IllustrationSeal around the top of the windshield has failed and worn out. You are now able to press on the windshield and have it unseat from the car frame
2010 Volvo XC60
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2010 Volvo XC60 do not stand out strongly from the model-year median of 36.
About this comparison →How this year compares
Owner complaints by model year
Compare all XC60 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
425–50K
350–75K
1175–100K
5100–150K
2150K+
37 reports with mileage · 19 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility/wiper. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports1 fire reports1 injury reports
Visibility complaints
5 reportsTL* THE CONTACT OWNS A 2010 VOLVO XC60. THE CONTACT NOTICED THAT THERE WAS LEAKAGE COMING FROM THE WINDSHIELD ON THE PASSENGER'S SIDE OF THE VEHICLE. THE CONTACT STATED THAT THE INSURANCE ADJUSTER DISCOVERED THAT THERE WAS AN ADHESIVE BONDING FAILURE WITH THE WINDSHIELD. THE CONTACT CONTACTED BILL GRAY VOLVO CARS (2897 WASHINGTO…
Read full complaint
TL* THE CONTACT OWNS A 2010 VOLVO XC60. THE CONTACT NOTICED THAT THERE WAS LEAKAGE COMING FROM THE WINDSHIELD ON THE PASSENGER'S SIDE OF THE VEHICLE. THE CONTACT STATED THAT THE INSURANCE ADJUSTER DISCOVERED THAT THERE WAS AN ADHESIVE BONDING FAILURE WITH THE WINDSHIELD. THE CONTACT CONTACTED BILL GRAY VOLVO CARS (2897 WASHINGTON RD, MCMURRAY, PA 15317, (724) 949-1555) AND WAS INFORMED TO HAVE THE VEHICLE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.
IT HAS BEEN VERY COLD HERE IN GERMANY. OUR TEMPERATURES HAVE DROPPED BELOW ZERO. I WENT OUTSIDE ON THE 20TH TO CLEAN OFF THE SNOW FROM MY CAR. I WALKED UPON MY DRIVERS SIDE WINDOW SHATTERED INTO A MILLION PIECES. MY CAR WAS TOWED TO THE DEALER ONLY TO FIND IT'S NOT UNDER WARRANTY. I LOVE MY VOLVO, I HAVE ONLY HAD IT FOR TWO MONT…
Read full complaint
IT HAS BEEN VERY COLD HERE IN GERMANY. OUR TEMPERATURES HAVE DROPPED BELOW ZERO. I WENT OUTSIDE ON THE 20TH TO CLEAN OFF THE SNOW FROM MY CAR. I WALKED UPON MY DRIVERS SIDE WINDOW SHATTERED INTO A MILLION PIECES. MY CAR WAS TOWED TO THE DEALER ONLY TO FIND IT'S NOT UNDER WARRANTY. I LOVE MY VOLVO, I HAVE ONLY HAD IT FOR TWO MONTHS AND NOW WE HAVE TO COME OUT OF THE POCKET FOR SOMETHING THAT HAPPENED WEATHER RELATED. *TR
1. CAN BARELY SEE OUT OF INSIDE REARVIEW MIRROR IN THE DAYTIME. PARTICULARLY HAZARDOUS IF CARS FOLLOWING DO NOT HAVE THEIR HEADLIGHTS ON. VOLVO SAYS THEY CANNOT LIGHTEN/CORRECT THE AUTO DIMMING MIRROR. 2. BLIS SYSTEM IS NOT RELIABLE FOR CARS IN BLIND SPOT AND SHOULD BE IGNORED. HOWEVER, IT CANNOT BE TURNED OFF. RES…
Read full complaint
1. CAN BARELY SEE OUT OF INSIDE REARVIEW MIRROR IN THE DAYTIME. PARTICULARLY HAZARDOUS IF CARS FOLLOWING DO NOT HAVE THEIR HEADLIGHTS ON. VOLVO SAYS THEY CANNOT LIGHTEN/CORRECT THE AUTO DIMMING MIRROR. 2. BLIS SYSTEM IS NOT RELIABLE FOR CARS IN BLIND SPOT AND SHOULD BE IGNORED. HOWEVER, IT CANNOT BE TURNED OFF. RESPONSE FROM VOLVO: HI , THANK YOU FOR CONTACTING VOLVO CARS OF NORTH AMERICA. THE AUTO-DIM REARVIEW MIRROR IS UNABLE TO BE LIGHTENED FOR DAYTIME USE. THERE IS NO PERMANENT SHUT-OFF FOR THE BLIS FUNCTION IN YOUR VEHICLE. OF COURSE, IT CAN BE SHUT OFF DURING USE, BUT MUST BE DONE MANUALLY EACH TIME THE VEHICLE IS STARTED. THANK YOU FOR ALLOWING US THE OPPORTUNITY TO RESPOND. DRIVE SAFELY, VOLVO CARS OF NORTH AMERICA*TR
REAR WINDOW IN 2010 VOLVO XC60 EXPLODED AFTER SMALL IMPACT INTO THOUSANDS OF VERY SHARP SHARDS (NOT THE "PEBBLES" AS IS SUPPOSED TO HAPPEN). SHARDS WERE SENT THROUGHOUT THE CABIN INCLUDING TO THE PASSENGER SEATS, WINDSCREEN, SPEEDO, ETC. THIS DOES NOT SEEM THE APPROPRIATE WAY FOR TEMPERED GLASS TO BEHAVE. *TR
Official recalls
720V378000 · Seat Belts:front
Jun 30, 2020
Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.
Consequence & remedy
Consequence: An unsecured occupant has an increased risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.
10V591000 · Seats
Nov 22, 2010
VOLVO IS RECALLING CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER FRONT PASSENGER SEATS. THE FRONT SEAT RAIL'S DETECTION SYSTEM WAS MANUFACTURED INCORRECTLY AND MAY PERMIT THE PASSENGER TO FORWARD THE SEAT BEYOND THE INTENDED MAXIMUM.
Consequence & remedy
Consequence: POSITIONING OF THE SEAT BEYOND THE INTENDED MAXIMUM CAN CAUSE INCREASED RISK OF INJURY TO THE PASSENGER IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE FRONT POWER SEAT STOPS FOR BOTH FRONT SEATS FOR THE PRESENCE OF AN "END STOP" AND REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 23, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT CUSTOMERCARE@VOLVOFORLIFE.COM.
10V564000 · Air Bags
Nov 10, 2010
VOLVO IS RECALLING CERTAIN MODEL YEAR 2010 XC60 VEHICLES. THE CURTAIN AIR BAGS MAY HAVE BEEN MIS-ASSEMBLED DURING THE MANUFACTURING PROCESS. THIS MAY CAUSE AN AIR BAG TO NOT DEPLOY OR NOT DEPLOY AS INTENDED.
Consequence & remedy
Consequence: IF THE CURTAIN AIR BAG DOES NOT PERFORM AS INTENDED IN THE EVENT OF A VEHICLE CRASH NECESSITATING DEPLOYMENT OF THAT AIR BAG, IT MAY NOT PROPERLY PROTECT THE OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE LEFT AND RIGHT CURTAIN AIR BAG ASSEMBLY AND ADJUST IF NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 9, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT CUSTOMERCARE@VOLVOFORLIFE.COM.
09V477000 · Fuel System, Other
Dec 15, 2009
VOLVO IS RECALLING MODEL YEAR 2010 XC60 VEHICLES. THE FUEL LINE RAIL COVER THAT PROTECTS THE FUEL LINES UNDER THE VEHICLE MAY NOT BE PROPERLY ATTACHED EXPOSING THE FUEL LINES TO DAMAGE.
Consequence & remedy
Consequence: DAMAGE TO THE FUEL LINES MAY RESULT IN A FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL LINE RAIL COVER FOR PROPER ATTACHMENT AND REATTACH IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 28, 2009. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
09V463000 · Structure:body:roof And Pillars
Dec 1, 2009
VOLVO IS RECALLING MODEL YEAR 2010 XC60 VEHICLES BUILT WITHOUT THE PANORAMIC ROOF AND DELIVERED TO PUERTO RICO FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THE FRONT SEAT OCCUPANTS MAY NOT HAVE PROPER PROTECTION.
Remedy: THESE FOUR VEHICLES ARE IN THE POSSESSION OF DEALERS IN PUERTO RICO AND DEALERS WILL REPLACE THE HEADLINER IN THE VEHICLE PRIOR TO SALE.
09V445000 · Seats
Nov 18, 2009
VOLVO IS RECALLING MODEL YEAR 2010 XC60 VEHICLES. THE DRIVER'S SEAT SIDE COVER PANEL (SEAT CONTROL PANEL) IN CERTAIN DRIVER'S SIDE IMPACTS MAY RELEASE THE ATTACHMENT OF THE SEATBELT TO THE SEAT FRAME.
Consequence & remedy
Consequence: SHOULD THIS CONDITION OCCUR IN A CRASH THE SEATBELT MAY FAIL TO PROPERLY RESTRAIN THE OCCUPANT INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL MODIFY THE INSIDE OF THE DRIVER'S SEAT SIDE COVER PANEL FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 22, 2009. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
09V343000 · Electrical System:software
Sep 1, 2009
VOLVO IS RECALLING MY 2008-2010 S80, MODEL YEAR 2009-2010 XC70 AND MODEL YEAR 2010 XC60 VEHICLES. UNDER CERTAIN CONDITIONS THE SOFTWARE WITHIN THE CENTRAL ELECTRONIC MODULE (CEM) MAY NOT SEND A SIGNAL TO THE FUEL PUMP ELECTRONIC MODULE (PEM). THIS MISSING SIGNAL TO THE PEM INHIBITS THE START OF THE FUEL PUMP. THE DRIVER MAY BE ABLE TO START THE ENGINE IN SPITE OF THE FUEL PUMP NOT BEING ACTIVATED DUE TO RESIDUAL PRESSURE IN THE FUEL SYSTEM. IN SOME CASES, THE DRIVER MAY BE ABLE TO DRIVE THE VEHICLE A SHORT DISTANCE AT IDLE BUT THEN THE ENGINE MAY STALL.
Consequence & remedy
Consequence: IF THE VEHICLE STALLS IN CERTAIN CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL DOWNLOAD SOFTWARE TO THE VEHICLES' CEM FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2009. VEHICLES IN DEALER'S INVENTORY WILL BE REPAIRED PRIOR TO DELIVERY. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.