3 weeks ago we had the transmission module fail on our vehicle while it was being driven. According to Volvo forums, this is a multi-model year, multi vehicle issue for those with sunroofs. Accrding to the dealer in our case, the seal failed, and water runs into the compartment where the transmission module is located, causing …
Read full complaint
3 weeks ago we had the transmission module fail on our vehicle while it was being driven. According to Volvo forums, this is a multi-model year, multi vehicle issue for those with sunroofs. Accrding to the dealer in our case, the seal failed, and water runs into the compartment where the transmission module is located, causing it to fail. We had it happen twice, and both times on the highway, with the engine running ragged causing it ot accelerate and then quickly decelerate. There were 3 warnings that popped up-"Gear lever locked," "transmission acceleration performance reduced," and "Parking Brake unaavialble." It happened twice and and was towed to the dealer both times, as it was not drivable-once the vehicle was parked it would no longer move out of park. The first time the diagnosis and module reset was comped by the dealer (Borton Volvo, Golden Valley, MN) and the second time, the transmission module was "dried out," and the sunroof seal was replaced, which was just under $700. It is available to be inspected if necessary. The vehicle was a hazard to others on the road while it was "acting up." Dealer was familia with the issue. No inspection was done other than by the dealer Warning lamps as outlined above
The car starting leaking water into the rear view mirror in June. This wouldn’t be much of an issue, but the cars computer system for drive assist is located in this area and has caused the car to malfunction in all areas. This XC90 pilot assist is now malfunctioning causing a huge safety issue. This is apparently a known proble…
Read full complaint
The car starting leaking water into the rear view mirror in June. This wouldn’t be much of an issue, but the cars computer system for drive assist is located in this area and has caused the car to malfunction in all areas. This XC90 pilot assist is now malfunctioning causing a huge safety issue. This is apparently a known problem with their cars with the panoramic sunroof, but is now a safety hazard. The Volvo dealership did not fix the issue and is now happening again effecting all of the electrical system.
NHTSA ODI #11499816
13,580 miles · May 8, 2021
Forward Collision Avoidance
CAR SUDDENLY ACTIVATED THE BRAKES, BRINGING IT TO A FULL STOP FROM 35MPH. IT WAS ON A CITY STREET. THERE WAS A 3-WHEELED MOTORCYCLE APPROACHING IN THE ONCOMING LANE, BUT IT WAS CENTERED IN ITS LANE, WITH NO RISK OF COLLISION. WE WERE APPROACHING AN UNCONTROLLED INTERSECTION (NO SIGNAL, NO SIGNS) WHEN IT OCCURRED. THE CAR STOPPED…
Read full complaint
CAR SUDDENLY ACTIVATED THE BRAKES, BRINGING IT TO A FULL STOP FROM 35MPH. IT WAS ON A CITY STREET. THERE WAS A 3-WHEELED MOTORCYCLE APPROACHING IN THE ONCOMING LANE, BUT IT WAS CENTERED IN ITS LANE, WITH NO RISK OF COLLISION. WE WERE APPROACHING AN UNCONTROLLED INTERSECTION (NO SIGNAL, NO SIGNS) WHEN IT OCCURRED. THE CAR STOPPED SO SUDDENLY THAT THE SHOULDER HARNESSES CAUSED SOME DISCOMFORT. HAD ANYONE BEEN FOLLOWING AT A CLOSE DISTANCE, A REAR-END COLLISION WOULD HAVE BEEN LIKELY.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.
Consequence & remedy
Consequence: An improperly tightened seat belt buckle may not restrain an occupant as intended, increasing their risk of injury during a crash.
Remedy: Dealers will inspect and tighten the second-row seat belt buckle anchorage bolts, as necessary, free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10259.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2016-2020 XC90 Excellence vehicles. Liquid or condensation on the rear seat control display may cause the front passenger seat to move back as far as possible.
Consequence & remedy
Consequence: The rear passenger may become trapped by the front seat without the ability to cancel the seat's movement, increasing the risk of injury.
Remedy: Volvo Car will notify owners, and dealers will update the rear seat control display software, free of charge. Owner notification letters were mailed July 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10093.
Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improperly. As a result, the GPS will not provide location information to emergency personnel in the event of an emergency.
Consequence & remedy
Consequence: If the GPS location is not provided to emergency personnel it can inhibit emergency response in the event of a crash or injury.
Remedy: Volvo will notify owners, and dealers will correct the software, free of charge. The recall began December 26, 2018. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R39917.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2018 Volvo XC90 Problems, Complaints & Recalls | Skip That Year
Illustration