Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 17 of 22 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Exterior Lighting. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports0 injury reports
What owners actually said
22 reports
Mileage unknown · Aug 30, 2019
Air Bags
TL* THE CONTACT OWNS A 2003 BMW 3 SERIES. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 15V318000 (AIR BAGS) AND 13V172000 (AIR BAGS). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AN APPOINTMENT WAS MADE TO BMW OF PLEASANT GROVE (2111 W GROVE PKWY, PLEASANT …
Read full complaint
TL* THE CONTACT OWNS A 2003 BMW 3 SERIES. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 15V318000 (AIR BAGS) AND 13V172000 (AIR BAGS). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AN APPOINTMENT WAS MADE TO BMW OF PLEASANT GROVE (2111 W GROVE PKWY, PLEASANT GROVE, UT 84062, (801) 443-2000) WHO STATED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDIES. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS UNKNOWN. *TT CONSUMER STATED HE MADE AN APPOINTMENT AT BMW OF PLEASANT GROVE. *JB
NHTSA ODI #11252476
113 miles · Jul 29, 2015
Air Bags
BMW OF CHAMPAIGN , ILLINOIS HAS REFUSED TO REPAIR MY AIRBAGS. I HAVE ATTEMPTED TO RESOLVE THIS PROBLEM THROUGH THEIR ATTORNEY, DAVID SHOLEM. HIS RESPONSE HAS BEEN TO HANG UP ON ME OR NOT RESPOND AT ALL. THIS IS A SERIOUS PROBLEM, AS THEY HAVE AGNOLIGED ( COPY AVAILABLE). I HAVE ASKED FOR AT LEAST FINANCIAL ASSISTANCE TO TR…
Read full complaint
BMW OF CHAMPAIGN , ILLINOIS HAS REFUSED TO REPAIR MY AIRBAGS. I HAVE ATTEMPTED TO RESOLVE THIS PROBLEM THROUGH THEIR ATTORNEY, DAVID SHOLEM. HIS RESPONSE HAS BEEN TO HANG UP ON ME OR NOT RESPOND AT ALL. THIS IS A SERIOUS PROBLEM, AS THEY HAVE AGNOLIGED ( COPY AVAILABLE). I HAVE ASKED FOR AT LEAST FINANCIAL ASSISTANCE TO TRAVEL TO ANOTHER BMW DEALER NEARLY 100 MILES AWAY TO RELIEVE THE HARDSHIP THEY CREATED. BMW CHAMPAIGN IS LOCATED LESS THAN 2 MILES FROM MY RESIDENCE.I PURCHASED THIS VEHICLE FROM BMW OF CHAMPAIGN WITH AN OPEN RECALL EVEN THOUGH THE VEHICLE WAS ADVERTISED AS BEING "FULLY RECONDITIONED.
NHTSA ODI #10744542
51,000 miles · May 1, 2014
Structure
I ARRIVED HOME WITH MY SON WHO WAS SITTING IN THE FRONT PASSENGER SEAT. WHEN HE TRIED TO GET OUT OF THE CAR, THE DOOR WOULD NOT OPEN. THE LOCK BUTTON STAYED DOWN AND WOULD NOT OPEN WITH TWO PULLS ON THE HANDLE AS IT SHOULD, WITH USE OF THE INTERIOR LOCKING/UNLOCKING BUTTON , OR WITH THE REMOTE CONTROL KEY FOB. IT HAS NOW REMAINE…
Read full complaint
I ARRIVED HOME WITH MY SON WHO WAS SITTING IN THE FRONT PASSENGER SEAT. WHEN HE TRIED TO GET OUT OF THE CAR, THE DOOR WOULD NOT OPEN. THE LOCK BUTTON STAYED DOWN AND WOULD NOT OPEN WITH TWO PULLS ON THE HANDLE AS IT SHOULD, WITH USE OF THE INTERIOR LOCKING/UNLOCKING BUTTON , OR WITH THE REMOTE CONTROL KEY FOB. IT HAS NOW REMAINED NON-FUNCTIONAL. IN THE EVENT OF A CRASH ON THE DRIVER'S SIDE, THERE WOULD BE NO WAY TO LEAVE THE CAR OR RECEIVED HELP WITHOUT BREAKING A WINDOW AND TRYING TO SLITHER OUT THROUGH BROKEN GLASS. IN ADDITION, SOMEONE WHO WAS INFIRM (E.G., BACK TROUBLE) AND COULD NOT CLIMB OVER THE CONSOLE AND DRIVER'S SEAT WOULD BE STUCK IN THE CAR. THIS IS A SAFETY AND HEALTH HAZARD AND FROM WHAT I HAVE SEEN ON LINE, IS NOT UNIQUE TO ME. BMW SHOULD BE REQUIRED TO MAKE MODIFICATIONS THAT WOULD ELIMINATE THIS SAFETY AND HEALTH HAZARD. *TR
NHTSA ODI #10585959
75,000 miles · Apr 7, 2014
Engine
THE BMW E46 3-SERIES (1999-2006) SUFFERS FROM A DESIGN FLAW IN THE COOLING SYSTEM. PLASTIC PARTS IN THE COOLING SYSTEM FAIL AS SOON AS 4 YEARS AND 80,000 MILES FROM MANUFACTURE DATE, OFTEN FAILING CATASTROPHICALLY AND CAUSING THE ENGINE TO OVERHEAT. CONTINUED DRIVING OF THE CAR IN THIS SITUATION LEADS TO COMPLETE ENGINE FAILURE…
Read full complaint
THE BMW E46 3-SERIES (1999-2006) SUFFERS FROM A DESIGN FLAW IN THE COOLING SYSTEM. PLASTIC PARTS IN THE COOLING SYSTEM FAIL AS SOON AS 4 YEARS AND 80,000 MILES FROM MANUFACTURE DATE, OFTEN FAILING CATASTROPHICALLY AND CAUSING THE ENGINE TO OVERHEAT. CONTINUED DRIVING OF THE CAR IN THIS SITUATION LEADS TO COMPLETE ENGINE FAILURE AND LOSS OF POWER (INCLUDING POWER STEERING AND POWER BRAKES), POTENTIALLY CAUSING AN ACCIDENT IF IT HAPPENS AT HIGHWAY SPEEDS. TYPICAL FAILED PARTS INCLUDE THE COOLANT EXPANSION TANK, RADIATOR END TANKS, AND WATER PUMP IMPELLERS OR BEARINGS. (BMW CAME UP WITH AN IMPROVED WATER PUMP DESIGN AROUND 2004 THAT IS MORE RELIABLE.) CARS WITH AUTOMATIC TRANSMISSIONS ALSO SUFFER FAILURES OF THE MECHANICAL FAN CLUTCH AND THE TRANSMISSION COOLING THERMOSTAT. FAILURE OF THE FAN CLUTCH (FOUND ONLY ON AUTOMATIC TRANSMISSION CARS) CAN CAUSE THE FAN BLADES TO BREAK OFF AND DAMAGE THE RADIATOR, SERPENTINE BELT, AND WATER PUMP, AS WELL AS THE CAR'S HOOD. AT HIGHER MILEAGES (>150,000 MILES) THE PLASTIC COOLANT PIPES OFTEN FAIL, CAUSING OVERHEATING AND REQUIRING MAJOR WORK TO REPLACE. ON MY CAR THE COOLANT EXPANSION TANK AND RADIATOR BOTH FAILED AND WERE REPLACED. THE THERMOSTAT ALSO STUCK OPEN RESULTING IN LOWER GAS MILEAGE UNTIL IT WAS REPLACED. NOW ONE OF MY PLASTIC COOLANT PIPES IS LEAKING. BMW SHOULD BE REQUIRED TO REPAIR FAILED PLASTIC COOLING SYSTEM PARTS ON THE E46 3-SERIES WITH HIGHER-QUALITY PARTS DESIGNED TO LAST AT LEAST 10 YEARS AND 100,000 MILES FROM MANUFACTURE DATE. *TR
NHTSA ODI #10577923
88,000 miles · Nov 1, 2013
Power Train
TL* THE CONTACT OWNS A 2003 BMW 323CI. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHIFT INTO REVERSE GEAR. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO STATED THAT THE REAR D DRUM FAILED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 88,000.
NHTSA ODI #10550524
9,500 miles · Sep 28, 2013
Service BrakesCrash
WAS GOING APPROXIMATELY 7MPH HIT BRAKES DIDN'T STOP HIT CAR IN FRONT OF ME. *TRW
NHTSA ODI #10545756
38,000 miles · Nov 21, 2011
Exterior Lighting
HEADLIGHTS FAIL RANDOMLY. HEADLIGHTS FLICKER, TURN OFF, TURN BACK ON. INDEPENDENT OF SPEED OR WEATHER CONDITIONS. BULB TESTING AFTER THIS FAILURE INDICATE THAT THE BULBS ARE NOT FAILING (THEY ARE NOT BURNED OUT). *TR
NHTSA ODI #10436660
98,000 miles · Jul 17, 2011
Exterior Lighting
THE LOW BEAM REFLECTORS ON 2003-2004 ZKW BRANDED HIGH INTENSITY DISCHARGE XENON OEM HID HEADLIGHTS ON THE 3 SERIES BMW FROM THAT MODEL YEAR (SEDAN) WERE MADE OF SOME PAINTED MATERIAL THAT DEGRADED WHEN SUBJECTED TO THE HEAT PRODUCED BY THE OEM XENON BULBS. THIS RESULTS IN A SIGNIFICANTLY DECREASED LIGHT OUTPUT AS THE REFLECTOR B…
Read full complaint
THE LOW BEAM REFLECTORS ON 2003-2004 ZKW BRANDED HIGH INTENSITY DISCHARGE XENON OEM HID HEADLIGHTS ON THE 3 SERIES BMW FROM THAT MODEL YEAR (SEDAN) WERE MADE OF SOME PAINTED MATERIAL THAT DEGRADED WHEN SUBJECTED TO THE HEAT PRODUCED BY THE OEM XENON BULBS. THIS RESULTS IN A SIGNIFICANTLY DECREASED LIGHT OUTPUT AS THE REFLECTOR BECAME SCORCHED. IF IT'S BAD ENOUGH, THERE IS NO LIGHT BEING PROJECTED ON THE ROAD AND IT IS VERY HARD TO SEE ANYTHING WITH THE NORMAL HEADLIGHTS. EITHER THE HIGH BEAMS HAVE TO BE USED OR THE FOGLIGHTS HAVE TO BE TURNED ON. THIS IS A SAFETY ISSUE. I WOULD IMAGINE THAT BMW AND ZKW WERE AND ARE AWARE OF THE DEFECT AS THE NEWER, REDESIGNED HEADLIGHTS DO NOT SUFFER FROM THIS PROBLEM. REPLACEMENT OEM HEADLIGHTS COST $1200 FOR EACH SIDE. *TR
NHTSA ODI #10413233
Mileage unknown · Jul 12, 2011
Exterior Lighting
ON 2003-2004 BMW 3 SERIES E46 SEDANS WITH OEM ZKW MANUFACTURED XENON (HID) HEADLIGHTS, THE REFLECTIVE BOWL FOR THE HEADLIGHTS WILL BECOME DISCOLORED AND NON-REFLECTIVE AFTER NORMAL USE WITH OEM BULBS. OVER TIME, THE HEAT FROM THE OEM BULB WILL SCORCH THE REFLECTIVE BOWL AND DRAMATICALLY REDUCE LIGHT OUTPUT TO UNSAFE LEVELS FOR N…
Read full complaint
ON 2003-2004 BMW 3 SERIES E46 SEDANS WITH OEM ZKW MANUFACTURED XENON (HID) HEADLIGHTS, THE REFLECTIVE BOWL FOR THE HEADLIGHTS WILL BECOME DISCOLORED AND NON-REFLECTIVE AFTER NORMAL USE WITH OEM BULBS. OVER TIME, THE HEAT FROM THE OEM BULB WILL SCORCH THE REFLECTIVE BOWL AND DRAMATICALLY REDUCE LIGHT OUTPUT TO UNSAFE LEVELS FOR NIGHT TIME DRIVING. BMW HAS NOT NOTIFIED OWNERS OF THE DESIGN FLAW, AND NO REPLACEMENT PARTS ARE AVAILABLE OTHER THAN THE ENTIRE EXPENSIVE, NEW HEADLIGHT ASSEMBLIES THAT WILL SUFFER FROM THE SAME PROBLEM IN TIME. THOUGH BMW REFUSES TO ACKNOWLEDGE THAT AN ISSUE EXISTS, BMW CHANGED THE XENON HEADLIGHT REFLECTOR DESIGN FOR LATER MODEL YEARS TO A METAL REFLECTOR ASSEMBLY THAT DOES NOT DEGRADE WHEN EXPOSED TO THE NORMAL OPERATING TEMPERATURES OF THE OEM XENON BULBS. THESE NEWER DESIGNED HEADLIGHT ASSEMBLIES TO NOT SUFFER FROM ANY REDUCTION IN LIGHT OUTPUT WITH USE. *TT
NHTSA ODI #10411949
81,606 miles · Jun 24, 2011
Air Bags
TL* THE CONTACT OWNS A 2006 BMW 3-SERIES. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL, INDICATING THAT THE FRONT PASSENGER SIDE AIR BAG WAS NOT FUNCTIONING. THE CONTACT NOTICED NHTSA CAMPAIGN I.D. NUMBER 08V384000 (AIR BAGS:FRONTAL) AND TOOK THE VEHICLE TO AN AUTHORIZED DEALER. THE CONTA…
Read full complaint
TL* THE CONTACT OWNS A 2006 BMW 3-SERIES. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL, INDICATING THAT THE FRONT PASSENGER SIDE AIR BAG WAS NOT FUNCTIONING. THE CONTACT NOTICED NHTSA CAMPAIGN I.D. NUMBER 08V384000 (AIR BAGS:FRONTAL) AND TOOK THE VEHICLE TO AN AUTHORIZED DEALER. THE CONTACT WAS INFORMED THAT THE FRONT PASSENGER AIR BAG DETECTION MATT NEEDED TO BE REPLACED, BUT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE CONTACT EXPRESSED CONCERN IN REGARDS TO DRIVING A VEHICLE WITHOUT A FUNCTIONING AIR BAG. THE FAILURE MILEAGE WAS 81,606. UPDATED 07/26/11 *BF THE CONSUMER STATED BMW AGREED TO SHARE THE COST WITH THE HIM. UPDATED 07/28/11
NHTSA ODI #10408807
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA09019 · Rear Lamp Illumination
Opened Dec 18, 2009 · Closed Sep 28, 2011
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Additional source detail variants (4)
Exterior Lighting
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:brake Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:tail Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
PE09036 · Rear Lamp Illumination
Opened Aug 7, 2009 · Closed Dec 22, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Additional source detail variants (4)
Exterior Lighting
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:brake Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:tail Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
DP09002 · Rear Lamp Illumination
Opened Apr 8, 2009 · Closed Aug 6, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Additional source detail variants (5)
Exterior Lighting:back Up Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:brake Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:tail Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
2003 BMW 3-SERIES Problems, Complaints & Recalls | Skip That Year
Illustration