2019 Volvo XC40

The driver side liftgate strut broke; the liftgate raised normally and when reached the fully opened position it immediately started to close very rapidly, this could have easily hit someone quite hard in the head. The Liftgate was then stuck in a halfway opened position and was unable to close fully. I was able to manually raise the liftgate and when released again slammed down to a halfway open position, and sill could not close the liftgate. I raised it again and propped it open and removed the driver side lift strut and noticed that water had severely infiltrated the strut mechanism and corroded the springs to the point of failure; the spring were broken in many places. There were no warnings or symptoms prior to the failure. I have informed Volvo of the issue but have not yet taken to a dealer for service.

The contact owns a 2019 Volvo XC40. The contact stated while at a stop sign or a stop light, the engine revved loudly, and the vehicle suddenly lunged forward out of control. There were no warning lights illuminated. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 7,600.

The component that failed was the Brake pedal, it was unresponsive while driving on the freeway, it was hard to push and the vehicle would not come to a complete stop. My safety along with my daughter was put at risk due to nearly colliding into several vehicles due to not being able to stop vehicle. I had to tow the vehicle to the nearest shop where it is currently. During the incident the brake light came on. The shop where the vehicle is currently is stating that it appears to have a faulty Brake Vacuum Pump.

The contact owns a 2019 Volvo XC40. The contact stated that the gear shifter knob had detached. The contact stated that the knob was not welded to the lever. The contact became aware that crazy glue had been used to secure the shifter knob. The contact stated that the vehicle failed to shift into gear; and while parking the vehicle, the gear shifter detached. The contact used the button to start the vehicle. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed and confirmed that the gear shifter knob was glued on. The knob was reglued; however, after going through a car wash, the knob detached again. The vehicle was repaired, but the failure recurred. The dealer informed the contact that the vehicle would be held for 24 hours to see if the glue would hold the part in place. The dealer informed the contact that the gear shifter might have to be replaced. The manufacturer was contacted and opened a case, but no additional assistance was provided. The failure mileage was approximately 42,000.

I stopped at a gas station and the fuel door would not open. I tried multiple times locking and unlocking the vehicle with the key fob. As I was driving home, I stopped at three other gas stations. All three times, I still could not open the fuel door. This happened when I initially purchased the car in 2019. I reported it to the Volvo dealer while standing at the gas station. I played with the key fob for about 20 minutes until it finally opened. I remember looking up this issue on the [XXX] and it had been reported numerous times. I stopped in at the Volvo dealership near me. When I told them what was happening, they asked if it was a 2024 XC40. So, the problem exists even in the current year's models. The dealership played around with the key fob, then pried the door open, I assume with a screwdriver, and charged me $50. I could have done that when I got home....for free. There is no option to open the fuel door manually, and there is no option to turn off the fuel door lock - which creates a safety issue! This car runs on gasoline. If I can't fuel my car, I am stuck. There should be an option not to lock the fuel door. I am not worried about anyone siphoning gas. I am worried about traveling on a highway or rural area and not being able to open the fuel door. I guess I'll keep a screwdriver in my car. My 2019 XC40 was the first year the car was introduced. The fact that 2024 models still have the same problem means Volvo knows the problem exists. Their mechanics know as well. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2019 volvos' xc40 center console has been glitching and blacking out while driving. I rely on this system to navigate and when it blacks out, it does not resume operation till I restart my car. I mentioned this while getting my car serviced and was told I needed to pay a $250 fee to get my system updated and I couldn't complete the update on my own. The update can only be completed by an authorized dealer and there is a charge associated with it. This practice is negligent and unacceptable as the lack of updates results in safety concerns and is not just perk. I contacted customer service and they apologized for the inconvenience. This is not an inconvenience, it is negligent and a safety issue.