Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 16 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Latches/locks/linkages. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Wheels. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
16 reports
75,000 miles · May 9, 2022
Electrical System
The contact owns a 2018 Volvo S90. The contact stated that the Vehicle Connectivity Module (VCM) had an error causing the Telematics and Driver Support Systems to function improperly. The contact stated the "Volvo on Call Service Required" warning light was illuminated. The contact had taken the vehicle to a local dealer, where …
Read full complaint
The contact owns a 2018 Volvo S90. The contact stated that the Vehicle Connectivity Module (VCM) had an error causing the Telematics and Driver Support Systems to function improperly. The contact stated the "Volvo on Call Service Required" warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the software installed in the Vehicle Connectivity Module (VCM) needed to be updated. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 18V800000 (Electrical System). The manufacturer had been informed of the failure. The failure mileage was approximately 75,000.
NHTSA ODI #11463882
Mileage unknown · Aug 17, 2021
Unknown Or OtherVehicle Speed ControlWheels
Hi, When you drive over 70mph, steering, floors and whole cabin start vibrates, I have changed tires as Volvo recommended, alignment done. Everything dealer requested I have done. I have driven couple of more volvo as a loaners and noticed they all vibrates , but not bad as mine. Try to reach out Volvo head office but no proper …
Read full complaint
Hi, When you drive over 70mph, steering, floors and whole cabin start vibrates, I have changed tires as Volvo recommended, alignment done. Everything dealer requested I have done. I have driven couple of more volvo as a loaners and noticed they all vibrates , but not bad as mine. Try to reach out Volvo head office but no proper resolution. They are keep blaming tires which I have changed 3 times but actually vibration happen from engine or somewhere else. Lots of Volvo owners online shares same issues online. Please help me out on this matter.
NHTSA ODI #11429514
Mileage unknown · Sep 15, 2020
Structure
2018 VOLVO S-90. CONSUMER WRITES IN REGARDS TO A PRODUCT FLAW. *LD THE CONSUMER STATED THE VEHICLES FLOOR MAT HAD UNSNAPPED AND BECOME WEDGED UNDER THE ACCELERATOR PEDAL. THE CONSUMER WAS UNABLE TO DRIVE FORWARD OR IN REVERSE. *JS
NHTSA ODI #11354712
47,778 miles · Jul 15, 2019
Unknown Or Other
I PURCHASED A VOLVO S90 2018 FROM ECAR ONE . ON JULY 6 2019. I WAS TOLD BY THE SALEMAN VIRGIL . THAT THERE WAS A RECALL ON THE DASHBOARD AND ALL I HAVE TO DO WAS CALL VOLVO DEALERSHIP AND THEY WOULD FIX FOR FREE. WHEN I CALLED VOLVO AFTER MY PURCHASE THEY SAID NO RECALL ON THIS VEHICLE. 0709
NHTSA ODI #11232055
100 miles · May 27, 2019
Service Brakes
WHILE DRIVING AT LOW SPEEDS THERE IS A LOUD SCREECHING SOUND WHEN BREAKING. THE DEALERSHIP HAS HAD THE CAR IN FOR REPAIR 4 TIMES, THE CURRENT MILEAGE IS 10,100. THE DEALERSHIP HAS NOT TOLD US WHAT IS THE ISSUE BUT THE NOISE REMAINS. I AM CONCERNED BECAUSE I DRIVE WITH MY KIDS AND THEIR FRIENDS IN THE CAR AND WE HAVE NO INFORMA…
Read full complaint
WHILE DRIVING AT LOW SPEEDS THERE IS A LOUD SCREECHING SOUND WHEN BREAKING. THE DEALERSHIP HAS HAD THE CAR IN FOR REPAIR 4 TIMES, THE CURRENT MILEAGE IS 10,100. THE DEALERSHIP HAS NOT TOLD US WHAT IS THE ISSUE BUT THE NOISE REMAINS. I AM CONCERNED BECAUSE I DRIVE WITH MY KIDS AND THEIR FRIENDS IN THE CAR AND WE HAVE NO INFORMATION ON WHAT IS GOING ON WITH THE BREAKS. WE DO NOT KNOW IF THE CAR IS A SAFETY HAZARD SINCE THEY HAVE TOLD US NOTHING. WE HAVE MANY AUDIOS WITH THE NOISE, WHICH THE DEALERSHIP RMCHOOSES TO IGNORE BUT THE NOISE PERSISTS AFTER EACH REPAIR. WE ARE AFRAID THEY ARE HIDING THE REAL ISSUE AND IT MAY BE DANGEROUS.
NHTSA ODI #11210221
Mileage unknown · Apr 11, 2018
EngineFuel/propulsion System
TL* THE CONTACT OWNS A 2018 VOLVO S90. THE CONTACT STATED THAT THE SERVICE ENGINE INDICATOR ILLUMINATED. IN ADDITION, THE FUEL MILEAGE WAS LESS THAN WHAT WAS STATED IN THE OWNER'S MANUAL. THE VEHICLE WAS TAKEN TO THE DEALER (GUNTHER VOLVO CARS COCONUT CREEK, 4300 SR 7, COCONUT CREEK, FL 33073, (954) 590-3760) MORE THAN TWICE FOR…
Read full complaint
TL* THE CONTACT OWNS A 2018 VOLVO S90. THE CONTACT STATED THAT THE SERVICE ENGINE INDICATOR ILLUMINATED. IN ADDITION, THE FUEL MILEAGE WAS LESS THAN WHAT WAS STATED IN THE OWNER'S MANUAL. THE VEHICLE WAS TAKEN TO THE DEALER (GUNTHER VOLVO CARS COCONUT CREEK, 4300 SR 7, COCONUT CREEK, FL 33073, (954) 590-3760) MORE THAN TWICE FOR DIAGNOSTIC TESTING AND TO BE TEST DRIVEN, BUT THERE WAS NO PERMANENT REMEDY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND HAD NOT ISSUED ANY RECALLS. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Volvo Car USA LLC (Volvo) is recalling certain 2018-2019 XC60 and S90 vehicles. The driver and passenger front seat rail rear flange nuts may not have been installed during assembly.
Consequence & remedy
Consequence: If the nuts are missing, in the event of a crash, the front seat structure and position may be affected, increasing the risk of injury.
Remedy: Volvo will notify owners, and dealers will inspect the front seat rails for missing flange nuts, installing them as necessary, free of charge. The recall began May 7, 2019. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R19931.
Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improperly. As a result, the GPS will not provide location information to emergency personnel in the event of an emergency.
Consequence & remedy
Consequence: If the GPS location is not provided to emergency personnel it can inhibit emergency response in the event of a crash or injury.
Remedy: Volvo will notify owners, and dealers will correct the software, free of charge. The recall began December 26, 2018. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R39917.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2018 Volvo S90 Problems, Complaints & Recalls | Skip That Year
Illustration