IllustrationLENS COVER FOR HEAD LIGHTS ON BMW 325 I WITH ONLY 65K IN SOUTHERN CALIFORNIA ARE SEVERELY OXIDIZED LIMITING VISION AT NIGHT. CALLED BMW AND BASICALLY STATED WARRANTY HAS EXPIRED. *TR
2003 BMW 3-SERIES
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Other model years Selected year
Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 17 of 22 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports0 injury reports
What owners actually said
22 reportsCENTRAL LOCKING WONT WORK, THE KEY DOES NOT OPEN THE DOORS LIGHT COMES ON TO SAY DOOR OPEN BUT THEY DON'T AND ALSO DRIVER DOOR OPENS WITH KEY THE INTERNAL BUTTON ALSO DOES NOT OPEN THE DOORS, INTERMITTENT FAULT. *TR
BMW E46 3 SERIES - ZKW HEADLIGHTS- VERY LOW LIGHT OUTPUT THE ZKW HEADLIGHTS HAVE A DESIGN FLAW IN WHICH AFTER 2-3 YEARS OF USE, THEY DIM TO AROUND 20% OF THE ORIGINAL LIGHT OUTPUT. THIS IS VERY DANGEROUS WHEN IT COMES TO NIGHT DRIVING. SOMEONE DRIVING WITH THIS ISSUE IS NEARLY COMPLETELY BLIND DRIVING AROUND AT NIGHT. THIS IS D…
Read full complaint
BMW E46 3 SERIES - ZKW HEADLIGHTS- VERY LOW LIGHT OUTPUT THE ZKW HEADLIGHTS HAVE A DESIGN FLAW IN WHICH AFTER 2-3 YEARS OF USE, THEY DIM TO AROUND 20% OF THE ORIGINAL LIGHT OUTPUT. THIS IS VERY DANGEROUS WHEN IT COMES TO NIGHT DRIVING. SOMEONE DRIVING WITH THIS ISSUE IS NEARLY COMPLETELY BLIND DRIVING AROUND AT NIGHT. THIS IS DUE TO THE PROJECTOR REFLECTOR BOWL BEING MADE OUT OF PLASTIC, AND MELTING FROM THE HEAT. THIS CAUSES THE LIGHT TO BLEED OUT FROM THE BACKSIDE OF THE LIGHT INTO THE HOUSING, INSTEAD OF FORWARD ONTO THE ROAD. BMW NOTED THIS FLAW BY REPLACED THE ZKW HEADLAMPS WITH AL BRANDED HEADLAMPS IN ALL THE NEWER BMWS IN 2005 AND ON. THE AL BRANDED HEADLIGHTS REPLACED THE PLASTIC BOWL WITH METAL BOWLS. HOWEVER, ALL E46 3 SERIES SEDANS FROM 2003-2004 STILL HAVE THESE FAULTY ZKW HEADLAMPS. THERE IS NO EASY FIX TO THIS PROBLEM, AS BMW DOES NOT SELL THE BOWLS SEPARATELY. THE ONLY SOLUTION IS TO COMPLETELY REPLACE THE HEADLAMPS, WHICH COSTS AROUND $2000. THIS IS A VERY SERIOUS SAFETY CONCERN. I CAN GUARANTEE THAT NEARLY EVERY 2003-2004 3 SERIES SEDAN WITH OEM XENON HEADLAMPS FACES THIS ISSUE. OWNERS DO NOT FIX THE ISSUE DUE TO THE HEAVY COSTS. *TR
1. ENGINE HAD BEEN RUNNING ROUGHLY ON START UP (FOR A FEW SECONDS) FOR A FEW DAYS. ON THE DATE OF INCIDENT, WHILE STARTING CAR TO HEAD BACK HOME, CAR STARTED VERY ROUGHLY (FOR A SHORT PERIOD OF TIME). CAR THEN CLEARED UP. WHILE DRIVING AT SPEED OF 55-60 MPH ON HIGHWAY, CAR SUDDENLY DIED. I HAD TO STEER THE CAR FROM THE LEFT…
Read full complaint
1. ENGINE HAD BEEN RUNNING ROUGHLY ON START UP (FOR A FEW SECONDS) FOR A FEW DAYS. ON THE DATE OF INCIDENT, WHILE STARTING CAR TO HEAD BACK HOME, CAR STARTED VERY ROUGHLY (FOR A SHORT PERIOD OF TIME). CAR THEN CLEARED UP. WHILE DRIVING AT SPEED OF 55-60 MPH ON HIGHWAY, CAR SUDDENLY DIED. I HAD TO STEER THE CAR FROM THE LEFT-HAND LANE ONTO THE RIGHT HAND SHOULDER IN THE MIDST OF TRAFFIC (DIFFICULT TO STEER). 2. THE ENGINE DIED SUDDENLY WHILE DRIVING ON THE HIGHWAY. THIS WAS THE ONLY TIME THAT THE ENGINE DIED WHILE I DROVE THE CAR. 3. I HAD THE VEHICLE TOWED TO THE SHOP. THE FUEL PUMP WAS REPLACED. EVEN THOUGH THERE WAS GAS IN THE TANK, THE FUEL TANK WAS EMPTY. *TR
TL*THE CONTACT OWNS A 2003 BMW 330. THE CONTACT STATED THAT THE BRAKE LIGHT ASSEMBLY HAD MELTED. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO HAVE THE BRAKE ASSEMBLY REPLACED SINCE BOTH LIGHTS FAILED. TSB ACTION NUMBER 10025585 WAS RELATED TO THE TAIL LIGHT FAILURE. THE CONTACT CALLED THE MANUFACTURER REGARDING A RECALL AND WAS…
Read full complaint
TL*THE CONTACT OWNS A 2003 BMW 330. THE CONTACT STATED THAT THE BRAKE LIGHT ASSEMBLY HAD MELTED. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO HAVE THE BRAKE ASSEMBLY REPLACED SINCE BOTH LIGHTS FAILED. TSB ACTION NUMBER 10025585 WAS RELATED TO THE TAIL LIGHT FAILURE. THE CONTACT CALLED THE MANUFACTURER REGARDING A RECALL AND WAS TOLD THAT THERE WAS NO FURTHER ESCALATION PROCESS TO FOLLOW REGARDING REIMBURSEMENT. THE CONTACT WAS CONCERNED THAT THERE WAS NO RECALL RELATED TO THE TAIL LIGHTS SINCE A FIRE COULD POTENTIALLY OCCUR. THE FAILURE MILEAGE WAS 46,578. UPDATED 10/20/10 *BF UPDATED 10/21/10*JB THE CONSUMER IS SEEKING REIMBURSEMENT DUE TO RECALL 11V438000 BEING ISSUED. UPDATED 05/17/12
I WAS THE PREVIOUS OWNER OF A BMW 325I THAT I HAVE BEEN TOLD NEEDS A NEW TRANSMISSION. AGE - 2003, MILES 60,000. IT'S UNACCEPTABLE THAT A CAR WITH SO LOW MILES, HAS BEEN MAINTAINED AND DRIVEN GENTLY HAS EXPERIENCED THIS PROBLEM. AFTER SEARCHING ON THE WEB, I FIND THAT THIS IS A RECURRING PROBLEM WITH BMW'S. WHY HAS NOTHING B…
Read full complaint
I WAS THE PREVIOUS OWNER OF A BMW 325I THAT I HAVE BEEN TOLD NEEDS A NEW TRANSMISSION. AGE - 2003, MILES 60,000. IT'S UNACCEPTABLE THAT A CAR WITH SO LOW MILES, HAS BEEN MAINTAINED AND DRIVEN GENTLY HAS EXPERIENCED THIS PROBLEM. AFTER SEARCHING ON THE WEB, I FIND THAT THIS IS A RECURRING PROBLEM WITH BMW'S. WHY HAS NOTHING BEEN DONE? HOW CAN BMW SAY THIS IS NOT THEIR ISSUE WHEN CLEARLY THIS IS A PROBLEM WITH THEIR CARS. I'M SPENDING AN ADDITIONAL 6,000 ON THIS CAR. I RECENTLY PURCHASED A BRAND NEW BMW AND SOLD THE 325 TO A CLOSE FRIEND. I REPLACED THE TRANSMISSION AS I COULD NOT EXPECT THEM TO PAY FOR IT. PRIOR TO THE SALE, THE CAR CHECKED OUT WITH BMW. LITTLE DID I KNOW 2 WKS LATER IT WOULD HAVE THIS PROBLEM WHICH APPEARS TO BE A STANDARD PROBLEM WITH BMW. I REGRET THAT I BOUGHT A NEW ONE. *TR
FORMAL PETITION FOR SAFETY DEFECT INVESTIGATION, AFTER REPLACING THE TAIL LIGHT BULBS IN ON THE PASSENGER AND DRIVER'S SIDE THEY CONTINUED TO BURN OUT, AFTER TAKING THE BULB HOUSING COVER OFF, I NOTICED A BURNING SMELL AND THE BROWN WIRE IN THE UNIT HAD MELTED THE ENTIRE CONNECTION. I WAS TOLD BY MY LOCAL BMW DEALERSHIP THIS IS …
Read full complaint
FORMAL PETITION FOR SAFETY DEFECT INVESTIGATION, AFTER REPLACING THE TAIL LIGHT BULBS IN ON THE PASSENGER AND DRIVER'S SIDE THEY CONTINUED TO BURN OUT, AFTER TAKING THE BULB HOUSING COVER OFF, I NOTICED A BURNING SMELL AND THE BROWN WIRE IN THE UNIT HAD MELTED THE ENTIRE CONNECTION. I WAS TOLD BY MY LOCAL BMW DEALERSHIP THIS IS A KNOWN FLAW AS THE GROUND WIRE IS NOT ADEQUATE TO HANDLE THE POWER COMING THROUGH, THIS ISSUE HAS CAUSED ME TO ALMOST BE REAR-ENDED 4 TIMES WHEN THE LIGHT SUDDENLY WILL STOP WORKING BMW USA WHOM I CONTACTED IS AWARE OF THIS MALFUNCTION, AND HAS DONE NOTHING TO ADDRESS THIS ISSUE. *TR UPDATED 04/27/09. *JB
2003 BMW 325XI SUDDEN ACCELERATION. CAR ACCELERATES SUDDENLY WHEN BRAKES APPLIED TO PARK OR APPROACHING LIGHT OR STOP SIGN. NO ACCIDENTS, BUT IT IS SO DANGEROUS THAT IT IS AN ACCIDENT WAITING TO HAPPEN. ENGINE RAVES TO 4000 - 6000RPM, VERY HARD TO HOLD THE BRAKES. SO FAR I HAVE ONLY GOTTEN A MOVING VIOLATION TICKET FOR NOT S…
Read full complaint
2003 BMW 325XI SUDDEN ACCELERATION. CAR ACCELERATES SUDDENLY WHEN BRAKES APPLIED TO PARK OR APPROACHING LIGHT OR STOP SIGN. NO ACCIDENTS, BUT IT IS SO DANGEROUS THAT IT IS AN ACCIDENT WAITING TO HAPPEN. ENGINE RAVES TO 4000 - 6000RPM, VERY HARD TO HOLD THE BRAKES. SO FAR I HAVE ONLY GOTTEN A MOVING VIOLATION TICKET FOR NOT STOPPING AT THE STOP SIGN, WHILE RETURNING FROM THE THIRD BMW SERVICE INSPECTION AND BEING TOLD THAT THE CAR IS IN PERFECT CONDITION. BMW CAN NOT OBSERVE THE PROBLEM AND THEREFORE DOES NOT WANT TO FIX IT. I WAS TOLD THAT THEY NEVER HEARD OF THIS KIND OF PROBLEM AND PERHAPS I AM HITTING THE WRONG PEDAL. I HAVE WITNESSES THAT WERE IN A CAR WITH ME THAT THIS IS NOT THE CASE. IT ALSO HAPPENED WHILE MY HUSBAND DROVE THE CAR. BY RESEARCHING IT ON MY OWN I FOUND THAT THERE WAS A RECALL FOR 325I AND 325CI SERIES OF THE SAME YEAR THAT IS MINE. BECAUSE MY CAR IS 325XI SERVICE WOULD NOT EVEN TRY TO APPLY THE RECOMMENDED REMEDY. THE SERVICE IS TRYING, BUT I WAS TOLD THAT IT'S AGAINST THE BMW POLICY TO PROCEED WITHOUT EXPERIENCING THE ACTUAL PROBLEM TALKED TO BMW CUSTOMER SERVICE FOUR TIMES, VERY POLITE, BUT NO ACTION SO FAR. *TR
ERRATIC IDLE. . . WHEN STOPPED AT A STOP LIGHT, CAR IN NEUTRAL, THE RPMS REV IN SPIKES FROM 500 TO 1500, UP AND DOWN, UP AND DOWN. THE CAR NEVER RESETS TO A CONSTANT IDLE. CAR HAS BEEN IN SHOP 8 - 9 TIMES OVER 18 DAYS TOTAL. NO SOLUTION. TECH TOLD ME BMW KNOW OF PROBLEM BUT HAS NO PLANS TO FIND A FIX. *JB
I PURCHASED COOPER TIRES LAST SUMMER AND DO NOT HAVE 10,000 MILES ON THEM AND THEY ARE STARTING TO FALL APART. I HAD TO REPLACE ONE BECAUSE THEY SAID IT WAS DAMAGE BECAUSE OF A POT HOLE. NOW I HAVE ANOTHER ONE THAT HAS A KNOT IN IT AND I AM TOLD THAT IT IS DUE TO A STRESS FRACTURE IN THE TIRE CAUSE BY A POTHOLE.. IT SEEMS LIKE I…
Read full complaint
I PURCHASED COOPER TIRES LAST SUMMER AND DO NOT HAVE 10,000 MILES ON THEM AND THEY ARE STARTING TO FALL APART. I HAD TO REPLACE ONE BECAUSE THEY SAID IT WAS DAMAGE BECAUSE OF A POT HOLE. NOW I HAVE ANOTHER ONE THAT HAS A KNOT IN IT AND I AM TOLD THAT IT IS DUE TO A STRESS FRACTURE IN THE TIRE CAUSE BY A POTHOLE.. IT SEEMS LIKE I AM BEING TAKEN ADVANTAGE OF BECAUSE I AM A WOMAN AND BLONDE. TWO YEARS AGO MY DAUGHTER HAD TO HAVE ALL 4 OF HER TIRES REPLACED THAT WERE COOPER BECAUSE SHE WAS TOLD THAT THE RADIAL HAD FLAT SIDES. *JB
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA09019 · Rear Lamp Illumination
Opened Dec 18, 2009 · Closed Sep 28, 2011
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Additional source detail variants (4)
Exterior Lighting
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:brake Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:tail Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
PE09036 · Rear Lamp Illumination
Opened Aug 7, 2009 · Closed Dec 22, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Additional source detail variants (4)
Exterior Lighting
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:brake Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:tail Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
DP09002 · Rear Lamp Illumination
Opened Apr 8, 2009 · Closed Aug 6, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Additional source detail variants (5)
Exterior Lighting:back Up Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:brake Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:tail Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.