This morning and a few days ago, ice cold water was dripping onto my control display pad and on me. The leakage came from the ourside down the plastic compartment behind my rearview mirror. This was distracting while I was driving since there was now water on me, and it was shorting out and affecting my control display. It woul…
Read full complaint
This morning and a few days ago, ice cold water was dripping onto my control display pad and on me. The leakage came from the ourside down the plastic compartment behind my rearview mirror. This was distracting while I was driving since there was now water on me, and it was shorting out and affecting my control display. It would continue to be buggy while driving. I believe this issue is a result from a cracked seal between the windshield and the car body. I have seen other documented cases on volvo forums.
NHTSA ODI #11602688
Mileage unknown · Oct 11, 2023
Visibility/wiper
Wipers began to turn on randomly without driver command causing distractions in a vehicle with 38,000 miles. There is a technical service bulletin about this issue (32366). It is known that the wipers will completely fail to work after an unknown, but rather short interval. Failed windshield wipers would render the vehicle unsaf…
Read full complaint
Wipers began to turn on randomly without driver command causing distractions in a vehicle with 38,000 miles. There is a technical service bulletin about this issue (32366). It is known that the wipers will completely fail to work after an unknown, but rather short interval. Failed windshield wipers would render the vehicle unsafe to operate, therefore we elected for Immediate repair. The repair was in excess of $1,500 and the manufacturer refused to pay for the repair out of warranty.
NHTSA ODI #11549503
5,000 miles · Nov 9, 2018
Visibility/wiperCrash
VOLVO XC90 2018 MODELS WILL NOT ALWAYS DISPLAY REAR VIEW CAMERA CONTENT WITHIN 2 SECONDS OF SHIFTING INTO REVERSE AS PER FMVSS 111. THIS IS DUE TO REALLY SLOW AND LAGGING INFOTAINMENT SYSTEM. BEHAVIOR IS EVIDENT ON MULTIPLE MODELS AND VEHICLES WHICH SHARE SAME SENSUS INFOTAINMENT SYSTEM.
NHTSA ODI #11150284
1,250 miles · Mar 19, 2018
Visibility/wiper
CRACKED WINDSHIELD EVEN WITH LESS THAN MINOR CHIP. THE CAR WAS DRIVING AT 68MPH ON A STRAIGHT HIGHWAY ON A 'CLIP' SOUND WAS HEARD HITTING THE WINDSHIELD. AFTER 10 MINUTES A 14 INCH CRACK WAS NOTED FROM THE TOP EDGE TO THE CENTER OF THE WINDSHIELD. THE CAR HAS <2000 MILES ON IT. IS THE QUALITY OF WINDSHIELD WORSE IN CARS WITH…
Read full complaint
CRACKED WINDSHIELD EVEN WITH LESS THAN MINOR CHIP. THE CAR WAS DRIVING AT 68MPH ON A STRAIGHT HIGHWAY ON A 'CLIP' SOUND WAS HEARD HITTING THE WINDSHIELD. AFTER 10 MINUTES A 14 INCH CRACK WAS NOTED FROM THE TOP EDGE TO THE CENTER OF THE WINDSHIELD. THE CAR HAS <2000 MILES ON IT. IS THE QUALITY OF WINDSHIELD WORSE IN CARS WITH DRIVER ASSISTANCE PACKAGES. HAVE DRIVEN DIFFERENT VEHICLES WITHOUT DRIVER ASSISTANCE AND NEVER ENCOUNTERED SUCH AN INCIDENT. THE EXTENT OF CRACK WITH A CHIP (WHICH IS NOT EVEN VISIBLE), IS QUITE SURPRISING. I HOPE NHTSA WILL LOOK INTO THIS. IS THIS ISOLATED TO THIS VEHICLE MANUFACTURER OR WITH MOST MANUFACTURER WINDSHIELDS WITH DRIVER ASSISTANCE PACKAGES. THIS MAY BE LIFE-THREATENING IF THE GLASS IS NOT STRONG ENOUGH AND SHATTER WITH SUCH MINOR ROAD HAZARDS.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.
Consequence & remedy
Consequence: An improperly tightened seat belt buckle may not restrain an occupant as intended, increasing their risk of injury during a crash.
Remedy: Dealers will inspect and tighten the second-row seat belt buckle anchorage bolts, as necessary, free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10259.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2016-2020 XC90 Excellence vehicles. Liquid or condensation on the rear seat control display may cause the front passenger seat to move back as far as possible.
Consequence & remedy
Consequence: The rear passenger may become trapped by the front seat without the ability to cancel the seat's movement, increasing the risk of injury.
Remedy: Volvo Car will notify owners, and dealers will update the rear seat control display software, free of charge. Owner notification letters were mailed July 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10093.
Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improperly. As a result, the GPS will not provide location information to emergency personnel in the event of an emergency.
Consequence & remedy
Consequence: If the GPS location is not provided to emergency personnel it can inhibit emergency response in the event of a crash or injury.
Remedy: Volvo will notify owners, and dealers will correct the software, free of charge. The recall began December 26, 2018. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R39917.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2018 Volvo XC90 Problems, Complaints & Recalls | Skip That Year
Illustration