IllustrationTERRIBLE GAS SMELL EVERY TIME I DRIVE IT. I GOT SOMEONE TO CHECK IT OUT, THERE IS GAS LEAKING FROM THE FUEL PUMP. THIS PERSON PUT SOME PUTTY OVER THE LEAK WHICH STOPPED THE SMELL BUT THIS IS NOT SAFE. I SEE A RECALL FOR THE FUEL PUMP BUT IT SAYS MY CAR DOESN'T HAVE A CURRENT RECALL.
2001 Volvo S60
Owner reports · Recalls · Investigations
More warning signs than most S60 years
Owner complaints for the 2001 Volvo S60 are substantially higher than the model-year median of 20.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all S60 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
1725–50K
5150–75K
3675–100K
36100–150K
23150K+
178 reports with mileage · 45 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports5 fire reports2 injury reports
Fuel/propulsion System complaints
16 reportsTL* THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL FROM THE TOP OF THE FUEL TANK AND FUEL PUMP. THE CONTACT CALLED THE MANUFACTURER AFTER RESEARCHING THE FAILURE AND WAS INFORMED THAT THERE WAS NO RECALL. THE MANUFACTURER FURTHER STATED THAT THE FAILURE OCCURRED IN STATES IN WARMER ZONES …
Read full complaint
TL* THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL FROM THE TOP OF THE FUEL TANK AND FUEL PUMP. THE CONTACT CALLED THE MANUFACTURER AFTER RESEARCHING THE FAILURE AND WAS INFORMED THAT THERE WAS NO RECALL. THE MANUFACTURER FURTHER STATED THAT THE FAILURE OCCURRED IN STATES IN WARMER ZONES THAN THE CONTACT'S STATE, AND DISCONNECTED THE CALL. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE FAILURE MILEAGE WAS 220,000.
EXTREME GAS SMELL INSIDE CAR. NOTICED GAS LEAKING FROM TOP OF TANK BY THE SCREWS THAT HOLD IT. VEHICLE WAS PARKED IN MY DRIVE WAY AND AS SOON AS MY KIDS GOT IN THEY NOTICED THE STRONG SMELL. NOT DRIVING IT DEFENETLY CAN CAUSE A FIRE.
I HAVE NOTICED A STRONG FUEL ODOR INSIDE AND OUTSIDE OF CAR. IT IS ALSO LEAKING FUEL. THE FUEL LEAKING IS UNDERNEATH THE CAR. I DO NOT KNOW EXACTLY WHERE FUEL IS LEAKING. IT IS NOT COMING FROM FUEL FILTER.
TL* THE CONTACT OWNS A 2001 VOLVO S60. WHILE THE VEHICLE WAS PARKED, A STRONG ODOR OF FUEL WAS NOTICED. THE CONTACT OBSERVED FUEL LEAKING FROM AN UNKNOWN PART OF THE FUEL TANK. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND V…
Read full complaint
TL* THE CONTACT OWNS A 2001 VOLVO S60. WHILE THE VEHICLE WAS PARKED, A STRONG ODOR OF FUEL WAS NOTICED. THE CONTACT OBSERVED FUEL LEAKING FROM AN UNKNOWN PART OF THE FUEL TANK. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.
TL* THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT NOTICED A FUEL ODOR INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THERE WAS A FUEL LEAK WITH THE FUEL PUMP. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF TH FAIL…
Read full complaint
TL* THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT NOTICED A FUEL ODOR INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THERE WAS A FUEL LEAK WITH THE FUEL PUMP. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF TH FAILURE. THE FAILURE MILEAGE WAS 155,000.
TL* THE CONTACT OWNS A 2001 VOLVO S60. WHILE DRIVING AT 20 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE COULD BE RESTARTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE W…
Read full complaint
TL* THE CONTACT OWNS A 2001 VOLVO S60. WHILE DRIVING AT 20 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE COULD BE RESTARTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
TL* THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED, THERE WAS A ODOR OF FUEL INSIDE THE VEHICLE WITHOUT WARNING. THE FAILURE RECURRED EACH TIME THE VEHICLE WAS STARTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE FUEL PUMP HAD FRACTURED AND NEEDED TO BE REP…
Read full complaint
TL* THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED, THERE WAS A ODOR OF FUEL INSIDE THE VEHICLE WITHOUT WARNING. THE FAILURE RECURRED EACH TIME THE VEHICLE WAS STARTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE FUEL PUMP HAD FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 78,000.
TL* THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT STATED THAT FUEL WAS SEEPING FROM THE TANK NEAR THE PUMP AND ONTO THE GROUND. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000.
TL* THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT STATED THAT A GASOLINE ODOR WAS PROMINENT AROUND THE VEHICLE. THE VEHICLE WAS NOT TAKEN FOR DIAGNOSIS OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 94,489.
Official recalls
821V766000 · Air Bags:frontal:driver Side:inflator Module
Sep 30, 2021
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.
20V681000 · Air Bags:frontal:driver Side:inflator Module
Nov 4, 2020
Volvo Car USA LLC (Volvo Car) is recalling certain 2001-2003 S80 and S60 vehicles sold or ever registered in Alabama, Arkansas, Florida, Georgia, Hawaii, Louisiana, Mississippi, North Carolina, Oklahoma, South Carolina, Tennessee, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. The driver side frontal air bag inflator may rupture, sending metal fragments into the passage compartment, when the driver side air bag is deployed.
Consequence & remedy
Consequence: Metal fragments can strike vehicle occupants increasing the risk of serious injury or death.
Remedy: Volvo Car will notify owners, and dealers will replace the driver side air bag module, free of charge. The recall began April 20, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10058.
10V566000 · Equipment:electrical:navigational System(global Positioning System)
Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
09V483000 · Fuel System, Gasoline:delivery:fuel Pump
Dec 18, 2009
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
07V152000 · Fuel System, Gasoline:delivery:fuel Pump
Apr 5, 2007
ON CERTAIN VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA, DUE TO THE COMBINATION OF FUEL QUALITY AND CLIMATE CONDITIONS, THE FUEL PUMP MAY, IN CERTAIN CASES, EXPERIENCE A REDUCED FUNCTIONALITY. THE MOST COMMON SYMPTOMS WOULD BE FUEL ODOR.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP FREE OF CHARGE. THE RECALL BEGAN ON JULY 10, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
06V441000 · Vehicle Speed Control
Nov 15, 2006
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
04V451000 · Engine And Engine Cooling:cooling System:fan
Sep 13, 2004
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
03V284000 · Equipment:other:labels
Aug 1, 2003
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRECT.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL RECEIVE A LETTER/PACKAGE CONSISTING OF THE SECOND ISOFIX GUIDE WITH INSTALLATION INSTRUCTIONS, AND IN CERTAIN CASES, THE CORRECTED OWNER'S MANUAL MAY BE PROVIDED. IF THE OWNER WANTS TO TAKE THEIR VEHICLE TO A VOLVO DEALER FOR INSTALLATION OF THE GUIDE, IT WILL BE PERFORMED AT NO CHARGE TO THE OWNER. OWNER NOTIFICATION BEGAN ON DECEMBER 19, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE06053 · Fuel Pump Leakage
Opened Nov 15, 2006 · Closed Apr 5, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:storage:tank Assembly
VOLVO IS RECALLING APPROXIMATELY 1,681 MODEL YEAR (MY) 2001-2002 S60 VEHICLES WITHIN THE STATES OF ARIZONA AND NEVADA TO REPLACE THE FUEL PUMP.VOLVO REPORTS THAT THE FUEL PUMP IN THESE VEHICLES MAY EXPERIENCE A FUEL LEAK AS A RESULT OF FUEL QUALITY AND HOT CLIMATE CONDITIONS.THE MOST COMMON SYMPTOM REPORTED IS FUEL SMELL.NO FIRES, CRASHES OR INJURIES ARE REPORTED.MY 2003 AND LATER S60 VEHICLES CONTAIN A DIFFERENT DESIGN FUEL PUMP.DATA FROM VOLVO INDICATES THAT A HIGHER RATE OF FUEL PUMP ODOR AND/OR LEAKAGE EXISTS WITH VEHICLES REGISTERED IN THE HOT STATES OF ARIZONA AND NEVADA.WARRANTY DATA SHOWS MANY MORE FUEL PUMP CLAIMS FOR MY 2001 AND 2002 (244 AND 140) COMPARED WITH MY 2003, 04, 05 AND 06 (18, 3, 4, AND 1 RESPECTIVELY).FURTHERMORE, THE FUEL PUMP WARRANTY CLAIM ACTIVITY IS HIGHEST IN THE STATES OF ARIZONA AND NEVADA (25% AND 10%) COMPARED WITH THE REMAINDER OF THE US (0.16%) BASED ON VEHICLE SALES POPULATION IN THESE AREAS.FOR ADDITION DETAILS SEE RECALL 07V152.THIS INVESTIGATION IS CLOSED
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
VOLVO IS RECALLING APPROXIMATELY 1,681 MODEL YEAR (MY) 2001-2002 S60 VEHICLES WITHIN THE STATES OF ARIZONA AND NEVADA TO REPLACE THE FUEL PUMP.VOLVO REPORTS THAT THE FUEL PUMP IN THESE VEHICLES MAY EXPERIENCE A FUEL LEAK AS A RESULT OF FUEL QUALITY AND HOT CLIMATE CONDITIONS.THE MOST COMMON SYMPTOM REPORTED IS FUEL SMELL.NO FIRES, CRASHES OR INJURIES ARE REPORTED.MY 2003 AND LATER S60 VEHICLES CONTAIN A DIFFERENT DESIGN FUEL PUMP.DATA FROM VOLVO INDICATES THAT A HIGHER RATE OF FUEL PUMP ODOR AND/OR LEAKAGE EXISTS WITH VEHICLES REGISTERED IN THE HOT STATES OF ARIZONA AND NEVADA.WARRANTY DATA SHOWS MANY MORE FUEL PUMP CLAIMS FOR MY 2001 AND 2002 (244 AND 140) COMPARED WITH MY 2003, 04, 05 AND 06 (18, 3, 4, AND 1 RESPECTIVELY).FURTHERMORE, THE FUEL PUMP WARRANTY CLAIM ACTIVITY IS HIGHEST IN THE STATES OF ARIZONA AND NEVADA (25% AND 10%) COMPARED WITH THE REMAINDER OF THE US (0.16%) BASED ON VEHICLE SALES POPULATION IN THESE AREAS.FOR ADDITION DETAILS SEE RECALL 07V152.THIS INVESTIGATION IS CLOSED
Fuel System, Gasoline:storage:tank Assembly
VOLVO IS RECALLING APPROXIMATELY 1,681 MODEL YEAR (MY) 2001-2002 S60 VEHICLES WITHIN THE STATES OF ARIZONA AND NEVADA TO REPLACE THE FUEL PUMP.VOLVO REPORTS THAT THE FUEL PUMP IN THESE VEHICLES MAY EXPERIENCE A FUEL LEAK AS A RESULT OF FUEL QUALITY AND HOT CLIMATE CONDITIONS.THE MOST COMMON SYMPTOM REPORTED IS FUEL SMELL.NO FIRES, CRASHES OR INJURIES ARE REPORTED.MY 2003 AND LATER S60 VEHICLES CONTAIN A DIFFERENT DESIGN FUEL PUMP.DATA FROM VOLVO INDICATES THAT A HIGHER RATE OF FUEL PUMP ODOR AND/OR LEAKAGE EXISTS WITH VEHICLES REGISTERED IN THE HOT STATES OF ARIZONA AND NEVADA.WARRANTY DATA SHOWS MANY MORE FUEL PUMP CLAIMS FOR MY 2001 AND 2002 (244 AND 140) COMPARED WITH MY 2003, 04, 05 AND 06 (18, 3, 4, AND 1 RESPECTIVELY).FURTHERMORE, THE FUEL PUMP WARRANTY CLAIM ACTIVITY IS HIGHEST IN THE STATES OF ARIZONA AND NEVADA (25% AND 10%) COMPARED WITH THE REMAINDER OF THE US (0.16%) BASED ON VEHICLE SALES POPULATION IN THESE AREAS.FOR ADDITION DETAILS SEE RECALL 07V152.THIS INVESTIGATION IS CLOSED
Fuel System, Gasoline
VOLVO IS RECALLING APPROXIMATELY 1,681 MODEL YEAR (MY) 2001-2002 S60 VEHICLES WITHIN THE STATES OF ARIZONA AND NEVADA TO REPLACE THE FUEL PUMP.VOLVO REPORTS THAT THE FUEL PUMP IN THESE VEHICLES MAY EXPERIENCE A FUEL LEAK AS A RESULT OF FUEL QUALITY AND HOT CLIMATE CONDITIONS.THE MOST COMMON SYMPTOM REPORTED IS FUEL SMELL.NO FIRES, CRASHES OR INJURIES ARE REPORTED.MY 2003 AND LATER S60 VEHICLES CONTAIN A DIFFERENT DESIGN FUEL PUMP.DATA FROM VOLVO INDICATES THAT A HIGHER RATE OF FUEL PUMP ODOR AND/OR LEAKAGE EXISTS WITH VEHICLES REGISTERED IN THE HOT STATES OF ARIZONA AND NEVADA.WARRANTY DATA SHOWS MANY MORE FUEL PUMP CLAIMS FOR MY 2001 AND 2002 (244 AND 140) COMPARED WITH MY 2003, 04, 05 AND 06 (18, 3, 4, AND 1 RESPECTIVELY).FURTHERMORE, THE FUEL PUMP WARRANTY CLAIM ACTIVITY IS HIGHEST IN THE STATES OF ARIZONA AND NEVADA (25% AND 10%) COMPARED WITH THE REMAINDER OF THE US (0.16%) BASED ON VEHICLE SALES POPULATION IN THESE AREAS.FOR ADDITION DETAILS SEE RECALL 07V152.THIS INVESTIGATION IS CLOSED
EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.