The contact owns a 2017 Volvo XC90. The contact stated that after a rainstorm, there was water leaking from the rearview mirror, which leaked into the vehicle, causing the electrical system to fail. There was an abnormal sound of water swishing around inside the vehicle. The on-call warning and check engine warning lights were i…
Read full complaint
The contact owns a 2017 Volvo XC90. The contact stated that after a rainstorm, there was water leaking from the rearview mirror, which leaked into the vehicle, causing the electrical system to fail. There was an abnormal sound of water swishing around inside the vehicle. The on-call warning and check engine warning lights were illuminated. The vehicle was taken to the local dealer, where it was diagnosed with a cracked sunroof cassette leak. The vehicle was not repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 147,000.
NHTSA ODI #11645958
Mileage unknown · May 22, 2023
StructureSuspension
The 2017 Volvo xc90 hybrid regularly experiences these two issues when it is below freezing in Montana: 1) doors do not catch in the latch so they do not close and/or will fly open when turning. This occurs every time the temperature is below zero. 2) when below zero temperature occurs,
NHTSA ODI #11523326
Mileage unknown · Sep 26, 2022
Structure
Rear passenger doors would get locked stuck, and can not get unlocked from inside or outside. This issue would remain even after locking/unlocking car multiple times or enabling/disabling child lock multiple times. Dealer suggested this is common issue in this model of the car, and needs an expensive repair of the latch mechani…
Read full complaint
Rear passenger doors would get locked stuck, and can not get unlocked from inside or outside. This issue would remain even after locking/unlocking car multiple times or enabling/disabling child lock multiple times. Dealer suggested this is common issue in this model of the car, and needs an expensive repair of the latch mechanism. This is a safety hazard as this would would trap the passengers inside the car in case of accident or any other emergency. Please look in to this matter, this should not be happening in a relatively new(5 years), low mileage, always garaged car like Volvo.
NHTSA ODI #11486539
Mileage unknown · Mar 3, 2021
Electrical SystemStructureUnknown Or Other
FOR 5 MONTHS NOW, THERE HAS BEEN LEAKING FROM THE REAR SIDE OF THE INTELLISAFE MODULE LOCATED BY THE MIDDLE TOP OF THE WINDSHIELD. I HAVE TAKEN THE CARE TO THE DEALERSHIP IN MULTIPLE LOCATIONS, THEY HAVE NOT FOUND THE ROOT CAUSE. I HAVE PAID FOR MULTIPLE REPLACEMENTS OF THE RUBBER TRIM AND CLEANING OF INTERIOR PARTS. THE WATER L…
Read full complaint
FOR 5 MONTHS NOW, THERE HAS BEEN LEAKING FROM THE REAR SIDE OF THE INTELLISAFE MODULE LOCATED BY THE MIDDLE TOP OF THE WINDSHIELD. I HAVE TAKEN THE CARE TO THE DEALERSHIP IN MULTIPLE LOCATIONS, THEY HAVE NOT FOUND THE ROOT CAUSE. I HAVE PAID FOR MULTIPLE REPLACEMENTS OF THE RUBBER TRIM AND CLEANING OF INTERIOR PARTS. THE WATER LEAKS DIRECTLY OVER THE HEAD UNIT, AND I FEAR THAT MIGHT CAUSE DAMAGE SUCH AS A ELECTRICAL FIRE OR REPLACEMENT OF PARTS THAT MIGHT BECOME VERY COSTLY. IT HAPPENS WHILE STILL IN PARK AND WHILE DRIVING.
NHTSA ODI #11398899
19,000 miles · Oct 22, 2018
Electrical SystemEngineStructureFire
WHILE DRIVING WITH TWO YOUNG CHILDREN IN CAR, VOLVO HOOD STARTED TO SMOKE. NO WARNING LIGHTS OR SIGNALS WENT OFF. WE PULLED OVER, TURNED ENGINE OFF, REMOVED KIDS FROM THE CAR, AND WITHIN A FEW MINUTES, THE ENTIRE HOOD OF THE CAR WAS IN FLAMES. THE CAR WAS COMPLETELY DESTROYED, EVEN THOUGH FIREFIGHTERS EXTINGUISHED THE FIRE. …
Read full complaint
WHILE DRIVING WITH TWO YOUNG CHILDREN IN CAR, VOLVO HOOD STARTED TO SMOKE. NO WARNING LIGHTS OR SIGNALS WENT OFF. WE PULLED OVER, TURNED ENGINE OFF, REMOVED KIDS FROM THE CAR, AND WITHIN A FEW MINUTES, THE ENTIRE HOOD OF THE CAR WAS IN FLAMES. THE CAR WAS COMPLETELY DESTROYED, EVEN THOUGH FIREFIGHTERS EXTINGUISHED THE FIRE. WE HAVE NO INFORMATION AS TO THE CAUSE OF THE FIRE - ENGINE, ELECTRICAL, ETC - BUT THE CAR ONLY HAD 18,000 MILES ON IT. VOLVO HAD ALREADY REPLACED THE ROTORS TWICE IN TWO YEARS - HIGHLY UNUSUAL - BUT OTHERWISE WE HAD NO REASON TO SUSPECT A PROBLEM. WE WERE VERY LUCKY WE WERE ON CITY STREETS AND NOT ON THE HIGHWAY WHERE IT WOULD HAVE BEEN DIFFICULT TO IMPOSSIBLE TO PULL OVER.
NHTSA ODI #11141828
18,000 miles · Feb 2, 2018
EngineStructureUnknown Or OtherFire
NEW VEHICLE (LESS THAN 19000 MILES) - VEHICLE WAS STATIONARY - IN A PARKING LOT, IGNITION OFF. APPROXIMATELY 10 TO 15 MINUTES LATER, FIRE IGNITED IN ENGINE BAY, RAPIDLY SPREADING TO THE WHOLE CAR... ENTIRE CARE BURNED TO SHELL.
NHTSA ODI #11066597
7,500 miles · Jan 28, 2017
Structure
PASSENGER DOORS (FRONT AND BACK) UNLOCK ON THEIR OWN WHILE DRIVING AND OPEN /BECOME AJAR. INTERIOR LIGHTS COME ON AND ALARM SOUNDS OFF.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.
Consequence & remedy
Consequence: An improperly tightened seat belt buckle may not restrain an occupant as intended, increasing their risk of injury during a crash.
Remedy: Dealers will inspect and tighten the second-row seat belt buckle anchorage bolts, as necessary, free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10259.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2016-2020 XC90 Excellence vehicles. Liquid or condensation on the rear seat control display may cause the front passenger seat to move back as far as possible.
Consequence & remedy
Consequence: The rear passenger may become trapped by the front seat without the ability to cancel the seat's movement, increasing the risk of injury.
Remedy: Volvo Car will notify owners, and dealers will update the rear seat control display software, free of charge. Owner notification letters were mailed July 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10093.
Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improperly. As a result, the GPS will not provide location information to emergency personnel in the event of an emergency.
Consequence & remedy
Consequence: If the GPS location is not provided to emergency personnel it can inhibit emergency response in the event of a crash or injury.
Remedy: Volvo will notify owners, and dealers will correct the software, free of charge. The recall began December 26, 2018. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R39917.
Volvo Car USA LLC (Volvo) is recalling certain 2017 XC90 vehicles. The Micro Gas Generator (MGG), a subcomponent part used within the right hand side seat belt retractor for the third row seats, may detach after the seatbelt retractor pretensioner is deployed.
Consequence & remedy
Consequence: Although, the seat belt will operate as intended in the event of a crash, if the MGG detaches, it may be a projectile within the vehicle cabin, increasing the risk of injury.
Remedy: Volvo will notify owners, and dealers will replace the third row passenger's side seatbelt retractor, free of charge. The recall began August 4, 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89716.
Volvo Car USA LLC (Volvo) is recalling certain 2017 XC90, S90, and V90 Cross Country vehicles. The bolts that secure the Inflatable Curtain (IC) air bags in place may break, possibly resulting in the IC air bag deploying improperly in the event of a crash. As, such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Consequence & remedy
Consequence: If the IC air bags do not deploy properly in the event of a crash, the vehicle occupants have an increased risk of injury.
Remedy: Volvo will notify owners, and dealers will inspect and replace the bolts, as necessary, free of charge. The recall is expected to begin April 1, 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89714.
Volvo Car USA LLC (Volvo) is recalling certain model year 2016-2017 XC90, S90, XC60, V60 Cross Country, V60, S60 Cross Country, S60, and S60 Inscription vehicles manufactured February 16, 2015, to August 22, 2016. On the affected vehicles, the front passenger seat belt buckle attaching stud may loosen, allowing the buckle to separate from the seat belt bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages" and number 209, "Seat Belt Assemblies."
Consequence & remedy
Consequence: If the seat belt buckle separates from the bracket, the front seat passenger may not be adequately restrained in the event of a crash, increasing their risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will inspect the front passenger seat belt buckle stud, replacing the seat belt buckle as needed, free of charge. The recall began January 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89708.
Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2016-2017 Volvo XC90 and S90 vehicles manufactured April 15, 2015 through September 19, 2016. In the affected vehicles, the drain hose for the air conditioning may leak into the passenger compartment due to a drain hose installation error during manufacturing.
Consequence & remedy
Consequence: Significant water drainage into the passenger compartment may adversely affect air bag deployment in the event of a crash, increasing the risk of occupant injury.
Remedy: Volvo will notify owners, and dealers will inspect the air conditioning drain hose for proper installation, replacing the hose as necessary, free of charge. The recall is expected to begin on November the 14, 2016. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R89707.
Additional source detail variants (2)
Equipment:appliance:air Conditioner
Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2016-2017 Volvo XC90 and S90 vehicles manufactured April 15, 2015 through September 19, 2016. In the affected vehicles, the drain hose for the air conditioning may leak into the passenger compartment due to a drain hose installation error during manufacturing.
Consequence: Significant water drainage into the passenger compartment may adversely affect air bag deployment in the event of a crash, increasing the risk of occupant injury.
Remedy: Volvo will notify owners, and dealers will inspect the air conditioning drain hose for proper installation, replacing the hose as necessary, free of charge. The recall is expected to begin on November the 14, 2016. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R89707.
Air Bags
Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2016-2017 Volvo XC90 and S90 vehicles manufactured April 15, 2015 through September 19, 2016. In the affected vehicles, the drain hose for the air conditioning may leak into the passenger compartment due to a drain hose installation error during manufacturing.
Consequence: Significant water drainage into the passenger compartment may adversely affect air bag deployment in the event of a crash, increasing the risk of occupant injury.
Remedy: Volvo will notify owners, and dealers will inspect the air conditioning drain hose for proper installation, replacing the hose as necessary, free of charge. The recall is expected to begin on November the 14, 2016. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R89707.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2017 Volvo XC90 Problems, Complaints & Recalls | Skip That Year
Illustration