Forward Collision Avoidance. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

What owners actually said

3 reports

Mileage unknown · May 26, 2026

Forward Collision Avoidance

Read full complaint

While driving on a rainy day my forward collision warning (FCW) system cam on signifying and impending collision via the "Red Warning Vehicle Crash" in the heads-up display. The car started to automatically break as well. There were no other vehicles in my land or close to me at the time. It was purely heavy rain. This is not the first occurrence of the FCW system engaging automatically. The same situation occurs during heavy rains or if water splashes from the other land in front of the car. The situation seems similar to the Hyundai recall just issued by NHSTA https://static.nhtsa.gov/odi/rcl/2026/RCLRPT-26V316-9486.pdf Luckily I have avoided being rear ended as no one has been close to me or they have been able to react to the sudden unexpected deceleration of my vehicle without my intervention or desire to do so. I ask NHTSA to broaden its investigation into other vehicles as this seems to be an issue across vehicle platforms and manufacturers.

NHTSA ODI #11740086

Mileage unknown · Aug 23, 2022

Forward Collision Avoidance

Read full complaint

On 8/22 while driving on a city road in extreme rainy conditions the vehicle in front of me drove through standing water, which created significant spray. As a result the City Safety feature of my Volvo S90 engaged in an extreme fashion. Without any risk of an impending collision the City Safety feature determined the water spray to be an obstacle and fully engaged the brakes (ABS event) to avoid the impending collision including engaging seat-belt pre-tensioning. I was lucky as the drive behind me was paying attention and swerved to avoid rear ending my abruptly stopping vehicle without any intervention from me as the driver. I believe that the issue was caused due to the City Safety system incorrectly detecting the water spray as an impeding crash. This seems to be a system calibration that could have been addressed during development. I wanted to notify NHTSA of this situation so you can be aware and monitor the impact of these driver assist features on overall road safety.

NHTSA ODI #11480704

Mileage unknown · Dec 7, 2021

Service BrakesSuspensionWheels

- Brakes, Wheels, and possibly suspension. - Car shudders under braking, impacts stopping ability. All tires vibrate while driving. Wheels are warped/damaged. - Vehicle went to the dealer. Replaced all four rotors, repaired all for rims. - I have reached out to the manufacturer for support. They declined to get involved. - No m…

Read full complaint

NHTSA ODI #11442995

Official recalls

25V179000 · Electrical System:propulsion System:traction Battery; Electrical System:software

Mar 24, 2025

Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.

Consequence & remedy

Consequence: A short circuit in a high-voltage battery increases the risk of a fire.

Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.

Additional source detail variants (2)

Electrical System:propulsion System:traction Battery

Consequence: A short circuit in a high-voltage battery increases the risk of a fire.

Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.

Electrical System:software

Consequence: A short circuit in a high-voltage battery increases the risk of a fire.

21V414000 · Electrical System:wiring:fuses And Circuit Breakers; Fuel System, Gasoline:delivery:fuel Pump

Jun 2, 2021

Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.

Consequence & remedy

Consequence: Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.

Remedy: Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.

Additional source detail variants (2)

Electrical System:wiring:fuses And Circuit Breakers

Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.

Consequence: Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.

Remedy: Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.

Fuel System, Gasoline:delivery:fuel Pump

Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.

Consequence: Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.

20V144000 · Forward Collision Avoidance: Automatic Emergency Braking; Forward Collision Avoidance:software:pedestrian/cyclist/object/obstacle/ Recognition

Mar 12, 2020

Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.

Consequence & remedy

Consequence: If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.

Remedy: Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.

Additional source detail variants (2)

Forward Collision Avoidance: Automatic Emergency Braking

Consequence: If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.

Remedy: Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.

Forward Collision Avoidance:software:pedestrian/cyclist/object/obstacle/ Recognition

Consequence: If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.