Vehicle Speed Control. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports1 fire reports5 injury reports

Latches/locks/linkages complaints

2 reports

Clear category filter

Mileage unknown · Oct 24, 2007

Electrical SystemExterior LightingFuel System, Gasoline

Read full complaint

WHILE TRAVELING AT HIGH SPEED ON AN INTERSTATE MY CAR LOST POWER COMPLETELY. I WAS ABLE TO GET TO THE SHOULDER SAFELY AND CALL VOLVO ROADSIDE ASSISTANCE. MY CAR WAS TOWED TO THE NEAREST DEALERSHIP WHERE IT SAT FOR A MONTH BECAUSE THE PROBLEM COULDN'T BE DETERMINED. THE CAR WAS RETURNED TO ME. ABOUT SIX MONTHS LATER THE SAME EXPERIENCE OCCURRED, ONCE AGAIN WHILE TRAVELING AT A HIGH SPEED ON AN INTERSTATE HIGHWAY. THE "PROBLEM" WAS FIXED AGAIN. MY CAR HAS BEEN IN AND OUT OF THE DEALERSHIP FOR VARIOUS REASONS FOR YEARS. WHEN I WAS FINALLY FED UP WITH IT AND DECIDED TO SELL IT, IT NEEDED MORE ELECTRICAL WORK. THE SERVICE MANAGER AT A DEALERSHIP LISTENED TO THE PROBLEMS I HAD WITH THE CAR OVER THE YEARS AND FELT THAT IT WARRANTED A CALL TO THE VOLVO REP. I GAVE HIM ALL WORK ORDERS WHICH I HAVE FROM THE PURCHASE DATE OF THE CAR. HE WAS TOLD BY THE VOLVO REP THAT SINCE ALL REPAIR WORK HAD NOT BEEN DONE AT A VOLVO DEALERSHIP THEY COULDN'T HELP ME. NORMAL WORK SUCH AS OIL CHANGES, ETC. WERE DONE BY A MECHANIC WHO ONLY WORKS ON SAABS AND VOLVOS. UPON LOOKING FOR THE NAMES OF VOLVO EXECS THAT I COULD WRITE A LETTER TO I STUMBLED ON A WEBSITE ABOUT VOLVO PROBLEMS AND PEOPLE WHO WERE TRYING TO HOLD THE COMPANY ACCOUNTABLE FOR MECHANICAL FAILURES OF ANY TYPE. I WROTE TO THE INDIVIDUAL WHO STARTED THE WEBSITE AND HE SUGGESTED THAT I SEND MY E-MAIL TO STEPHEN MCHENRY AT NHTSA WHICH I DID. AFTER TRYING FOR MANY DAYS TO DO SO AND FAILING TO CONNECT BECAUSE OF SOME PROBLEM WITH THE MESSAGE TRYING TO REACH MR. MCHENRY I JUST LET IT GO. WE NEED TO SELL THE CAR BECAUSE WE CAN'T AFFORD TO FIX ALL THAT NEEDS TO BE REPAIRED. THE PROBLEM IS HOW DO I SELL A CAR THAT NEEDS OVER A THOUSAND DOLLARS OF WORK? I AM FORWARDING THE E-MAIL I TRIED TO SEND TO STEPHEN MCHENRY TO YOUR E-MAIL ADDRESS. WHAT CAN I DO? AM I TOO LATE IN REPORTING THIS? WHAT DO YOU ADVISE ME TO DO? THANK YOU FOR YOUR CONSIDERATION. SUSAN K. LUXEM *TR

NHTSA ODI #10206739

10,000 miles · Aug 28, 2003

Electrical SystemEngine And Engine CoolingExterior Lighting

Read full complaint

I WAS RECENTLY TOLD MY 2001 V79XC NEEDED BALL JOINTS, THEN SWAY BARS AND SOMEONE ELSE SAID STRUTS! ALSO: I HAVE HAD THE CAR DIAGNOSED, THE SYSTEM REPORTED THROTTLE MODULE ERRORS AND ELECTIRCAL OR CIRCUIT PROBLEMS; THROTTLE MODULE CLEANED, THEN REPLACED; HEADLIGHTS REPLACED 3 TIMES (WIRING CAUSES SHORTS); GAS FILTER REPLACED TWO JUNES IN A ROW GAS PROPELLED OUT OF THE TANK BACK AT ME UPON PUMPING (SOMETHING ABOUT AIR INTAKE LINE WAS CLOGGED), THE BRACKETS UNDERNEATH THE CAR ARE TOTALLY RUSTED NOT STAINLESS STEEL! I HAD THE COOLING FAN REPLACED, CAR OVERHEATED INTO THE RED! I TOO HAVE HAD LITTLE TIME TO ENJOY MY CAR. THE E BRAKE STICKS IN THE WINTER, BECAUSE THE COATING ON THE LINES/CABLES IS CRACKED, BROKEN/BURNED DUE TO IMPROPER SUSPENSION. MY SUN ROOF, INTERIOR LIGHTS AND REAR HATCH DOOR WORKS INTERMITTENTLY IN COLD WEATHER. THE GLOVE COMPARTMENT WAS RATTLING LOUDLY AND THE DEALER I BOUGHT IT FROM TRIED TO FIX IT AND TOLD ME I HAD TO LIVE WITH IT! OF COURSE ANOTHER DEALERSHIP FIXED IT OUTRIGHT. THE SEATBELT FREQUENTLY STICKS AND DOESNT TAKE UP THE SLACK INTERMITTENTLY ONLY TO GET SHUT IN THE DRIVERS DOOR FREQUENTLY, WHEN I JUST ABOUT THINK IT HAS CORRECTED ITSELF. AND, THERE IS A STRANGE DRAFT ON THE FRONT PASSENGER SIDE WINDOW THAT GETS QUITE COLD IN THE WINTER. THE SEAL SEEMS FINE AND ITS ANOTHER PROBLEM NO SHOP SEEMS TO KNOW ANYTHING ABOUT.

NHTSA ODI #10036737

Official recalls

04V451000 · Engine And Engine Cooling:cooling System:fan

Sep 13, 2004

ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.

Consequence & remedy

Consequence: A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.

Remedy: DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA05021 · Throttle Control Malfunction

Opened Dec 6, 2005 · Closed Dec 12, 2006

Status: closed (inferred from source dates) · Vehicle Speed Control

ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.

PE05041 · Throttle Control Malfunction

Opened Jul 26, 2005 · Closed Dec 7, 2005

Status: closed (inferred from source dates) · Vehicle Speed Control

PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.