IllustrationI HAVE A 33' 2004 TRAVEL TRAILER WITH ORIGINAL TIRES. IN MAY 2007 I HAD A BLOW OUT, AND AGAIN IN JULY, 2007 I HAD A SECON BLOW OUT. CARILSLE, RADIL TRAIL, ST 225 / 75R15, DOT 833AAD0094.*AK
2004 Wanderer 367WTB
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Other model years Selected year
Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 3 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Tires complaints
2 reports2 CARLISLE TRAILER TIRES BLEW OUT A MONTH APPART AND ONE CAUSED DAMAGE TO OUR NEW 36' 5TH WHEEL RV. WE BELIEVE THESE 16" TIRES TO BE DEFECTIVE AND A SERIOUS HAZARD WHEN TOWING A 5TH WHEEL OR TRAILER, AS THIS IS THE SECOND RV WE HAD WITH CARLISLE TIRES THAT HAD TREAD SEPARATION FOR NO REASON. WE LOST ALL 4 TIRES ON OUR PREVIOUS 2…
Read full complaint
2 CARLISLE TRAILER TIRES BLEW OUT A MONTH APPART AND ONE CAUSED DAMAGE TO OUR NEW 36' 5TH WHEEL RV. WE BELIEVE THESE 16" TIRES TO BE DEFECTIVE AND A SERIOUS HAZARD WHEN TOWING A 5TH WHEEL OR TRAILER, AS THIS IS THE SECOND RV WE HAD WITH CARLISLE TIRES THAT HAD TREAD SEPARATION FOR NO REASON. WE LOST ALL 4 TIRES ON OUR PREVIOUS 2000 25' WANDERER WAGON TRAVEL TRAILER IN THE FIRST YEAR; SO FAR WE HAVE LOST TWO ON THE 2004 36' 5TH WHEEL RV. PROPER INFLATION WAS ASSURED PRIOR TO TRAVEL AND TEMP WAS ONLY ABOUT 40 DEGREES OUTSIDE OF HAVASU, AZ. THE STEEL BELTS WRAPPED AROUND THE AXLE AND THE RUBBER TORE UP THE SIDE OF THE TRAILER, DAMAGE WAS $1,295.00. A MONTH LATER THE SECOND TIRE PEELED OFF IN THE SAME WAY BUT CAUSED NO DAMAGE, BUT MUCH INCONVENIENCE, AS IT WAS IN A BAD PLACE TO CHANGE IT, ON A MAJOR FREEWAY SHOULDER OF I-15 NEAR MESQUITE, NV. *AK
Official recalls
103V320000 · Power Train:axle Assembly
Aug 22, 2003
ON CERTAIN FIFTH WHEEL TRAILERS, DEPENDING UPON THE MANNER IN WHICH ITEMS ARE STORED IN THE TRAILER DURING TRANSIT AND THE CORRESPONDING WEIGHT DISTRIBUTION, THE TRAILER COULD BEGIN TO SWAY WHILE BEING TOWED.
Consequence & remedy
Consequence: THIS DEFECT COULD RESULT IN A VEHICLE CRASH INVOLVING BOTH THE TRAILER AND THE TOW VEHICLE, POSSIBLY RESULTING IN SERIOUS INJURY.
Remedy: THOR WILL NOTIFY ITS CUSTOMERS TO ARRANGE TO HAVE THE TRAILERS TRANSPORTED TO THOR CALIFORNIA'S FACTORY FOR REPAIR. OWNER NOTIFICATION AUGUST 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOR CALIFORNIA AT 1-888-697-8467.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.