THE DEALER AND MANUFACTURER INDICATED THAT THE VEHICLE WAS EXCLUDED AND THAT THE AUXILIARY WATER PUMP NEEDED TO BE REPLACED, WHICH WAS NOT CORRECTLY DIAGNOSED WHEN THE FAILURE FIRST OCCURRED. THE VEHICLE WAS TO BE REPAIRED BY THE DEALER. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #11101638
120,000 miles · Apr 5, 2018
Engine And Engine CoolingSteering
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING IN REVERSE, THE STEERING WHEEL BECAME HARD TO TURN. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE POWER STEERING PUMP BOLT ON THE PULLEY FAILED, WHICH CAUSED THE STEERING WHEEL TO SEIZE AND THE ALTERNATOR BELT NOT TO FUNCTION. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAG…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING IN REVERSE, THE STEERING WHEEL BECAME HARD TO TURN. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE POWER STEERING PUMP BOLT ON THE PULLEY FAILED, WHICH CAUSED THE STEERING WHEEL TO SEIZE AND THE ALTERNATOR BELT NOT TO FUNCTION. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V550000 (STEERING, ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 120,000.
NHTSA ODI #11083479
62,000 miles · Nov 14, 2016
EngineEngine And Engine CoolingPower Train
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING 60 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE AND LOST POWER. THE ENGINE TEMPERATURE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE SERVICE AND THE TECHNICIAN STATED THAT THERE WAS A FAILURE WITH THE…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING 60 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE AND LOST POWER. THE ENGINE TEMPERATURE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE SERVICE AND THE TECHNICIAN STATED THAT THERE WAS A FAILURE WITH THE ENGINE FAN. THE VEHICLE WAS DIAGNOSED AND PRODUCED DIAGNOSTIC CODE 3792. THE CONTACT WAS UNSURE ABOUT WHAT PARTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 11V521000 (ENGINE AND ENGINE COOLING), BUT THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 62,000. UPDATED 01/04/17*LJ UPDATED 7/5/18*JB *TR
NHTSA ODI #10925872
Mileage unknown · Aug 21, 2014
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 14V176000 (ENGINE AND ENGINE COOLING) EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER STATED THAT THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE DELAY. THE VEHICLE WAS NOT REPAIRED. THE CONTACT DID NOT EX…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 14V176000 (ENGINE AND ENGINE COOLING) EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER STATED THAT THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE DELAY. THE VEHICLE WAS NOT REPAIRED. THE CONTACT DID NOT EXPERIENCE A FAILURE.
NHTSA ODI #10627306
71,000 miles · Aug 5, 2014
EngineEngine And Engine Cooling
ONLY AFTER ABOUT 10 MINUTES OF DRIVING IN THE NEIGHBORHOOD, WE GOT A WARNING "ENGINE HOT, DRIVE MODERATELY" THEN A FEW MINUTES LATER, IT SAID TO ENGINE HOT, AND TO STOP THE CAR IMMEDIATELY. WE HAD TO PULL THE CAR OVER AND AFTER ENGINE COOLED A BIT, TAKE OUR 2011 X5 TO THE NEAREST SHOP IN AN EMERGENCY. THE SHOP MECHANIC HAD TO R…
Read full complaint
ONLY AFTER ABOUT 10 MINUTES OF DRIVING IN THE NEIGHBORHOOD, WE GOT A WARNING "ENGINE HOT, DRIVE MODERATELY" THEN A FEW MINUTES LATER, IT SAID TO ENGINE HOT, AND TO STOP THE CAR IMMEDIATELY. WE HAD TO PULL THE CAR OVER AND AFTER ENGINE COOLED A BIT, TAKE OUR 2011 X5 TO THE NEAREST SHOP IN AN EMERGENCY. THE SHOP MECHANIC HAD TO REPLACE THE WATER PUMP AND SAID THAT IT IS A COMMON PROBLEM WITH BMW X5, EVEN THOUGH WE ONLY HAD 71,000 MILES. I LOOKED ONLINE AND THERE IS A RECALL AFFECTING WATER PUMPS FOR BMW X5 2011 (ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO-CHARGER RECALL NUMBER: 11V521000) BUT WHEN I CALLED BMW, IT SAID THAT MY PARTICULAR ENGINE IS NOT RECALLED. THE MECHANIC SAYS THIS IS UNUSUAL FOR SUCH A NEW CAR TO HAVE ENGINE OVERHEATING DUE TO WATER PUMP FAILURE, THIS SHOULD BE INVESTIGATED FOR SAFETY ISSUE. *TR
NHTSA ODI #10619011
71,000 miles · Jun 10, 2014
Engine And Engine Cooling
HI, I JUST PURCHASED THE ABOVE VEHICLE ON 5/13/14 AND ABOUT TWO WEEKS LATER MY CAR STARTED OVERHEATING. I KIND OF KNEW THAT THERE IS A PROBLEM WITH WATER PUMP SO I STARTED DOING SOME RESEARCH ONLINE TO SEE IF BMW X5 WAS ANY RECALLS AND TO MY SURPRISE THEY RECALLED NUMEROUS X5'S DUE TO WATER PUMP. I ALSO CALLED THEIR CUSTOME…
Read full complaint
HI, I JUST PURCHASED THE ABOVE VEHICLE ON 5/13/14 AND ABOUT TWO WEEKS LATER MY CAR STARTED OVERHEATING. I KIND OF KNEW THAT THERE IS A PROBLEM WITH WATER PUMP SO I STARTED DOING SOME RESEARCH ONLINE TO SEE IF BMW X5 WAS ANY RECALLS AND TO MY SURPRISE THEY RECALLED NUMEROUS X5'S DUE TO WATER PUMP. I ALSO CALLED THEIR CUSTOMER SERVICE TO SEE IF THERE WAS A RECALL ON MY CAR AND UNFORTUNATELY I WAS TOLD THAT THERE ISN'T. I TOOK MY CAR TO INTERNATIONAL AUTOS ON 6/9/14 FOR A DIAGNOSTICS CHECK AND THEY HAVE CONFIRMED THAT WATER PUMP NEEDS TO BE REPLACED. I BELIEVE THAT MY CAR SHOULD BE UNDER RECALL AS WELL SINCE BMW SEEMS TO HAVE A LOT OF TROUBLE WITH THIS. *TR
NHTSA ODI #10597364
6,000 miles · Feb 2, 2012
Engine And Engine CoolingFuel System, GasolinePower Train
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT OBSERVED EXCESSIVE RUST AND CORROSION WITHIN THE FUEL TANK, EXHAUST SYSTEM AND THE ATTACHING COMPONENTS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO STATED THAT THE OWNER WOULD BE RESPONSIBLE FOR THE REPAIR EXPENSES. THE VEHICLE WAS NOT REPAIRED. ON A SEPARATE OCCASION, THE …
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT OBSERVED EXCESSIVE RUST AND CORROSION WITHIN THE FUEL TANK, EXHAUST SYSTEM AND THE ATTACHING COMPONENTS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO STATED THAT THE OWNER WOULD BE RESPONSIBLE FOR THE REPAIR EXPENSES. THE VEHICLE WAS NOT REPAIRED. ON A SEPARATE OCCASION, THE CONTACT STATED THAT SMOKE EMITTED FROM UNDERNEATH THE HOOD WHILE DRIVING. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD AND STOPPED. THE CONTACT EXAMINED THE VEHICLE AND STATED THAT THERE WAS A SUBSTANTIAL AMOUNT OF OIL LOSS IN THE RESERVOIR. THE CONTACT THEN ADDED MORE OIL ACCORDINGLY. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER, WHO REFUSED TO MEASURE THE OIL MANUALLY PER THE CONSUMERS REQUEST, THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REIMBURSED THE CONSUMER FOR TWO DAYS OF MOTEL, FOOD AND TOWING COSTS. UNABLE TO LOCATE A FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 6,000. UPDATED 3/11/13 *CN BMW OFFERED TO BUY THE VEHICLE BACK, BUT LATER CHANGED THEIR MIND. THE CASE WENT TO COURT, AND THE JUDGE RULED THE OFFER WAS NOT BINDING. THE CONSUMER ALSO STATED THE VEHICLE WOULD RUN HOT, AND THE VEHICLE WOULD NOT GO INTO GEAR.
NHTSA ODI #10446315
17,800 miles · Dec 7, 2011
Engine And Engine CoolingFuel System, Gasoline
ENGINE STALLED WHILE DRIVING. WARNING LAMPS INDICATED REDUCED POWER. SEVERAL OCCURRENCES WERE AT SPEED ON THE INTERSTATE. CAR WOULD RESTART AFTER SITTING FOR SEVERAL HOURS. CAR WAS LEFT WITH BMW FOR SERVICE. HOWEVER, BMW SAID THEY COULD NOT REPLICATE THE PROBLEM AND DID NOT PERFORM ANY REPAIRS THE FIRST TIME. CAR AGAIN D…
Read full complaint
ENGINE STALLED WHILE DRIVING. WARNING LAMPS INDICATED REDUCED POWER. SEVERAL OCCURRENCES WERE AT SPEED ON THE INTERSTATE. CAR WOULD RESTART AFTER SITTING FOR SEVERAL HOURS. CAR WAS LEFT WITH BMW FOR SERVICE. HOWEVER, BMW SAID THEY COULD NOT REPLICATE THE PROBLEM AND DID NOT PERFORM ANY REPAIRS THE FIRST TIME. CAR AGAIN DIED WHILE DRIVING AT SPEED ON HIGHWAY SEVERAL WEEKS LATER. BMW STATED THAT THERE WAS LOSS OF ENGINE COMPRESSION. THEN, STATED THAT FUEL INJECTORS WERE FAULTY. THEN, CLAIMED THAT IT WAS DUE TO "BAD GAS" AND/OR SUGAR IN THE GAS TANK. *TR
NHTSA ODI #10438826
1,300 miles · Aug 18, 2011
Engine And Engine CoolingFuel System, GasolinePower Train
2012 BMW X5. UPON ENGINE START UP WHEN COLD, THE ENGINE SURGES EXCESSIVELY. IF THE TRANSMISSION IS ENGAGED DURING THE SURGING (FLUCTUATING RPM) THE VEHICLE LURCHES FORWARD/REVERSE CAUSING A DANGEROUS SITUATION AND POTENTIAL ACCIDENT. *KB
NHTSA ODI #10420072
469 miles · May 19, 2011
Engine And Engine CoolingEquipmentFuel System, Gasoline
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT THE VEHICLE SUDDENLY STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO REPLACED THE FUEL PUMP. IN ADDITION, THE DRIVER SIDE WINDOW WAS MAKING A LOUD NOISE BUT THE CONTACT WAS UNSURE OF THE DIAGNOSIS AND THE REPAIR. ALSO, WHEN FIRST STARTING THE …
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT THE VEHICLE SUDDENLY STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO REPLACED THE FUEL PUMP. IN ADDITION, THE DRIVER SIDE WINDOW WAS MAKING A LOUD NOISE BUT THE CONTACT WAS UNSURE OF THE DIAGNOSIS AND THE REPAIR. ALSO, WHEN FIRST STARTING THE VEHICLE, THE ENGINE WOULD ROAR ABNORMALLY LOUD. THE CONTACT ALSO STATED THAT THERE WAS NO AIR EMITTING FROM THE AIR CONDITIONER WHEN ACTIVATED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT MILEAGE WAS APPROXIMATELY 500 AND THE FAILURE MILEAGE WAS 469. UPDATED 11/08/11*LJ UPDATED 11/14/11
NHTSA ODI #10402037
Official recalls
14Oct 20, 2023
BMW of North America, LLC (BMW) is recalling certain 2010-2012 1 Series Coupe, 1 Series Convertible, 3 Series Sedan, 3 Series Convertible, 2010-2011 3 Series Sportswagon, 3 Series Coupe, 5 Series Sedan, X3 xDrive 28i, X3 xDrive 30i, X5 xDrive30i, and Z4 sDrive30i vehicles. The aluminum bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and possibly break.
Consequence & remedy
Consequence: Loose or broken VANOS unit bolts can result in an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the four VANOS bolts, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed December 18, 2023. Owner notification letters were mailed June 19, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2009-2012 X5 xDrive35d, 2008-2012 X6 xDrive35i, X6 xDrive50i and X6 M, 2007-2012 X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M and 2010-2011 X6 ActiveHybrid vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSPI-2) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until this remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag, free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 14, 2019
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, 2008-2014 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, 2009-2013 X5 xDrive35d vehicles and 2010-2011 X6 ActiveHybrid vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
May 23, 2018
BMW of North America, LLC (BMW) is recalling certain 2009-2013 X5 xDrive 35d diesel vehicles. The engine idler pulley bolt may loosen over time and break.
Consequence & remedy
Consequence: If the idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the idler pulley bolt with an improved part, free of charge. The recall began March 11, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Apr 18, 2018
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence & remedy
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Engine And Engine Cooling:engine
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Jan 9, 2018
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, 2009-2010 X5 xDrive35d vehicles and 2009-2013 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." BMW is also recalling certain 2007-2010 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." BMW is also recalling certain 2007-2009 X5 xDrive30i, X5 xdrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag module, free of charge. The recall is expected to begin March 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
Mar 2, 2017
BMW of North America, LLC, (BMW) is recalling certain 2011-2013 X5 xDrive35i, X5 xDrive50i, X5 M and X5 xDrive35d vehicles, 2011-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles, and 2011 x6 ActiveHybrid Vehicles. Water and debris may enter the front driveshaft's universal joint, causing excessive wear and possibly resulting in the joint's failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on April 18, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Oct 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
Consequence & remedy
Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 25, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, 2009-2011 X5 xDrive35d vehicles, 2008-2011 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, and 2010-2011 X6 ActiveHybrid vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain model year 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, and 2008 BMW X6 xDrive35i, X6 xDrive50i and X6 M vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger frontal air bag inflator or air bag module, free of charge. The recall began July 28, 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2011 X5 xDrive 35i, xDrive50i, X5 M, X6 xDrive35i, X6 xDrive50i, and X6 M vehicles manufactured April 5, 2010, to November 20, 2010, 2011 X5 xDrive35d diesel vehicles manufactured April 7, 2010, to November 20, 2010, and 2011 X6 Active Hybrid vehicles manufactured April 15, 2010, to November 17, 2010. The affected vehicles have a front driveshaft universal joint that may not seal out water and debris from getting in and damaging the joint, which could lead to its failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on July 8, 2016. Owners may contact BMW customer service at 1-800-525-7417.
Oct 20, 2011
BMW IS RECALLING CERTAIN MODEL YEAR 2011 5-SERIES, MODEL YEAR 2010-2011 5-SERIES GRAN TURISMO, MODEL YEAR 2009-2011 7-SERIES, MODEL YEAR 2010-2011 X5 SAV, AND MODEL YEAR 2008-2011 X6 SAV VEHICLES EQUIPPED WITH 8- OR 12-CYLINDER, TURBOCHARGED, ENGINES BECAUSE THE CIRCUIT BOARD FOR THE ELECTRIC AUXILIARY WATER PUMP CAN OVERHEAT.
Consequence & remedy
Consequence: THIS COULD LEAD TO A SMOLDERING OF THE PUMP OR AN ENGINE COMPARTMENT OR VEHICLE FIRE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE AUXILIARY WATER PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 19, 2011. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Jun 2, 2010
BMW IS RECALLING CERTAIN MODEL YEAR 2011 X5 SAV AND X6 SAV PASSENGER VEHICLES MANUFACTURED FROM APRIL 1 THROUGH MAY 8, 2010. THE TIRE LABEL DOES NOT CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE VEHICLES ARE EQUIPPED WITH 20-INCH WHEELS, BUT THE LABEL STATES THAT THE VEHICLES WERE EQUIPPED WITH 19-INCH WHEELS AND THE STATED TIRE PRESSURE IS INCORRECT FOR THE EQUIPPED WHEELS.
Consequence & remedy
Consequence: IMPROPER TIRE INFLATION CAN RESULT IN PREMATURE TIRE FAILURE OR REDUCED VEHICLE HANDLING PERFORMANCE, EITHER OF WHICH CAN INCREASE THE RISK OF A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND PROVIDE CORRECT LABELS FREE OF CHARGE. THE OWNER WILL HAVE THE OPTION TO AFFIX THE LABEL THEMSELVES OR THEY MAY TAKE THEIR VEHICLE TO A BMW DEALER WHO WILL AFFIX THE LABEL FOR THEM AT NO COST. THE SAFETY RECALL BEGAN ON OCTOBER 8, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration