Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports2 fire reports1 injury reports

Visibility/wiper complaints

1 reports

Clear category filter

Mileage unknown · Mar 17, 2023

Electrical SystemExterior LightingVisibility/wiper

Read full complaint

The headlight housing on my model year is leaking water into it and causing electrical issues , Iv noticed majority of other models I see on the road have the same issue with one of the headlight housings having water in them, this has caused numerous codes to appear on the dash. “ Vertical headlight malfunction “ …”turn signal malfunction “ …”daytime running light malfunction “ ect… this is a safety issue because it stops my signal from working and my headlight works when it wants to. Normally I would think maybe I rock chipped the housing but since I see it on majority of 535’s I see I figure it must have been an issue from factory.

NHTSA ODI #11512368

Official recalls

15V188000 · Exterior Lighting

Mar 31, 2015

BMW of North America, LLC (BMW) is recalling certain model year 2013 528i, 528i xDrive, 535i, 535i xDrive, 550i, 550i xDrive, and ActiveHybrid 5 vehicles. The rear reflex reflectors may not reflect enough light. As such, the vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: The vehicle may be less visible to other vehicles, increasing the risk of a crash.

Remedy: BMW will notify owners, and dealers will replace the rear reflex reflectors, free of charge. The recall began July 28, 2017. Owners may contact BMW customer service at 1-800-525-7417.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.