WHILE OPERATING THE SUBJECT VEHICLE, A VOLVO 1999 MODEL V70R AWD, AND ATTEMPTING A LEFT HAND TURN THROUGH TRAFFIC UNDER A GREEN LIGHT, THE THROTTLE CONTROL SYSTEM FAILED. AS THE ONCOMING TRAFFIC CLEARED SUFFICIENTLY FOR A SAFE LEFT HAND TURN, THE ACCELERATOR PEDAL WAS DEPRESSED TO EXECUTE THE LEFT TURN BUT THE ENGINE AND VEHICLE…
Read full complaint
WHILE OPERATING THE SUBJECT VEHICLE, A VOLVO 1999 MODEL V70R AWD, AND ATTEMPTING A LEFT HAND TURN THROUGH TRAFFIC UNDER A GREEN LIGHT, THE THROTTLE CONTROL SYSTEM FAILED. AS THE ONCOMING TRAFFIC CLEARED SUFFICIENTLY FOR A SAFE LEFT HAND TURN, THE ACCELERATOR PEDAL WAS DEPRESSED TO EXECUTE THE LEFT TURN BUT THE ENGINE AND VEHICLE DID NOT RESPOND. THE VEHICLE ONLY IDLED FORWARD INTO APPROACHING TRAFFIC. THE VEHICLE HAD TO BE TURNED OFF AND RESTARTED IN ORDER TO GET THE THROTTLE TO RESPOND. IN MY OPINION, THIS FAILURE IS EQUIVALENT TO THE THROTTLE CABLE SNAPPING ON A FOUR YEAR OLD VEHICLE WITH ONLY 60,000 MILES. IF THE RATE OF INCIDENCE OF OCCURRENCE IS SOMEHOW REPRESENTED BY THE NUMBER OF COMPLAINTS EVIDENT ON THE WORLD WIDE WEB, THEN THIS IS A COMMON OCCURRENCE. IT IS LIKELY THAT PROPERTY AND PEOPLE HAVE BEEN HURT BY THIS THROTTLE FAILURE AND THIS PROBLEM SHOULD BE CORRECTED BY A RECALL. *JB
NHTSA ODI #10064428
Mileage unknown · Oct 21, 2002
Vehicle Speed Control
ABS BRAKE, CHECK ENGINE LIGHT, TRANSMISSION LIGHTS ALL CAME ON. THIRD TIME IN 11 MONTHS. FIRST SERVICE WAS A SOFT WARE PATCH. HARDWARE REPLACED LAST WEEK AND SAME PROBLEM HAPPENED AGAIN. MANUFACTURER UNWILLING TO ASSIST WITH PROBLEM. DT
NHTSA ODI #768700
Mileage unknown · May 25, 2001
Vehicle Speed Control
I WAS ON HIGHIWAY 5 IN SAN DIEGO. I SET THE CRUISE CONTROL AT 65MPH. WHEN I APPROACHED A CONGESTED AREA, I MANUALLY PUSHED THE CRUISE CONTROL SWITCH TO THE "OFF" POSITION. WITH THE CRUISE CONTROL IN THE "OFF" POSITION I CONTINUED DRIVING THROUGH THE CONGESTED AREA. AS I WAS LEAVING THE CONGESTED AREA, I DECIDED THIS WOULD BE…
Read full complaint
I WAS ON HIGHIWAY 5 IN SAN DIEGO. I SET THE CRUISE CONTROL AT 65MPH. WHEN I APPROACHED A CONGESTED AREA, I MANUALLY PUSHED THE CRUISE CONTROL SWITCH TO THE "OFF" POSITION. WITH THE CRUISE CONTROL IN THE "OFF" POSITION I CONTINUED DRIVING THROUGH THE CONGESTED AREA. AS I WAS LEAVING THE CONGESTED AREA, I DECIDED THIS WOULD BE AN IDEAL TIME TO PUSH THE CRUISE CONTROL SWITCH INTO THE "ON" POSITION, IN PREPARATION FOR DRIVING AT THE HIGHER ALLOWED 65MPH SPEED LIMIT. WHILE TRAVELLING AT 30MPH I PUSHED THE CRUISE CONTROL SWITCH INTO THE "ON" POSITION. AS THE CAR WAS NEW TO ME, I DID NOT RECOGNIZE THAT THERE IS NO CLEAR DETENT SIGNIFYING THE "ON" POSITION. UNKNOWNINGLY I 'OVERPUSHED' THE SWITCH FROM THE "OFF" POSITION, PASS THE "ON" POSITION, INTO THE "RESUME" POSITION (THINKING THAT THIS OUGHT TO BE THE "ON" POSITION). I REMOVED MY FINGER FROM THE SWITCH AND IMMEDIATELY THE CAR BEGAN ACCELERATING (I LATER CAME TO REALIZE IT WAS ACCELERATING TO 65MPH, THE SETTING PRIOR TO THE SWITCH BEING TURNED OFF). MY COMPLAINT IS THAT WHEN I PUSHED THE SWITCH INTO THE "OFF" POSITON, ALL PRIOR CRUISE CONTROL SETTINGS SHOULD HAVE BEEN ERADICATED (AS IT DOES IN MY GM TRUCK AND PREVIOUS CARS I DROVE). A DRIVER, AS I DID, NOT KNOWING THAT THE CRUISE CONTROL MEMORY DOES NOT CLEAR WHEN THE SWITCH IS PUSHED INTO THE "OFF" POSITION, COULD EXPERIENCE AN UNCONTROLLED ACCELERATION AND A RESULTING COLLISION WHEN THE SWITCH IS PUSHED BEYOND THE "ON" POSITION. AN INDIVIDUAL, AS I, HAVING DRIVEN A GM VEHICLE WITH FACTORY INSTALLED CRUISE CONTROL CONTROL IS USED TO HAVING THE "OFF" POSITION SEPARATING THE "RESUME" AND "ON" POSITIONS SO THAT THE OPERATOR MUST SELECT A DISTINCT, EXCLUSIVE MOTION FOR "OFF" "ON" AND "RESUME". *AK
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, OVER AN EXTENDED PERIOD OF TIME, THE HEADLIGHT SWITCH MAY CEASE TO FUNCTION.
Consequence & remedy
Consequence: THE HEAD LIGHTS MAY NOT OPERATE PROPERLY WHICH COULD RESULT IN INTERMITTENT OR NO HEADLIGHT FUNCTION. THIS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: ON VEHICLES WITH AN ORIGINAL OEM SWITCH, DEALERS WILL REPLACE THE HEADLIGHT SWITCH. ALL OTHER VEHICLES WILL BE INSPECTED TO DETERMINE IF THE SWITCH HAS EEN DAMAGED AND REPLACE ONLY IF NECESSARY. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THERE COULD BE INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET WHICH COULD CAUSE THE FRONT TURN SIGNAL NOT TO FUNCTION AS DESIGNED.
Consequence & remedy
Consequence: THIS WOULD FAIL TO WARN AN APPROACHING DRIVER THAT THE VEHICLE IS TURNING AND COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT TURN SIGNAL BULB AND SOCKET.
VEHICLE DESCRIPTION: STATION WAGONS EQUIPPED WITH THIRD SEATS. USERS OF THE THIRD SEAT, WHEN EXITING THE VEHICLE, CAN COME IN CONTACT WITH THE TAILPIPE.
Consequence & remedy
Consequence: CONTACT WITH THE TAILPIPE CAN RESULT IN PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE LENGTH OF THE VEHICLE'S TAILPIPE AND, IF NECESSARY, REPAIR THE TAILPIPE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Additional source detail variants (2)
Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Exterior Lighting:headlights
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
PE00031 · Turn Signal
Opened Aug 15, 2000 · Closed Dec 22, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE99040 · Inadvertent Side Air Bag Deployment
Opened Jun 7, 1999 · Closed Oct 27, 1999
Status: closed (inferred from source dates) · Air Bags:side/window
No summary supplied.
1999 Volvo V70 Problems, Complaints & Recalls | Skip That Year
Illustration