IllustrationVehicle is slightly off-balance no matter if I do an alignment ball joints seem to always get affected. I’m not sure if the hydraulics are working correctly. Yesterday I just started leaking antifreeze fluid.
2006 Volvo XC90
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Volvo XC90 do not stand out strongly from the model-year median of 34.
About this comparison →How this year compares
Owner complaints by model year
Compare all XC90 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
525–50K
350–75K
275–100K
14100–150K
5150K+
41 reports with mileage · 12 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports4 fire reports3 injury reports
Suspension complaints
3 reportsTL* THE CONTACT OWNS A 2006 VOLVO XC90. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD PULL TO THE RIGHT. THE VEHICLE WAS TAKEN TO CRIPPEN VOLVO (8300 W. SAGINAW HWY, LANSING, MI), BUT THE FAILURE COULD NOT BE DUPLICATED. APPROXIMATELY ONE MONTH LATER, WHILE DRIVING 70 MPH, THE VEHICLE SUDDENLY PULLED HARD TO THE RIGHT AND THE …
Read full complaint
TL* THE CONTACT OWNS A 2006 VOLVO XC90. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD PULL TO THE RIGHT. THE VEHICLE WAS TAKEN TO CRIPPEN VOLVO (8300 W. SAGINAW HWY, LANSING, MI), BUT THE FAILURE COULD NOT BE DUPLICATED. APPROXIMATELY ONE MONTH LATER, WHILE DRIVING 70 MPH, THE VEHICLE SUDDENLY PULLED HARD TO THE RIGHT AND THE DRIVER NEARLY LOST CONTROL OF THE STEERING. AFTER STOPPING THE VEHICLE, IT WAS DISCOVERED THAT THE FRONT PASSENGER SIDE TIE ROD BALL JOINT FAILED AND THE WHEELS WERE NOT PROPERLY POSITIONED. THE VEHICLE WAS TOWED TO AN UNKNOWN DEALER AND THE TIE ROD WAS DAMAGED. THE CONTACT INDICATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V155000 (STEERING) ALTHOUGH THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. ALSO, ON SEVERAL OCCASIONS, THE VEHICLE COULD NOT BE IMMEDIATELY STARTED. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY SHUT OFF AND CAUSED THE POWER STEERING AND POWER BRAKES TO BECOME INOPERABLE. THE CAUSE OF THE FAILURES WAS NOT DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 130,000. *TT*JB
I HAVE HAD MULTIPLE ISSUES WITH THE SUSPENSION OF THIS CAR IN THE PAST TWO YEARS.- UP UNTIL RECENTLY, THESE WERE THE ONLY PROBLEMS I HAD WITH THE CAR. FIRST THE STRUT ENGINE MOUNT BRACE AND TORQUE RODS NEEDED REPLACING, THEN AT 155,000 I NEEDED TO HAVE THE FRONT BALL JOINT,CONTROL ARMS AND BUSHINGS REPLACED. AT 158,000 I …
Read full complaint
I HAVE HAD MULTIPLE ISSUES WITH THE SUSPENSION OF THIS CAR IN THE PAST TWO YEARS.- UP UNTIL RECENTLY, THESE WERE THE ONLY PROBLEMS I HAD WITH THE CAR. FIRST THE STRUT ENGINE MOUNT BRACE AND TORQUE RODS NEEDED REPLACING, THEN AT 155,000 I NEEDED TO HAVE THE FRONT BALL JOINT,CONTROL ARMS AND BUSHINGS REPLACED. AT 158,000 I HAD TO REPLACE THE RIGHT REAR KNUCKLE AND WHEEL BEARINGS. NOW AT 189,000 I HAVE A PROBLEM WITH MY OUTER TIE RODS. I HAD JUST THOUGHT THESE WERE EXPECTED WEAR AND TEAR FOR A HIGH MILEAGE VEHICLE, BUT I SAW THAT THERE HAD BEEN RECALLS FOR FAILURES OF THESE PARTS IN SOME VERSIONS OF MY CAR. I CHECKED WITH VOLVO AND THEY CLAIMED THAT MY VIN WAS NOT INCLUDED IN THESE RECALLS. BUT I DO FIND IT SUSPICIOUS THAT I NOW AM HAVING THE SAME ISSUES THAT SO MANY "OTHER VERSIONS" OF MY MODEL AND YEAR VEHICLE HAD. SHOULD MY CAR HAVE BEEN INCLUDED IN THE RECALLS? HOW DO THEY DETERMINE WHICH ONES HAVE A PROBLEM AND WHICH ONES DO NOT? THANKS *TR
Official recalls
310V566000 · Equipment:electrical:navigational System(global Positioning System)
Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
06V155000 · Steering:linkages:tie Rod Assembly
May 5, 2006
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Consequence & remedy
Consequence: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
06V144000 · Visibility:windshield Wiper/washer
Apr 28, 2006
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Consequence & remedy
Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.