SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2005 Yamaha FZ6

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →
14Owner complaints

Model-year median: 14

0Recall campaigns

View recall details →

1Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
34
200414
20052
2006
Compare all FZ6 years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Engine And Engine Cooling
6Electrical System
4Fuel System, Gasoline
3Vehicle Speed Control
3Exterior Lighting
2
All reported categories
Engine
1Power Train
1Service Brakes, Hydraulic
1Tires
1Wheels
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 12 of 14 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Engine And Engine Cooling. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

What owners actually said

14 reports
Mileage unknown · Feb 25, 2022
Electrical SystemEngineVehicle Speed Control

Hello, i ride this Yamaha FZ-6 motorcycle and I experience poor idling and engine stalls during riding, and last time this nearly led to accident, because the motorcycle slowed down in front of an overpassing automobile. I have bought this bike imported from USA. I am situated in Bulgaria, Europe. I saw there is a recall action …

Read full complaint

Hello, i ride this Yamaha FZ-6 motorcycle and I experience poor idling and engine stalls during riding, and last time this nearly led to accident, because the motorcycle slowed down in front of an overpassing automobile. I have bought this bike imported from USA. I am situated in Bulgaria, Europe. I saw there is a recall action about faulty TPS sensor. Kindly requesting any help for replacing this sensor by recall action. Thank you in advance for your kind support. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI #11453978

5,225 miles · Feb 28, 2009
Engine And Engine Cooling

ENGINE OIL PAN CRACKED AFTER TORQUING DRAIN PLUG TO MANUFACTURERS SPEC. HAVE READ MANY OTHER COMPLAINTS OF THIS SAME OCCURRENCE. CONTACTED LOCAL DEALER AND YAMAHA AMERICA. BOTH DECLINED KNOWLEDGE OF DEFECT. YAMAHA AMERICA WAS QUITE SHORT, DID NOT WANT TO HEAR ANY DETAILS OF THE FAILURE, JUST STATED THAT THERE WERE NO RECALLS, AN…

Read full complaint

ENGINE OIL PAN CRACKED AFTER TORQUING DRAIN PLUG TO MANUFACTURERS SPEC. HAVE READ MANY OTHER COMPLAINTS OF THIS SAME OCCURRENCE. CONTACTED LOCAL DEALER AND YAMAHA AMERICA. BOTH DECLINED KNOWLEDGE OF DEFECT. YAMAHA AMERICA WAS QUITE SHORT, DID NOT WANT TO HEAR ANY DETAILS OF THE FAILURE, JUST STATED THAT THERE WERE NO RECALLS, ANY DEFECTS WERE NO LONGER UNDER WARRANTY. *TR

NHTSA ODI #10260324

4,000 miles · Sep 15, 2006
Electrical System

MY 2005 FZ6 RAN FLAWLESSLY TILL 4000 MILE THEN THE IDLE WAS DROPPING TO 600-800 AND THEN WOULD JUST DIE. I WOULD TURN KEY OFF AND TURN KEY ON AGAIN AND RESTART AND IT WOULD RUN FINE. IT HAPPENS TWICE A WEEK. ONCE ON WET PAVEMENT IT WAS FEELING BOGGISH I PULLED CLUTCH TO SEE AND IT WAS 600-800 AND DIED. I LET OUT CLUTCH AND A…

Read full complaint

MY 2005 FZ6 RAN FLAWLESSLY TILL 4000 MILE THEN THE IDLE WAS DROPPING TO 600-800 AND THEN WOULD JUST DIE. I WOULD TURN KEY OFF AND TURN KEY ON AGAIN AND RESTART AND IT WOULD RUN FINE. IT HAPPENS TWICE A WEEK. ONCE ON WET PAVEMENT IT WAS FEELING BOGGISH I PULLED CLUTCH TO SEE AND IT WAS 600-800 AND DIED. I LET OUT CLUTCH AND ALMOST LOST IT. I READ ABOUT SEVERAL OTHER OWNERS EXPERIENCING SAME PROBLEM AND SOME RUMOR IT TO THE TPS SENSOR. *JB

NHTSA ODI #10168366

17,648 miles · Jun 29, 2006
Vehicle Speed Control

MOTORCYCLE HAS BEEN IDLING POORLY AND STALLING WHEN COMING OFF INTERSTATE RIDING. GAS MILEAGE HAS ALSO BEEN DROPPING. ONLY RECENTLY, MOTORCYCLE STALLED IN CENTER LANE OF HIGHWAY AT TRAFFIC SIGNAL AT NIGHT, WOULD NOT RESTART. RECEIVED FAULT CODE 15 CORRESPONDING TO THROTTLE POSITION SENSOR. REPLACED PART. LEARNED OF SEVERAL OTHER…

Read full complaint

MOTORCYCLE HAS BEEN IDLING POORLY AND STALLING WHEN COMING OFF INTERSTATE RIDING. GAS MILEAGE HAS ALSO BEEN DROPPING. ONLY RECENTLY, MOTORCYCLE STALLED IN CENTER LANE OF HIGHWAY AT TRAFFIC SIGNAL AT NIGHT, WOULD NOT RESTART. RECEIVED FAULT CODE 15 CORRESPONDING TO THROTTLE POSITION SENSOR. REPLACED PART. LEARNED OF SEVERAL OTHER 2005 FZ6'S WITH SIMILAR PROBLEM. *NM

NHTSA ODI #10161041

3,690 miles · May 25, 2006
Fuel System, Gasoline

I WAS RIDING HOME ON MY 2005 YAMAHA FZ6 MOTORCYCLE, WHEN THE ENGINE BEGAN IDLING VERY ROUGH. I HAD TO ROLL ON THE THROTTLE TO KEEP THE ENGINE FROM STALLING. THEN A FEW SECONDS LATER I PULLED IN THE CLUTCH AND THE ENGINE STALLED COMPLETELY. I WAS NOT ABLE TO RESTART THE ENGINE AFTER 4 ATTEMPTS. THEN I TURNED THE IGNITION OFF, AND…

Read full complaint

I WAS RIDING HOME ON MY 2005 YAMAHA FZ6 MOTORCYCLE, WHEN THE ENGINE BEGAN IDLING VERY ROUGH. I HAD TO ROLL ON THE THROTTLE TO KEEP THE ENGINE FROM STALLING. THEN A FEW SECONDS LATER I PULLED IN THE CLUTCH AND THE ENGINE STALLED COMPLETELY. I WAS NOT ABLE TO RESTART THE ENGINE AFTER 4 ATTEMPTS. THEN I TURNED THE IGNITION OFF, AND TURNED IT BACK ON, AND THE ENGINE STARTED AS IF THERE WAS NO PROBLEM. OBVIOUSLY, TURNING THE IGNITION OFF AND BACK ON IS MERELY A BAND AID FOR THIS ISSUE, AND NOT A PERMANENT SOLUTION. PLEASE REFER TO THIS WEBSITE TO LEARN OF OTHER FZ6 OWNERS THAT HAVE EXPERIENCED THIS ISSUE. HTTP://FORUMS.SPORTBIKES.NET/FORUMS/SHOWTHREAD.PHP?T=7320 *JB

NHTSA ODI #10158254

4,800 miles · May 15, 2006
Engine And Engine CoolingVehicle Speed Control

I AM AWARE OF SEVERAL DOZEN PEOPLE WHO HAVE HAD THE SAME PROBLEM I AM NOW HAVING WITH FAILURE OF THE THROTTLE POSITION SENSOR (TPS) ON A 2004-2005 YAMAHA FZ6. THIS CAUSES A NEW VEHICLE TO RUN POORLY AND STALL FREQUENTLY UNTIL THE PART IS REPLACED. *JB

NHTSA ODI #10157605

9,500 miles · Dec 1, 2005
Tires

METZLER Z4 MOTORCYCLE TIRE (FRONT) INTERNAL BELT BREAKING LOOSE AT 65 MPH IN MORNING RUSH HOUR TRAFFIC. THE TIRE IMMEDIATELY BECAME SO OUT OF ROUND THAT THE MOTORCYCLE COULD NOT BE RIDDEN MORE THAN 5 MPH. *NM

NHTSA ODI #10144155

7,600 miles · Oct 12, 2005
Fuel System, Gasoline

ROUGH RUNNING AT SMALL THROTTLE OPENINGS, STALLING. NOT CORRECTED YET. *JB

NHTSA ODI #10139422

1,200 miles · Oct 5, 2005
Engine And Engine Cooling

DT: THE CALLER SAID THAT WHILE HE RIDING THE ENGINE ON MOTORCYCLE BROKE OPEN AND ALL THE FLUID SPRAYED OUT. THE CALLER WAS GOING ABOUT 60 MPH. HE ALMOST LOST CONTROL ,BUT WAS ABLE TO STOP AND GET OFF THE MOTORCYCLE. HE HAD TO HAVE IT TOWED. DEALER , WHOSAID THEY WILL LOOK AT IT. THE CALLER CONTACTED THE MANUFACTURER AND LEFT A…

Read full complaint

DT: THE CALLER SAID THAT WHILE HE RIDING THE ENGINE ON MOTORCYCLE BROKE OPEN AND ALL THE FLUID SPRAYED OUT. THE CALLER WAS GOING ABOUT 60 MPH. HE ALMOST LOST CONTROL ,BUT WAS ABLE TO STOP AND GET OFF THE MOTORCYCLE. HE HAD TO HAVE IT TOWED. DEALER , WHOSAID THEY WILL LOOK AT IT. THE CALLER CONTACTED THE MANUFACTURER AND LEFT A VOICE MAIL. MOTORCYCLE IS A YAMAHA R-1. *AK

NHTSA ODI #10138672

7,500 miles · Sep 25, 2005
Electrical System

THE MOTORCYCLE LOSES IGNITION, AS THOUGH THE "KILL SWITCH" WAS PRESSED. THE RPMS DROP TO ZERO AND THERE IS NO THROTTLE RESPONSE, ALTHOUGH LIGHTS AND GAUGES CONTINUE TO WORK. *JB

NHTSA ODI #10137531

Official recalls

0

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

PE06020 · Motorcycle Stalling

Opened May 23, 2006 · Closed Oct 5, 2006

Status: closed (inferred from source dates) · Fuel System, Other:fuel Injection System

OPERATORS REPORT THE MOTORCYCLE STALLS WHEN ROLLING OFF THE THROTTLE (E.G., TIP-OUT STALL WHILE APPROACHING A STOP) ALLEGEDLY DUE TO A FAULTY THROTTLE POSITION SENSOR (TPS).TO CORRECT THIS CONDITION, YAMAHA IS RECALLING THE SUBJECT VEHICLES TO INSTALL AN IMPROVED TPS.