2002 Volvo S60

TAKATA RECALL [XXX]. FOR MY SSN NUMBER, DRIVER LICENSE NUMBER CALL ME FOR THAT INFORMATION I DON'T LIKE TO PUT IT ON WEBSITE SO THAT OTHER PEOPLE CAN GET IT BUT HERE'S MY VIN [XXX] EMAIL IS [XXX] THE WHOLE DASHBOARD MY LIGHTS WON'T COME ON THE KEY WONT COME OUT I HAVE TO WAIT 5 OR 10 MIN TO WAIT FOR IT TO COME OUT IT SMELL LIKE GAS SOMETIMES THE KEYLESS WONT WORK I CHANGE THE THANG IN THE BACK FIVE TIMES IN ONE MONTH THE GEAR SOMETIME DON'T WORK. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2002 VOLVO S60. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE WENT INTO LIMP MODE AND FAILED TO ACCELERATE OVER 30 MPH. THE CONTACT ALSO STATED THAT THE ACCELERATION PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE VEHICLE FAILED TO ACCELERATE AND SUDDENLY SURGED FORWARD. THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED WHEN THE FAILURE OCCURRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V441000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

TL* THE CONTACT OWNS A 2002 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE THROTTLE FAILED. THE CONTACT STATED THAT SHE TRIED TO ENGAGE THE ACCELERATOR PEDAL BUT THE VEHICLE WOULD NOT MOVE. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSE THAT THE ELECTRONIC THROTTLE MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO STATED THAT ALTHOUGH THE VEHICLE WAS INCLUDED IN RECALL NHTSA CAMPAIGN ID NUMBER: 06V441000 (VEHICLE SPEED CONTROL) IT WAS NO LONGER ELIGIBLE SINCE THE VEHICLE HAD SURPASSED THE STATUE OF LIMITATION. THE FAILURE MILEAGE WAS 140,000.

PURCHASED USED S60 IN NOVEMBER 2011 WITH 137,000 MILES. A FEW WEEKS LATER VARIOUS PROBLEMS MANIFESTED: SCRAMBLED LETTERS IN DASHBOARD MESSAGE, DRIVER DOOR LOCKS INTERMITTENTLY WORKED, RADIO SELF TUNED TO DIFFERENT STATION, SPEEDOMETER GIVING FALSE READINGS OR STUCK AT CURRENT SPEED OR READING ZERO, FUEL GAUGE MALFUNCTION, ALL INSTRUMENTS ON PANEL FLICKERED, ALL INSTRUMENTS WENT "DARK" WHILE DRIVING. AT FIRST RESTARTING CAR WOULD CLEAR PROBLEM. THEN FREQUENCY BETWEEN FAILURES INCREASED. JUST BEFORE COMPLETE FAILURE - CAR NEEDED TO BE "COLD" FOR INSTRUMENTS TO WORK - WITH INSTRUMENTS FAILING ONCE ENGINE WARMED. FINALLY IN FEBRUARY 2012 AT ABOUT 147,021 MILES THE PANEL COMPLETELY FAILED WHILE DRIVING - GIVING DRIVER NO READINGS (SPEED, FUEL, TEMP, MILEAGE, OR WARNING INDICATORS) AND WOULD NOT RESET. INTERNET FORUMS OF VOLVO OWNERS SUGGESTED IT WAS A DRIVER INFORMATION MODULE FAILURE. OWNERS FORUMS PINPOINTED 3 PROBABLE CAUSES OF A DIM FAILURE - 1. LOOSE CONNECTION OF THE MOTOROLA MICROCHIP, 2. LOOSE CAPACITOR/RESISTOR 3. LACK OF PROTECTION FROM HEAT/HEAT TRANSFER TO INDIVIDUAL PRONGS IN MICROCHIP OR BETWEEN CAPACITOR/RESISTOR AND THE CIRCUIT BOARD. SOME ELECTRICALLY SAVVY OWNERS FIXED BY REFLOWING/RESOLDERING/HEAT PROTECTING SAID COMPONENTS. OUR LOCAL VOLVO DEALER CONFIRMED DIM FAILURE AND QUOTED APROX. $1500 FOR A NEW INSTRUMENT CLUSTER AND 3 HRS. LABOR. WE CHOSE TO SEND DIM/INSTRUMENT CLUSTER OUT FOR A REFURBISHMENT TO BAA REMANUFACTURING INC. ON REINSTALLATION WARNING MESSAGE READ "SRA/AIRBAG-SERVICE URGENT". ASKED DEALER TO CLEAR DIM CODE FIRST, THEN FROM SRS MODULE PER BAA-REMAN INSTRUCTIONS. DEALER JOB DESCRIPTION/RECEIPT STATED THEY CLEARED CODES DIM 0001, 0003, 0005, 0006, E003, SRS 00D4, E003. NO PROBLEMS WITH LOCKS/RADIO/INSTRUMENT CLUSTER SINCE REMANUFACTURE IN THE LAST 10,000 MILES/5 MONTHS. VOLVO'S ORIGINAL DIM CIRCUIT BOARD POORLY DESIGNED/ASSEMBLED. *TR

TL* THE CONTACT OWNS A 2002 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 60 MPH THE VEHICLE WOULD GO INTO LIMP MODE AND DECELERATE TO 15 MPH UNEXPECTEDLY. THE FAILURE RECURRED ON AN INTERMITTENT BASIS. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 06V441000 (VEHICLE SPEED CONTROL). BOTH THE DEALER AND MANUFACTURER DENIED ASSISTANCE WITH THE REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 133,000 AND THE CURRENT MILEAGE WAS 135,000.

I WAS STOPPED AT STOP LIGHT WAITING TO TURN LEFT. UPON LIGHT TURNING GREEN, I ACCELERATED TO TURN LEFT. CAR, WITHOUT WARNING, LOST ACCELERATION, STEERING, AND BRAKING AS IF IN LIMP HOME MODE. I WAS ABLE TO PULL THE CAR OVER TO THE SIDE OF THE ROAD. I THEN PUT CAR IN PARK AND TURNED OFF ENGINE. CAR STARTED BACK UP AND DROVE WITHOUT INCIDENT. THERE WERE NO INDICATOR LIGHTS. TOOK CAR TO LOCAL GARAGE AND NO CODES CAME UP. THEN AGAIN ON MARCH 23, 2011 CAR AGAIN LOST ALL ACCELERATION AND STEERING. THIS TIME THE CAR WAS BEING DRIVEN APPROXIMATELY 40 MPH. NO WARNING INDICATORS WERE LIT. PUT CAR INTO PARK AND IT STARTED WITHOUT INCIDENT. TOOK CAR TO DEALER ON MARCH 25, 2011. THE DEALER SAID NO CODES CAME UP AND THEY WERE HAVING TROUBLE DIAGNOSING THE FAILURE. AFTER 4 DAYS THEY CALLED TO TELL ME IT COULD BE THE MASS AIR FLOW SENSOR AND THROTTLE BODY NEEDED TO BE CLEANED (COST $660). HOWEVER, THEY COULD NOT SAY FOR SURE IF THIS WAS THE CAUSE OF THE FAILURE. I AM GETTING THE SUGGESTED REPAIRS DONE. HOWEVER AFTER READING THE NUMEROUS COMPLAINTS DESCRIBING THIS SAME FAILURE, I FEEL VERY UNEASY ABOUT DRIVING MY CAR. VOLVO NEEDS TO ADDRESS THESE NUMEROUS COMPLAINTS AS THIS IS A MAJOR SAFETY CONCERN. I DRIVE MY CAR WITH TWO SMALL KIDS IN THE BACK SEAT EVERYDAY. I AM TERRIFIED THIS FAILURE WILL HAPPEN AGAIN. THERE WAS A RECALL ON MY MODEL AND YEAR CAR FOR THIS TYPE OF FAILURE, HOWEVER MY VIN IS NOT INCLUDED.

TL*THE CONTACT OWNS A 2002 VOLVO S60. THE CONTACT STATED THAT THE ETM PARTS FOR THE THROTTLE MODULE MOVED INTO LIMP MODE WHICH MADE THE VEHICLE DRIVE SLOWLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE ETM PARTS WERE REPLACED BUT AFTER A COUPLE DAYS, THE FAILURE OCCURRED AGAIN. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THEY WOULD UPGRADE THE SOFTWARE WHICH WOULD FIX THE PROBLEM. THE UPGRADE WAS PERFORMED BUT THE FAILURE OCCURRED AGAIN. THE VEHICLE HAD NOT BEEN REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 40,598 AND THE CURRENT MILEAGE WAS 88,892. UPDATED 04/25/11 *BF UPDATED 12/19/2011 *LN

TL*THE CONTACT OWNS A 2002 VOLVO S60. WHILE THE VEHICLE WAS STOPPED AND THE CONTACT ATTEMPTED TO ACCELERATE, THE VEHICLE SHIFTED INTO LIMP HOME MODE. THE VEHICLE WOULD ONLY MOVE 5 MPH. THE CONTACT TURNED THE VEHICLE OFF AND RESTARTED IT; IT PERFORMED CORRECTLY AFTER THE RESTART. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER THREE TIMES WHERE THE SOFTWARE AS UPDATE AND THE THROTTLE MODULAR AND MASS AIR FLOWS WERE REPLACED. THE CONTACT REFERENCED RECALL 06V441000 (VEHICLE SPEED CONTROL) WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 98,000.